柔性玻璃的化学强化及其力学性能研究

硅酸盐通报 ›› 2024, Vol. 43 ›› Issue (4): 1359-1365.

• “玻璃材料与玻璃技术”专题(II) • 上一篇下一篇

柔性玻璃的化学强化及其力学性能研究

毛婧怡¹, 刘冰¹, 郭振强², 张家昌¹, 袁坚^1,2

1.武汉理工大学硅酸盐建筑材料国家重点实验室,武汉 430070;
2.河北省沙河玻璃技术研究院,邢台 054199

收稿日期:2023-11-03 修订日期:2024-01-02 出版日期:2024-04-15 发布日期:2024-04-17
通信作者: 袁坚,博士,教授。E-mail:janeyuan@whut.edu.cn
作者简介:毛婧怡(1999—),女,硕士研究生。主要从事柔性玻璃的研究。E-mail:1489970205@qq.com
基金资助:
国家重点研发计划(2022YFB3603300)

Chemical Strengthening and Mechanical Properties of Flexible Glass

MAO Jingyi¹, LIU Bing¹, GUO Zhenqiang², ZHANG Jiachang¹, YUAN Jian^1,2

1. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China;
2. Shahe Research Institute of Glass Technology, Xingtai 054199, China

Received:2023-11-03 Revised:2024-01-02 Online:2024-04-15 Published:2024-04-17

摘要/Abstract

摘要： 具有高弯曲强度的柔性玻璃是柔性电子显示的重要组成部分,但柔性玻璃本质是脆性材料,因此其力学性能仍然不能满足使用要求。化学强化是提高柔性玻璃弯曲半径、抗划伤性等力学性能的有效途径,本文采用一步化学强化法,将90 μm超薄高铝柔性玻璃在纯硝酸钾熔盐中进行强化,研究离子交换工艺对样品表面应力、维氏硬度及弯曲半径的影响规律。结果表明:在380 ℃进行1 h的离子交换后,样品的表面压应力达834.1 MPa,应力层深度为15.91 μm,此时玻璃具有最佳的弯曲性能和耐划伤性;经化学强化后,90 μm柔性玻璃的最小弯曲半径可由(29.8±0.73) mm降低至(6.94±0.99) mm;随着继续升高交换温度和延长时间,柔性玻璃的力学性能会有所降低。

关键词: 化学强化, 柔性玻璃, 表面应力, 离子交换深度, 弯曲半径, 维氏硬度

Abstract: Flexible glass with high bending strength is a remarkable component of flexible electronic displays. However, flexible glass is a brittle material inherently, and its mechanical properties still do not meet the requirements of application. To address this challenge, the application of chemical strengthening stands out as a viable approach to significantly bolster scratch resistance and bending strength in flexible glass. 90 μm ultra-thin high-aluminum flexible glass was reinforced in the molten potassium nitrate using a conventional one-step chemical strengthening method. The effect laws of chemical strengthening temperature and time on the surface stress, Vickers hardness and bending radius of the strengthened flexible glass were investigated. The results indicate that, after ion-exchange at 380 ℃ for 1 h, the compressive stress of sample reaches 834.12 MPa, and the depth of stress layer is 15.91 μm, at which time the glass samples have the best bending performance and scratch resistance. After chemical strengthening, the bending radiu of 90 μm flexible glass reduces from (29.8±0.73) mm to (6.94±0.99) mm. As the overly increasing exchange temperature and excessive prolongation of time, the mechanical properties of flexible glass are weakened.

Key words: chemical strengthening, flexible glass, surface stress, ion-exchange depth, bending radiu, Vickers hardness

中图分类号:

TQ171

毛婧怡, 刘冰, 郭振强, 张家昌, 袁坚. 柔性玻璃的化学强化及其力学性能研究[J]. 硅酸盐通报, 2024, 43(4): 1359-1365.

MAO Jingyi, LIU Bing, GUO Zhenqiang, ZHANG Jiachang, YUAN Jian. Chemical Strengthening and Mechanical Properties of Flexible Glass[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2024, 43(4): 1359-1365.

