CoFeMgAl-LDHs/CNTs复合材料对水泥水化及微观结构的影响

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (1): 3-12.

所属专题：水泥混凝土

CoFeMgAl-LDHs/CNTs复合材料对水泥水化及微观结构的影响

廖牧情^1,2,3, 熊志文^1,2,3, 柯国军^1,2,3, 邹品玉^1,2,3, 宋百姓^1,2,3, 金丹^1,2,3

1.南华大学土木工程学院,衡阳 421001;
2.中国核建高性能混凝土实验室,衡阳 421001;
3.高性能特种混凝土湖南省重点实验室,衡阳 421001

收稿日期:2021-09-04 修订日期:2021-11-10 出版日期:2022-01-15 发布日期:2022-02-10
通信作者: 柯国军,教授。E-mail:1132980799@qq.com
作者简介:廖牧情(1997—),男,硕士研究生。主要从事高性能混凝土及固体废渣利用的研究。E-mail:383782245@qq.com
基金资助:
湖南省自然科学基金衡阳联合项目(2019JJ60003)

Effect of CoFeMgAl-LDHs/CNTs Composite Material on Hydration and Microstructure of Cement

LIAO Muqing^1,2,3, XIONG Zhiwen^1,2,3, KE Guojun^1,2,3, ZOU Pinyu^1,2,3, SONG Baixing^1,2,3, JIN Dan^1,2,3

1. School of Civil Engineering, University of South China, Hengyang 421001, China;
2. China Nuclear Construction Key Laboratory of High Performance Concrete, Hengyang 421001, China;
3. Hunan Provincial Key Laboratory of High Performance Special Concrete, Hengyang 421001, China

Received:2021-09-04 Revised:2021-11-10 Online:2022-01-15 Published:2022-02-10

摘要/Abstract

摘要： 通过进行水化热测试、非蒸发水含量测试、X射线衍射分析、扫描电镜分析、压汞测试及强度试验,研究了钴铁镁铝水滑石-碳纳米管复合材料(CoFeMgAl-LDHs/CNTs)对水泥水化过程、硬化水泥净浆孔结构及强度的影响。结果表明,CoFeMgAl- LDHs/CNTs复合材料通过成核作用显著提升了水泥3 d内的水化程度,从而显著提高了水泥净浆3 d内的抗压强度,3 d后强度提高效果逐渐减小,7 d后复合材料对硬化水泥浆体强度没有明显的提高作用。掺入CoFeMgAl-LDHs/CNTs复合材料的水泥净浆与空白净浆相比,胶凝孔和毛细孔含量明显增多,大孔含量有所降低,同时复合材料的桥联作用进一步优化了水泥净浆的微观结构,从而提高了水泥基体薄弱部位的应力承载能力。因此在同一龄期,复合材料掺入后硬化水泥净浆的强度有所增大。由于复合材料掺量的变化对孔径分布没有明显的影响,改变复合材料的掺量对同龄期硬化水泥净浆强度提升影响较小。

关键词: 钴铁镁铝水滑石-碳纳米管, 水泥净浆, 水化, 孔结构, 强度, 成核作用, 桥联作用

Abstract: Heat of hydration test, non-evaporating water content test, X-ray diffraction analysis, scanning electron microscope analysis, mercury intrusion test and compressive strength tests were used to investigate the effect of the Co-Fe-Mg-Al hydrotalcite carbon nanotubes (CoFeMgAl-LDHs/CNTs) composite material on the hydration process, pore structure and strength of hardened cement paste. The results show that CoFeMgAl-LDHs/CNTs composite material significantly improves the hydration degree of cement within 3 d through nucleation, and thereby significantly enhances the compressive strength of the cement paste in the age of 3 d, the effect of improving the strength gradually reduces after 3 d and become unobvious after 7 d. Compare with blank cement paste, the content of gel pore and capillary pore in hardened cement paste increase obviously, while the macro pore decreases. At the same time, bridging effect of composite material optimizes microstructure of cement paste, and increase the stress bearing capacity of weak parts of cement matrix. Therefore, at the same age, the strength of hardened cement paste is increased. Because the change of composite content has no obvious effect on the change of pore size distribution, the change of composite content has little effect on the strength improvement of hardened cement paste at the same age.

