纳米C-S-H对矿粉-水泥体系水化的影响

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (1): 13-19.

所属专题：水泥混凝土

纳米C-S-H对矿粉-水泥体系水化的影响

徐智东¹, 梅军鹏¹, 王智鑫¹, 廖宜顺¹, 廖国胜¹, 李海南²

1.武汉科技大学城市建设学院,武汉 430065;
2.武汉纺织大学工程造价系,武汉 430200

收稿日期:2021-09-14 修订日期:2021-10-13 出版日期:2022-01-15 发布日期:2022-02-10
通信作者: 梅军鹏,博士,讲师。E-mail:meijunpeng2006@126.com
作者简介:徐智东(1997—),男,硕士研究生。主要从事高性能土木工程材料的研究。E-mail:xvzhidong@163.com
基金资助:
国家自然科学基金(51908434)

Effect of Nano C-S-H on Hydration of Slag Powder-Cement System

XU Zhidong¹, MEI Junpeng¹, WANG Zhixin¹, LIAO Yishun¹, LIAO Guosheng¹, LI Hainan²

1. School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China;
2. Department of Construction Cost, Wuhan Textile University, Wuhan 430200, China

Received:2021-09-14 Revised:2021-10-13 Online:2022-01-15 Published:2022-02-10

摘要/Abstract

摘要： C-S-H是通用硅酸盐水泥主要的水化产物,对水泥基材料的性能起着十分重要的作用,但水泥水化产物复杂,难以从水化产物中分离出纯净的C-S-H并研究其对水泥基材料的影响。故本文通过双分解法制备了纳米C-S-H(NC)颗粒,并将其掺入矿粉-水泥体系中,通过无接触式电阻率测定仪、X射线衍射仪、差热分析仪(DSC-TG)、扫描电镜、压汞测试仪(MIP)等探究了NC对矿粉-水泥体系水化的影响。研究发现,在1%~4%(质量分数)掺量范围内,掺入NC可缩短基体的凝结时间,并为水泥早期水化提供更多的活性位点,加速水化产物的形成和沉淀,促进水化产物之间的搭接,从而降低了基体孔隙率并使基体早期强度和水化浆体电阻率均有所提升。

关键词: 矿粉-水泥体系, 纳米C-S-H, 水化, 电阻率, 早期强度, 孔结构

Abstract: C-S-H is the main hydration product of common Portland cement, which plays a very important role in the properties of cement-based materials. However, the hydration products of cement are complex, and it is difficult to separate pure C-S-H from the hydration products and explore its influence on cement-based materials. Therefore, nano C-S-H (NC) particles were prepared by the double decomposition method in this paper and mixed into the slag powder-cement system. The influence of NC on the hydration of slag powder-cement system was investigated by means of non-contact electrical resistivity measurement, XRD, DSC-TG, SEM, and MIP. Results show that in the range of 1% to 4% (by mass) dosage, the addition of NC shortens the setting time of matrix, and provides more nucleation sites for cement hydration, accelerates the formation and precipitation of hydration products. It also promotes the bond between the hydration products, thus reducing the porosity and increasing the early strength and resistivity of cement matrix composites.

Key words: slag powder-cement system, nano C-S-H, hydration, electrical resistivity, early strength, pore structure

中图分类号:

TU525

徐智东, 梅军鹏, 王智鑫, 廖宜顺, 廖国胜, 李海南. 纳米C-S-H对矿粉-水泥体系水化的影响[J]. 硅酸盐通报, 2022, 41(1): 13-19.

XU Zhidong, MEI Junpeng, WANG Zhixin, LIAO Yishun, LIAO Guosheng, LI Hainan. Effect of Nano C-S-H on Hydration of Slag Powder-Cement System[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 13-19.