参考文献

[1] MACRELLI G, VARSHNEYA A K, MAURO J C. Ultra-thin glass as a substrate for flexible photonics[J]. Optical Materials, 2020, 106: 109994.
[2] GARNER S, GLAESEMANN S, LI X H. Ultra-slim flexible glass for roll-to-roll electronic device fabrication[J]. Applied Physics A, 2014, 116(2): 403-407.
[3] TAMAGAKI H, IKARI Y, OHBA N. Roll-to-roll sputter deposition on flexible glass substrates[J]. Surface and Coatings Technology, 2014, 241: 138-141.
[4] WANG Z, GUAN T H, REN T F, et al. Effect of normal scratch load and HF etching on the mechanical behavior of annealed and chemically strengthened aluminosilicate glass[J]. Ceramics International, 2020, 46(4): 4813-4823.
[5] LI L, LIN H T, MICHON J, et al. A new twist on glass: a brittle material enabling flexible integrated photonics[J]. International Journal of Applied Glass Science, 2017, 8(1): 61-68.
[6] VARSHNEYA A K, UNIVERSITY A. Recent advances in the chemical strengthening of glass[J]. Physics and Chemistry of Glasses: European Journal of Glass Science and Technology Part B, 2017, 58(4): 127-132.
[7] OVERLY S. Stronger smartphone screens coming with Gorilla Glass 5[J]. Toronto Star (Canada), 2016.
[8] EGBOIYI B, MATTEY R, KONICA S, et al. Mechanistic understanding of the fracture toughening in chemically strengthened glass—experiments and phase-field fracture modeling[J]. International Journal of Solids and Structures, 2022, 238: 111374.
[9] MACRELLI G, MAURO J C, VARSHNEYA A K. Coupling of diffusion and chemical stress: the case of ion exchange in glass[J]. Journal of the American Ceramic Society, 2021, 104(11): 5599-5613.
[10] HE F, JOTZ M, WEGENER H, et al. Towards flexible glass: ultra-thin glass with tight dimensional tolerance and high strength achieved by ion exchange[J]. SID Symposium Digest of Technical Papers, 2017, 48(1): 218-221.
[11] GULATI S T, WESTBROOK J, CARLEY S, et al. 45.2: two point bending of thin glass substrate[J]. SID Symposium Digest of Technical Papers, 2011, 42(1): 652-654.
[12] TANG Z Z, LOWER N P, GUPTA P K, et al. Using the two-point bend technique to determine failure stress of pristine glass fibers[J]. Journal of Non-Crystalline Solids, 2015, 428: 98-104.
[13] GOMEZ S, DEJNEKA M J, ELLISON A J, et al. A look at the chemical strengthening process: Alkali aluminosilicate glasses vs. soda-lime glass[J]. 71st Conference on Glass Problems: Ceramic Engineering and Science Proceedings, 2011, 32: 61-66.
[14] NUNES B, PINHO I, CRUZ FERNANDES J, et al. Mechanical properties of ion-exchanged alkali aluminosilicate glass[J]. International Journal of Applied Glass Science, 2023, 14(1): 155-164.
[15] AKIBA S. Ultra-thin chemically strengthened cover glasses for foldable devices[J]. SID Symposium Digest of Technical Papers, 2017, 48(1): 222-225.
[16] ZHANG Y M, LI B B, LI D, et al. Microstructure, cytocompatibility, and chemical durability of chemically strengthened LAS (Li₂O-Al₂O₃-SiO₂) glass-ceramic materials[J]. Journal of the European Ceramic Society, 2022, 42(13): 6110-6118.
[17] ERDEM , GULDIREN D, AYDIN S. Chemical tempering of soda lime silicate glasses by ion exchange process for the improvement of surface and bulk mechanical strength[J]. Journal of Non-Crystalline Solids, 2017, 473: 170-178.
[18] JOSHI D, KITTLESON A P, HARRIS J T. Probability of failure and weibull size-scaling parameters for thin glass subjected to two-point bending[J]. Journal of the European Ceramic Society, 2022, 42(16): 7609-7619.
[19] JIANG L B, WANG Y, MOHAGHEGHIAN I, et al. Subcritical crack growth and lifetime prediction of chemically strengthened aluminosilicate glass[J]. Materials & Design, 2017, 122: 128-135.

