热疲劳作用对混凝土力学性能及微观结构的影响

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (3): 825-832.

热疲劳作用对混凝土力学性能及微观结构的影响

肖帅鹏¹, 李宗利^1,2, 张国辉³, 李常兵³, 刘士达¹, 李云波¹

1.西北农林科技大学水利与建筑工程学院,杨凌 712100;
2.西北农林科技大学旱区农业水土工程教育部重点实验室,杨凌 712100;
3.昆明理工大学电力工程学院,昆明 650500

收稿日期:2021-11-01 修回日期:2022-01-08 出版日期:2022-03-15 发布日期:2022-04-08
通讯作者: 李宗利,博士,教授。E-mail:zongli02@163.com
作者简介:肖帅鹏(1995—),男,硕士研究生。主要从事混凝土材料耐久性方面的研究。E-mail:510214539@qq.com
基金资助:
“十三五”国家重点研发计划(2017YFC405101);国家自然科学基金(51379178)

Effect of Thermal Fatigue on Mechanical Properties and Microstructure of Concrete

XIAO Shuaipeng¹, LI Zongli^1,2, ZHANG Guohui³, LI Changbing³, LIU Shida¹, LI Yunbo¹

1. College of Water Resources and Architectural Engineering, Northwest A&F University, Yangling 712100, China;
2. Key Laboratory of Agricultural Soil and Water Engineering in Arid and Semiarid Areas, Ministry of Education, Northwest A&F University, Yangling 712100, China;
3. Faculty of Electric Power Engineering, Kunming University of Science and Technology, Kunming 650500, China

Received:2021-11-01 Revised:2022-01-08 Online:2022-03-15 Published:2022-04-08

摘要/Abstract

摘要： 我国西北地区日、年温差大,混凝土经历着温差产生的热疲劳劣化。保持环境湿度恒定,在20 ℃、30 ℃、40 ℃温差下开展两种强度等级的混凝土热疲劳试验,测定其抗压强度、劈裂抗拉强度等宏观性能变化规律;通过超声无损检测技术和压汞试验测定微观结构。结果表明:热疲劳劣化效应明显,随循环温差的增大和循环次数增加,混凝土强度下降明显,C40混凝土下降幅度大于C25混凝土,且劈裂抗拉强度较抗压强度对热疲劳作用更敏感;超声波速呈减小趋势,说明混凝土内部裂隙缺陷增多;同一循环温差下,混凝土的孔隙率、孔隙总体积、平均孔径、中值孔径、最可几孔径随温差循环次数增加而增大,孔隙总表面积减小,孔隙结构表现出粗化的特征且呈劣化的趋势,C40混凝土的孔隙率小于C25混凝土,但其孔隙率相对变化值更大,从微观层面揭示了混凝土在热疲劳作用下强度损伤的内在原因。

关键词: 混凝土, 恒湿环境, 热疲劳, 强度劣化, 超声无损检测技术, 微观结构

Abstract: The daily and annual temperature differences in northwest China vary greatly, which leads to thermal fatigue deterioration of concrete. Under the condition of constant environmental humidity, the thermal fatigue tests of concrete with two strength grades were carried out at the temperature difference of 20 ℃, 30 ℃ and 40 ℃ to measure the changes of the macroscopic properties such as compressive strength and splitting tensile strength. The microstructure changes of concrete were measured by ultrasonic nondestructive technology and mercury intrusion porosimetry test. The results show that the thermal fatigue degradation effect is obvious. With the increase of temperature difference and number of temperature difference cycles, the concrete strength decreases obviously. The decrease of C40 concrete is greater than that of C25 concrete, and the splitting tensile strength is more sensitive to thermal fatigue than compressive strength. The ultrasonic velocity decreases, which indicates that the internal defects of concrete increase. The porosity, total pore volume, average pore diameter, medium pore diameter and the most probable pore diameter of concrete increase with the increase of temperature difference and number of cycles, while the total pore surface area decreases, which indicates that the pore structure shows the characteristic of coarsening and a tendency to deteriorate. The porosity of C40 concrete is smaller than that of C25 concrete, but the relative change value of the porosity of C40 is larger, which reveals the internal reason for strength damage of concrete under thermal fatigue from the microscopic level.

Key words: concrete, constant humidity, thermal fatigue, strength degradation, ultrasonic nondestructive technology, microstructure

中图分类号:

TU528

肖帅鹏, 李宗利, 张国辉, 李常兵, 刘士达, 李云波. 热疲劳作用对混凝土力学性能及微观结构的影响[J]. 硅酸盐通报, 2022, 41(3): 825-832.

XIAO Shuaipeng, LI Zongli, ZHANG Guohui, LI Changbing, LIU Shida, LI Yunbo. Effect of Thermal Fatigue on Mechanical Properties and Microstructure of Concrete[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(3): 825-832.