参考文献

[1] KUMAR A, WALDER B J, KUNHI M A, et al. The atomic-level structure of cementitious calcium silicate hydrate[J]. The Journal of Physical Chemistry C, 2017, 121(32): 17188-17196.
[2] 雷永胜,韩涛,王慧奇,等.水热合成水化硅酸钙(C-S-H)的制备与表征[J].硅酸盐通报,2014,33(3):465-469.
LEI Y S, HAN T, WANG H Q, et al. Preparation and characterization of calcium silicate hydrate(C-S-H) synthesized by the hydrothermal method[J]. Bulletin of the Chinese Ceramic Society, 2014, 33(3): 465-469 (in Chinese).
[3] 刘新,冯攀,沈叙言,等.水泥水化产物:水化硅酸钙(C-S-H)的研究进展[J].材料导报,2021,35(9):9157-9167.
LIU X, FENG P, SHEN X Y, et al. Advances in the understanding of cement hydrate: calcium silicate hydrate (C-S-H)[J]. Materials Reports, 2021, 35(9): 9157-9167 (in Chinese).
[4] 李遵云,杨林,屠柳青,等.纳米水化硅酸钙对混凝土耐久性的影响[J].混凝土,2013(10):112-114+118.
LI Z Y, YANG L, TU L Q, et al. Effect of nano-calcium silicate hydrate on durability of concrete[J]. Concrete, 2013(10): 112-114+118 (in Chinese).
[5] 王伟山,黄德祥,邓最亮,等.新型晶核型早强剂的性能与早强机理分析[J].新型建筑材料,2016,43(5):9-13.
WANG W S, HUANG D X, DENG Z L, et al. Performance and mechanism analysis of new type of crystal nucleus based hardening accelerator[J]. New Building Materials, 2016, 43(5): 9-13 (in Chinese).
[6] 陈娇,于诚,慕儒,等.纳米水化硅酸钙的制备及对水泥水化影响的研究进展[J].硅酸盐通报,2021,40(5):1429-1440.
CHEN J, YU C, MU R, et al. Research progress on preparation of nano calcium silicate hydrate and its influence on cement hydration[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(5): 1429-1440 (in Chinese).
[7] KANCHANASON V, PLANK J. Effectiveness of a calcium silicate hydrate-polycarboxylate ether (C-S-H-PCE) nanocomposite on early strength development of fly ash cement[J]. Construction and Building Materials, 2018, 169: 20-27.
[8] 陶俊,肖世玉,杨军,等.纳米C-S-H对粉煤灰/矿粉双掺混凝土性能的影响[J].硅酸盐通报,2020,39(10):3267-3272.
TAO J, XIAO S Y, YANG J, et al. Influence of nano C-S-H on performance of fly ash/slag mixed concrete[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(10): 3267-3272 (in Chinese).
[9] 张小伟,肖瑞敏,张雄.粉煤灰矿粉水泥胶凝体系的高效复合早强剂研制[J].建筑材料学报,2012,15(2):249-254.
ZHANG X W, XIAO R M, ZHANG X. Preparation of high performance composites strength accelerator for cement containing fly ash and ground granulated blast-furnace slag[J]. Journal of Building Materials, 2012, 15(2): 249-254 (in Chinese).
[10] 崔素萍,郭红霞,王辰,等.纳米无定形C-S-H凝胶颗粒及其结构表征[J].硅酸盐通报,2012,31(3):531-534.
CUI S P, GUO H X, WANG C, et al. Synthesis and characterization of amorphous calcium-silieate hydrate (C-S-H) nanoparticles[J]. Bulletin of the Chinese Ceramic Society, 2012, 31(3): 531-534 (in Chinese).
[11] THOMAS J J, JENNINGS H M, CHEN J J. Influence of nucleation seeding on the hydration mechanisms of tricalcium silicate and cement[J]. The Journal of Physical Chemistry C, 2009, 113(11): 4327-4334.
[12] 彭小芹,兰聪,王淑萍,等.水化硅酸钙粉体对水泥水化反应过程及机理的影响[J].建筑材料学报,2015,18(2):195-201.
PENG X Q, LAN C, WANG S P, et al. Effects of the C-S-H powder on the hydration process and mechanism of cement[J]. Journal of Building Materials, 2015, 18(2): 195-201 (in Chinese).
[13] 王政,杨英姿,李家和.水化硅酸钙晶种的制备及对水泥强度的影响[J].材料科学与工艺,2007,15(6):789-791+796.
WANG Z, YANG Y Z, LI J H. Preparation of C-S-H-phase nuclei and its effects on compressive strength of cement[J]. Materials Science and Technology, 2007, 15(6): 789-791+796 (in Chinese).
[14] JOHN E, MATSCHEI T, STEPHAN D. Nucleation seeding with calcium silicate hydrate: a review[J]. Cement and Concrete Research, 2018, 113: 74-85.
[15] ALIZADEH R, RAKI L, MAKAR J M, et al. Hydration of tricalcium silicate in the presence of synthetic calcium-silicate-hydrate[J]. Journal of Materials Chemistry, 2009, 19(42): 7937.
[16] ZHANG B L, TAN H B, SHEN W G, et al. Nano-silica and silica fume modified cement mortar used as surface protection material to enhance the impermeability[J]. Cement and Concrete Composites, 2018, 92: 7-17.
[17] SHAIKH F U A, HOSAN A. Effect of nano silica on compressive strength and microstructures of high volume blast furnace slag and high volume blast furnace slag-fly ash blended pastes[J]. Sustainable Materials and Technologies, 2019, 20: e00111.
[18] 吴中伟.混凝土科学技术近期发展方向的探讨[J].硅酸盐学报,1979,7(3):262-270.
WU Z W. An approach to the recent trends of concrete science and technology[J]. Journal of the Chinese Ceramic Society, 1979, 7(3): 262-270 (in Chinese).
[19] 张朝阳,蔡熠,孔祥明,等.纳米C-S-H对水泥水化、硬化浆体孔结构及混凝土强度的影响[J].硅酸盐学报,2019,47(5):585-593.
ZHANG C Y, CAI Y, KONG X M, et al. Influence of nano C-S-H on cement hydration, pore structure of hardened cement pastes and strength of concrete[J]. Journal of the Chinese Ceramic Society, 2019, 47(5): 585-593 (in Chinese).