Key words: Co-Fe-Mg-Al hydrotalcite carbon nanotubes, cement paste, hydration, pore structure, strength, nucleation, bridging effect

中图分类号:

TU525

廖牧情, 熊志文, 柯国军, 邹品玉, 宋百姓, 金丹. CoFeMgAl-LDHs/CNTs复合材料对水泥水化及微观结构的影响[J]. 硅酸盐通报, 2022, 41(1): 3-12.

LIAO Muqing, XIONG Zhiwen, KE Guojun, ZOU Pinyu, SONG Baixing, JIN Dan. Effect of CoFeMgAl-LDHs/CNTs Composite Material on Hydration and Microstructure of Cement[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 3-12.

参考文献

[1] 夏远英,陈景,熊骁辉,等.绿色混凝土发展途径的探讨[J].混凝土,2011(4):101-104+117.
XIA Y Y, CHEN J, XIONG X H, et al. Discussion on the development of green concrete[J]. Concrete, 2011(4): 101-104+117 (in Chinese).
[2] RUAN Y F, HAN B G, YU X, et al. Mechanical behaviors of nano-zirconia reinforced reactive powder concrete under compression and flexure[J]. Construction and Building Materials, 2018, 162: 663-673.
[3] 陆富龙.碳纳米管对水泥基材料的作用机理研究[D].广州:广州大学,2019.
LU F L. Study on the mechanism of carbon nanotubes on cement based materials[D]. Guangzhou: Guangzhou University, 2019 (in Chinese).
[4] MACHNER A, ZAJAC M, BEN HAHA M, et al. Chloride-binding capacity of hydrotalcite in cement pastes containing dolomite and metakaolin[J]. Cement and Concrete Research, 2018, 107: 163-181.
[5] 李海艳,刘小星,司鹤洋,等.纳米类水滑石对硫铝酸盐水泥熟料水化硬化规律的影响[J].硅酸盐学报,2018,46(7):887-894.
LI H Y, LIU X X, SI H Y, et al. Effect of nano-layered double hydroxides on hydration and hardening of calcium sulphoaluminate cement clinker[J]. Journal of the Chinese Ceramic Society, 2018, 46(7): 887-894 (in Chinese).
[6] YANG Z X, FISCHER H, CEREZO J, et al. Aminobenzoate modified MgAl hydrotalcites as a novel smart additive of reinforced concrete for anticorrosion applications[J]. Construction and Building Materials, 2013, 47: 1436-1443.
[7] 宋学锋,张俊涛,崔贺龙,等.热处理水滑石对普通硅酸盐水泥和碱矿渣水泥抗碳化性能的影响[J].硅酸盐通报,2019,38(11):3379-3384.
SONG X F, ZHANG J T, CUI H L, et al. Effect of calcined layered double hydroxides on carbonation resistance of ordinary Portland cement and alkali-activated slag cement[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(11): 3379-3384 (in Chinese).
[8] XU S L, CHEN Z R, ZHANG B W, et al. Facile preparation of pure CaAl-layered double hydroxides and their application as a hardening accelerator in concrete[J]. Chemical Engineering Journal, 2009, 155(3): 881-885.
[9] VULIC T, RUDIC O, VUCETIC S, et al. Photocatalytic activity and stability of TiO₂/ZnAl layered double hydroxide based coatings on mortar substrates[J]. Cement and Concrete Composites, 2015, 58: 50-58.
[10] 崔宏志,杨嘉明,林炅增.碳纳米管分散技术及碳纳米管-水泥基复合材料研究进展[J].材料导报,2016,30(3):91-95.
CUI H Z, YANG J M, LIN J Z. Research progress on carbon nanotubes dispersion techniques and CNTs-reinforced cement-based materials[J]. Materials Review, 2016, 30(3): 91-95 (in Chinese).
[11] WANG B M, PANG B. Properties improvement of multiwall carbon nanotubes-reinforced cement-based composites[J]. Journal of Composite Materials, 2020, 54(18): 2379-2387.
[12] 张淑文,张杰,王贵春,等.碳纳米管对水泥基材料热膨胀性能的影响[J].材料研究学报,2019,33(5):387-393.
ZHANG S W, ZHANG J, WANG G C, et al. Effect of carbon nanotubes on thermal expansion properties of cement-based materials[J]. Chinese Journal of Materials Research, 2019, 33(5): 387-393 (in Chinese).