参考文献

[1] 朱伯芳.大体积混凝土温度应力与温度控制[M].北京:中国电力出版社,1999.
ZHU B F. Thermal stresses and temperature control of mass concrete[M]. Beijing: China Electric Power Press, 1999 (in Chinese).
[2] NORRIS A, SAAFI M, ROMINE P. Temperature and moisture monitoring in concrete structures using embedded nanotechnology/microelectromechanical systems (MEMS) sensors[J]. Construction and Building Materials, 2008, 22(2): 111-120.
[3] 王树和,水中和,玄东兴.大温差环境条件下混凝土表面裂缝损伤[J].东南大学学报(自然科学版),2006,36(S2):122-125.
WANG S H, SHUI Z H, XUAN D X. Investigation on surface cracking damage of concrete under big temperature difference[J]. Journal of Southeast University (Natural Science Edition), 2006, 36(S2): 122-125 (in Chinese).
[4] 赵燕茹,刘芳芳,王磊,等.基于孔结构的单面冻后混凝土抗压强度模型研究[J].建筑材料学报,2020,23(6):1328-1336+1344.
ZHAO Y R, LIU F F, WANG L, et al. Modeling of compressive strength of concrete based on pore structure under single-side freeze-thaw condition[J]. Journal of Building Materials, 2020, 23(6): 1328-1336+1344 (in Chinese).
[5] 张卫东,董云,彭宁波,等.冻融循环下透水再生混凝土力学性能损伤分析[J].建筑材料学报,2020,23(2):292-296.
ZHANG W D, DONG Y, PENG N B, et al. Analysis on mechanical properties of pervious recycled concrete by damage under freeze-thaw cycles[J]. Journal of Building Materials, 2020, 23(2): 292-296 (in Chinese).
[6] NADEEM A, MEMON S A, LO T Y. The performance of fly ash and Metakaolin concrete at elevated temperatures[J]. Construction and Building Materials, 2014, 62: 67-76.
[7] 褚洪岩,孙伟,蒋金洋.高温作用下牺牲混凝土的损伤演化[J].硅酸盐学报,2016,44(2):211-217.
CHU H Y, SUN W, JIANG J Y. Damage evolution of sacrificial concrete subjected to elevated temperatures[J]. Journal of the Chinese Ceramic Society, 2016, 44(2): 211-217 (in Chinese).
[8] 韩明明.热疲劳作用对高性能混凝土强度与渗透性能的影响研究[D].北京:北京交通大学,2016.
HAN M M. Effect of thermal fatigue on strength and permeability of high performance concrete[D]. Beijing: Beijing Jiaotong University, 2016 (in Chinese).
[9] AN M Z, HUANG H F, WANG Y, et al. Effect of thermal cycling on the properties of high-performance concrete: microstructure and mechanism[J]. Construction and Building Materials, 2020, 243: 118310.
[10] SHOKRIEH M M, HEIDARI-RARANI M, SHAKOURI M, et al. Effects of thermal cycles on mechanical properties of an optimized polymer concrete[J]. Construction and Building Materials, 2011, 25(8): 3540-3549.
[11] AL-TAYYIB A J, BALUCH M H, SHARIF A F M, et al. The effect of thermal cycling on the durability of concrete made from local materials in the Arabian Gulf countries[J]. Cement and Concrete Research, 1989, 19(1): 131-142.
[12] WALKER S, BLOEM D L, MULLEN W G. Effects of temperature changes on concrete as influenced by aggregates[J]. American Concrete Institute, 1952, 48(4): 661-679.
[13] 王康,张玉平,章杰,等.大温差环境下混凝土抗热疲劳性能研究[J].建材世界,2018,39(1):18-21.
WANG K, ZHANG Y P, ZHANG J, et al. Research on thermal fatigue resistance of concrete under large temperature difference condition[J]. The World of Building Materials, 2018, 39(1): 18-21 (in Chinese).
[14] ZHANG G H, LI Z L, ZHANG L F, et al. Experimental research on drying control condition with minimal effect on concrete strength[J]. Construction and Building Materials, 2017, 135: 194-202.
[15] 邵化建,李宗利,肖帅鹏,等.干湿循环作用下混凝土力学性能及微观结构研究[J].硅酸盐通报,2021,40(9):2948-2955.
SHAO H J, LI Z L, XIAO S P, et al. Mechanical properties and microstructure of concrete under drying-wetting cycles[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(9): 2948-2955 (in Chinese).
[16] KANELLOPOULOS A, FARHAT F A, NICOLAIDES D, et al. Mechanical and fracture properties of cement-based bi-materials after thermal cycling[J]. Cement and Concrete Research, 2009, 39(11): 1087-1094.
[17] 韩进生,李宗利,张国辉,等.不同强度等级混凝土等温干燥脱水规律[J].建筑材料学报,2018,21(6):963-968.
HAN J S, LI Z L, ZHANG G H, et al. Isothermal drying and dehydration of concrete with different strength grades[J]. Journal of Building Materials, 2018, 21(6): 963-968 (in Chinese).
[18] DU X Q, LI Z L, HAN J S, et.al. Effect of different humidity-controlling modes on microstructure and compressive behavior of ordinary concrete[J]. Journal of Materials in Civil Engineering, 2020, 32(1): 04019337.
[19] 姚武,郑欣.配合比参数对混凝土热膨胀系数的影响[J].同济大学学报(自然科学版),2007,35(1):77-81+87.
YAO W, ZHENG X. Effect of mix proportion on coefficient of thermal expansion of concrete[J]. Journal of Tongji University (Natural Science), 2007, 35(1): 77-81+87 (in Chinese).
[20] TANG S W, HUANG J S, DUAN L, et al. A review on fractal footprint of cement-based materials[J]. Powder Technology, 2020, 370: 237-250.
[21] 吴中伟,廉慧珍.高性能混凝土[M].北京:中国铁道出版社,1999.
WU Z W, KANG H Z. High performance concrete[M]. Beijing: China Railway Publishing House, 1999 (in Chinese).