纳米C-S-H对矿粉-水泥体系水化的影响

Effect of Nano C-S-H on Hydration of Slag Powder-Cement System

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李宁, 赵立革, 赵少伟, 王卉, 郑永超. Ti含量对矿渣玻璃体结构及其水化活性的影响机制研究[J]. 硅酸盐通报, 2024, 43(4): 1325-1334.
[2]	张全红, 王涛, 穆松, 蔡佳豪, 刘凯, 周莹, 刘光严. 不同侵蚀环境下喷射混凝土耐久性提升技术及作用机理[J]. 硅酸盐通报, 2024, 43(4): 1410-1419.
[3]	盖珂瑜, 龙勇, 陈露一, 李信, 刘开志, 王宇, 孙涛. 矿物掺合料复掺对超高性能湿接缝混凝土性能的影响[J]. 硅酸盐通报, 2024, 43(3): 948-955.
[4]	尹鹏翔, 李静. 废玻璃粉对泡沫混凝土性能和微观孔结构的影响及其价值工程分析[J]. 硅酸盐通报, 2024, 43(3): 1021-1029.
[5]	丁正, 廖国胜, 廖宜顺, 何军林, 胡思达. 搅拌站废浆对水泥水化硬化的影响机理[J]. 硅酸盐通报, 2024, 43(3): 1039-1047.
[6]	原健, 王琴, 曾凡超, 郭志翔, 王宏维. 不同温度下矿物掺合料对喷射混凝土水化行为及力学性能的影响[J]. 硅酸盐通报, 2024, 43(2): 407-417.
[7]	向杰, 王胜, 李玉杰, 王文杰. 基于响应面法的地热钻采碳纳米管复合水泥基材料的研究[J]. 硅酸盐通报, 2024, 43(2): 495-508.
[8]	朱崟源, 朱干宇, 齐放, 李会泉, 陈艳, 李少鹏, 郭彦霞. 固废基水化硅酸钙制备及综合利用研究进展[J]. 硅酸盐通报, 2024, 43(2): 517-533.
[9]	郭威, 庞来学, 王文超, 张佳丽, 王华, 白书霞. 粉煤灰无溶剂法合成方钠石新方法及效果验证[J]. 硅酸盐通报, 2024, 43(2): 584-592.
[10]	朱鹏飞, 余熠, 石研然, 杨恒, 何旸, 徐菲, 蒋林华, 储洪强, 徐天磊, 徐宁. 基于电化学阻抗谱的石灰石粉硬化水泥浆体孔结构演化研究[J]. 硅酸盐通报, 2024, 43(1): 35-43.
[11]	林淑瑾, 罗盛洋, 熊晓立. 负载S-g-C₃N₄/MgAl-CLDH光催化砂浆的去污及水化性能研究[J]. 硅酸盐通报, 2024, 43(1): 44-51.
[12]	董建统, 刘志勇, 胡忠帅, 朱丹丹, 丁怡, 张伟强, 来福琨. 减水保坍型聚羧酸减水剂的合成及性能研究[J]. 硅酸盐通报, 2024, 43(1): 52-60.
[13]	杜爽, 王伟, 乔敏, 曾鲁平, 赵爽, 陈俊松, 吴庆勇, 朱伯淞. 低温环境下液体速凝剂的适应性及强度增强机理研究[J]. 硅酸盐通报, 2024, 43(1): 61-70.
[14]	孙婧, 洪俊哲, 王珅, 常璞, 贾小静, 刘宏波. 多孔玄武岩粗骨料HPC的制备和收缩性能研究[J]. 硅酸盐通报, 2024, 43(1): 84-91.
[15]	李永清, 倪勇军, 李芳芳, 郭伟龙, 曹轩豪, 关博文. 尾泥微粉-粉煤灰-水泥复合胶凝体系性能研究[J]. 硅酸盐通报, 2024, 43(1): 236-245.