[13] TYSON B M, ABU AL-RUB R K, YAZDANBAKHSH A, et al. Carbon nanotubes and carbon nanofibers for enhancing the mechanical properties of nanocomposite cementitious materials[J]. Journal of Materials in Civil Engineering, 2011, 23(7): 1028-1035.
[14] 牛荻涛,何嘉琦,傅强,等.碳纳米管对水泥基材料微观结构及耐久性能的影响[J].硅酸盐学报,2020,48(5):705-717.
NIU D T, HE J Q, FU Q, et al. Effect of carbon nanotubes on microstructure and durability of cement-based materials[J]. Journal of the Chinese Ceramic Society, 2020, 48(5): 705-717 (in Chinese).
[15] 李相国,明添,刘卓霖,等.碳纳米管水泥基复合材料耐久性及力学性能研究[J].硅酸盐通报,2018,37(5):1497-1502.
LI X G, MING T, LIU Z L, et al. Research on durability and mechanical properties of carbon nanotube cement matrix composites[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(5): 1497-1502 (in Chinese).
[16] RAKI L, BEAUDOIN J J, MITCHELL L. Layered double hydroxide-like materials: nanocomposites for use in concrete[J]. Cement and Concrete Research, 2004, 34(9): 1717-1724.
[17] 张晨璐,冷然,张一阚,等.锰铝二元水滑石和锰铁铝三元水滑石对U(Ⅵ)的高效去除及其机理研究[J].中国科学:化学,2019,49(1):133-144.
ZHANG C L, LENG R, ZHANG Y K, et al. Interaction of U(Ⅵ) with MnAl and MnFeAl layered double hydroxides: batch and spectroscopy study[J]. Scientia Sinica (Chimica), 2019, 49(1): 133-144 (in Chinese).
[18] 丁娴,殷凡文,彭成栋,等.规整Mn-Zn-Mg-Al-CO₃四元LDHs层状材料的水热合成、结构及性能[J].无机化学学报,2012,28(2):331-341.
DING X, YIN F W, PENG C D, et al. Hydrothermal synthesis, structural analysis and performance of regular Mn-Zn-Mg-Al-CO₃ quaternary layered double hydroxides(LDHs)[J]. Chinese Journal of Inorganic Chemistry, 2012, 28(2): 331-341 (in Chinese).
[19] 翁荔丹,黄雪红.聚羧酸减水剂对水泥水化过程的影响[J].福建师范大学学报(自然科学版),2007,23(1):54-57.
WENG L D, HUANG X H. Influence on cement hydration process by adding polycarboxylic series[J]. Journal of Fujian Normal University (Natural Science Edition), 2007, 23(1): 54-57 (in Chinese).
[20] 赵玉敏,万海勤,许昭怡.碳纳米管吸附还原溴酸盐研究[J].南京大学学报(自然科学),2017,53(2):286-291.
ZHAO Y M, WAN H Q, XU Z Y. Adsorption and reduction of bromate over carbon nanotubes[J]. Journal of Nanjing University (Natural Sciences), 2017, 53(2): 286-291 (in Chinese).
[21] YANG W, GAO Z, WANG J, et al. Solvothermal one-step synthesis of Ni-Al layered double hydroxide/carbon nanotube/reduced graphene oxide sheet ternary nanocomposite with ultrahigh capacitance for supercapacitors[J]. ACS Applied Materials & Interfaces, 2013, 5(12): 5443-5454.
[22] SUN J F, SHI H, QIAN B B, et al. Effects of synthetic C-S-H/PCE nanocomposites on early cement hydration[J]. Construction and Building Materials, 2017, 140: 282-292.
[23] 郑玉飞.低水胶比复合胶凝材料的水化程度及孔结构研究[D].北京:北京交通大学,2018.
ZHENG Y F. Study on hydration degree and pore structure of low water/binde ratio cementitious composites[D]. Beijing: Beijing Jiaotong University, 2018 (in Chinese).
[24] 张朝阳,蔡熠,孔祥明,等.纳米C-S-H对水泥水化、硬化浆体孔结构及混凝土强度的影响[J].硅酸盐学报,2019,47(5):585-593.
ZHANG C Y, CAI Y, KONG X M, et al. Influence of nano C-S-H on cement hydration, pore structure of hardened cement pastes and strength of concrete[J]. Journal of the Chinese Ceramic Society, 2019, 47(5): 585-593 (in Chinese).
[25] CARRIÇO A, BOGAS J A, HAWREEN A, et al. Durability of multi-walled carbon nanotube reinforced concrete[J]. Construction and Building Materials, 2018, 164: 121-133.
[26] IGARASHI S I, WATANABE A, KAWAMURA M. Evaluation of capillary pore size characteristics in high-strength concrete at early ages[J]. Cement and Concrete Research, 2005, 35(3): 513-519.