柔性玻璃的化学强化及其力学性能研究

Chemical Strengthening and Mechanical Properties of Flexible Glass

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	郑伟宏, 刘国凤, 张浩, 王启东, 张梦豪, 袁坚. Li₂O/Na₂O对YAS微晶玻璃结构、析晶与力学性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1292-1300.
[2]	田英良, 韩金龙, 徐博, 温玉琳, 李培浩, 何峰, 赵志永. 组成对钠铝硅玻璃中钇锆酸盐纳米晶析晶性能的影响[J]. 硅酸盐通报, 2024, 43(2): 710-718.
[3]	田英良, 袁智淳, 赵志永, 穆广涵, 何峰. 废液晶玻璃再生制备低膨胀硼硅玻璃及其理化性能研究[J]. 硅酸盐通报, 2024, 43(1): 354-362.
[4]	申常胜, 王瑞强, 李镔, 韦中华, 陈松, 陈波, 王卫国, 张伟儒. 氮化硅陶瓷的注射成型工艺研究[J]. 硅酸盐通报, 2023, 42(8): 2915-2921.
[5]	田昊东, 徐驰, 许少坤, 周绍骏, 曹文龙, 祖成奎. 玻璃化学强化技术研究进展[J]. 硅酸盐通报, 2022, 41(7): 2502-2510.
[6]	武振飞, 王跃超, 陆丽芳, 张弘毅. 无压烧结氮化硅陶瓷的物理性能研究[J]. 硅酸盐通报, 2022, 41(5): 1782-1787.
[7]	廖伟帆, 胡传杰, 王明忠, 郭云岚, 崔秀珍, 梁新辉, 刘超. 超薄铝硅玻璃离子交换工艺研究[J]. 硅酸盐通报, 2022, 41(4): 1163-1169.
[8]	李溦长, 王欣, 胡丽丽, 陈树彬, 陈辉宇, 张旭丰, 蒋晓琦. 高强度Li₂O-Al₂O₃-SiO₂体系微晶玻璃研究进展[J]. 硅酸盐通报, 2022, 41(11): 3795-3805.
[9]	周卫卫, 陈宝, 郝振邦, 何光园, 朱凯迪, 刘景仲, 张福军, 张继红. Li₂O-Al₂O₃-SiO₂高强度半透光微晶玻璃晶化及机械性能研究[J]. 硅酸盐通报, 2022, 41(11): 3813-3818.
[10]	韩韩, 彭瑞欣, 李筱凡, 赵会峰, 姜宏, 马艳平. LAS微晶玻璃在离子交换后的去结晶相变化及机械性能表征[J]. 硅酸盐通报, 2021, 40(9): 3138-3144.
[11]	王涛, 储洪强, 丁天云, 朱正宇, 曾有旭, 谢嘉璇, 蒋林华. 复杂环境下粉煤灰水泥石的离子浓度分布与维氏硬度劣化规律[J]. 硅酸盐通报, 2021, 40(12): 4011-4019.
[12]	郭振强;袁坚;淮旭光;王瑞璞;张长军;王兵兵;陈向阳. 柔性玻璃制备及加工技术进展[J]. 硅酸盐通报, 2020, 39(2): 585-591.
[13]	祝佳祺, 毛汉褀, 张正君, 孙建宁, 李婧雯, 林焱剑, 乔芳建, 张欢. 氧化锆对微通道板用铅硅玻璃结构和性能的影响[J]. 硅酸盐通报, 2020, 39(12): 4010-4015.
[14]	刘锡宇, 何峰, 陈七, 张树岩, 张卓恒, 谢峻林. 熔盐K2CO3含量对超薄玻璃化学钢化性能的影响研究[J]. 硅酸盐通报, 2019, 38(7): 2314-2320.
[15]	宋学锋;白超. 化学强化剂对再生骨料及再生混凝土性能的影响研究[J]. 硅酸盐通报, 2019, 38(6): 1748-175.