CoFeMgAl-LDHs/CNTs复合材料对水泥水化及微观结构的影响

Effect of CoFeMgAl-LDHs/CNTs Composite Material on Hydration and Microstructure of Cement

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	朱经纬, 舒众众, 金良茂, 曹志强, 张冲, 郑际杰, 刘涌, 韩高荣. 残余应力分布对基板玻璃落球冲击强度影响的数值模拟研究[J]. 硅酸盐通报, 2024, 43(4): 1267-1273.
[2]	李宁, 赵立革, 赵少伟, 王卉, 郑永超. Ti含量对矿渣玻璃体结构及其水化活性的影响机制研究[J]. 硅酸盐通报, 2024, 43(4): 1325-1334.
[3]	吴江涛, 刘津, 刘玲玲, 徐德生, 金飞凯, 程轶斐, 丁林锋, 王连军. 高反射釉料对不同厚度光伏玻璃断裂强度的影响[J]. 硅酸盐通报, 2024, 43(4): 1350-1358.
[4]	马继树, 杨淑雁. 西北大温差环境下温度对硫铝酸盐水泥砂浆抗压强度的影响[J]. 硅酸盐通报, 2024, 43(4): 1388-1397.
[5]	毛翔, 杨鼎宜, 曹忠露, 赵健, 陈龙祥, 王彤章. 基于图像法对自密实超高性能混凝土性能提升的研究[J]. 硅酸盐通报, 2024, 43(4): 1398-1409.
[6]	张全红, 王涛, 穆松, 蔡佳豪, 刘凯, 周莹, 刘光严. 不同侵蚀环境下喷射混凝土耐久性提升技术及作用机理[J]. 硅酸盐通报, 2024, 43(4): 1410-1419.
[7]	郑述芳, 李华影, 陈祥花, 梁莹, 陈宗平. 粉煤灰掺量对全再生自密实混凝土工作性能与力学性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1445-1454.
[8]	郭强, 张晓雷, 史晨曦, 门杰. 赤泥-矿渣基地聚物固化黄土冻融后力学特性研究[J]. 硅酸盐通报, 2024, 43(4): 1482-1489.
[9]	顾雅洁, 陈瑶姬, 尹旭军, 常星岚, 孙科, 孙盛睿, 奚爽, 许嘉雨, 刘阳桥. 氟化钇对粉煤灰基堇青石陶瓷合成及性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1515-1523.
[10]	付思远, 吕文欣, 韦家崭, 柯善军. 工艺参数对抛光渣轻质陶瓷砖性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1524-1531.
[11]	付弯弯, 劳家岳, 郭柯钰, 陈柳维, 吴世芳, 周薇, 谭晓明, 彭浩. 装配式建筑用聚合物乳液改性套筒灌浆料的制备及性能研究[J]. 硅酸盐通报, 2024, 43(3): 833-843.
[12]	张梦真, 娄广辉, 刘子娴, 蔡基伟, 许鸽龙, 乔一佳, 张祥飞. 硫酸亚铁对铝酸盐水泥浆体性能及水化产物的影响[J]. 硅酸盐通报, 2024, 43(3): 844-850.
[13]	宁慧员, 张菊, 闫长旺, 白茹. 基于高斯过程回归模型的电石渣激发煤矸石地聚合物强度响应预测与分析[J]. 硅酸盐通报, 2024, 43(3): 905-913.
[14]	蒋明屾, 李飞, 周理安, 宁佳蕊, 张政. 碳酸钠、氢氧化钠与水玻璃复合激发对地聚物胶凝材料性能的影响[J]. 硅酸盐通报, 2024, 43(3): 929-937.
[15]	盖珂瑜, 龙勇, 陈露一, 李信, 刘开志, 王宇, 孙涛. 矿物掺合料复掺对超高性能湿接缝混凝土性能的影响[J]. 硅酸盐通报, 2024, 43(3): 948-955.