回收轮胎钢纤维再生骨料混凝土基本力学性能试验研究

摘要/Abstract

摘要： 混凝土的基本力学性能与破坏形态是反映试件在不同受力状态下承载能力与韧性的重要指标。为了研究回收轮胎钢纤维(RTSF)再生骨料混凝土的基本力学性能,试验设计了8组不同种类的混凝土试件。通过坍落度、含气量、立方体抗压、劈裂抗拉与抗折试验,系统的探究了RTSF体积掺量(0.25%、0.5%、0.75%和1.0%)和再生骨料取代率(质量分数分别为50%、75%和100%)对混凝土基本力学性能以及破坏形态的影响。研究表明:随着再生骨料取代率的升高,混凝土拌合物坍落度减小、含气量增大,各项力学性能均产生不同程度的降低;RTSF能够有效提高再生骨料混凝土的基本力学性能,且试件的破坏形态随RTSF掺量的增加呈现出明显的延性破坏特征。综合各项指标,当再生骨料取代率为50%时,RTSF体积掺量为0.5%的RTSF再生骨料混凝土力学性能最佳。其试件立方体抗压强度(28 d)较普通混凝土仅降低1.0%,而劈裂抗拉强度与抗折强度较普通混凝土分别提高9.6%和12.5%。此外其弯曲韧度指数I₅、I₁₀和I₂₀分别为普通混凝土的2.7倍、3.8倍和4.8倍。

关键词: 基本力学性能, 破坏形态, 回收轮胎钢纤维, 再生骨料混凝土, 弯曲韧度指数

Abstract: The basic mechanical properties and damage modes of concrete are important indicators of the load-bearing capacity and toughness of the specimens under different stress conditions. To investigate the basic mechanical properties of recycled tyre steel fiber (RTSF) recycled aggregate concrete, 8 sets of concrete specimens of different types were designed for the test. The effects of RTSF volume fraction (0.25%, 0.5%, 0.75% and 1.0%) and recycled aggregate replacement rate(the mass fractions are 50%, 75% and 100%, respectively) on the basic mechanical properties and failure modes of concrete were systematically investigated by slump, gas content, cubic compressive, splitting tensile and flexural tests. The results show that with the increase of recycled aggregate replacement rate, the slump of concrete mixture decrease and the gas content increase, and the mechanical properties are reduced to different degrees. RTSF effectively improves the basic mechanical properties of recycled aggregate concrete, and the failure mode of the specimens shows obvious ductile damage characteristics with the increase of RTSF content. Comprehensive indicators, when the replacement rate of recycled aggregate is 50%, the mechanical properties of RTSF recycled aggregate concrete with RTSF volume content of 0.5% is the best. The cube compressive strength (28 d) of the specimens is only 1.0% lower than that of plain concrete, while the splitting tensile strength and flexural strength are 9.6% and 12.5% higher than that of plain concrete, respectively. In addition, the flexural toughness index I₅, I₁₀ and I₂₀ of the concrete are 2.7 times, 3.8 times and 4.8 times of that of the plain concrete, respectively.

Key words: basic mechanical property, failure mode, recycled tyre steel fiber, recycled aggregate concrete, bending toughness index

中图分类号:

TU528.572

范小春, 张雯静, 梁天福, 陈凯风. 回收轮胎钢纤维再生骨料混凝土基本力学性能试验研究[J]. 硅酸盐通报, 2021, 40(7): 2331-2340.

FAN Xiaochun, ZHANG Wenjing, LIANG Tianfu, CHEN Kaifeng. Experimental Study on Basic Mechanical Properties of Recycled Tyre Steel Fiber Recycled Aggregate Concrete[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(7): 2331-2340.

参考文献

[1] FRAJ A B, IDIR R. Concrete based on recycled aggregates-recycling and environmental analysis: a case study of Paris’ region[J]. Construction and Building Materials, 2017, 157: 952-964.
[2] AIT MOHAMED AMER A, EZZIANE K, BOUGARA A, et al. Rheological and mechanical behavior of concrete made with pre-saturated and dried recycled concrete aggregates[J]. Construction and Building Materials, 2016, 123: 300-308.
[3] 李琼,冯琼,曹辉.再生骨料级配对混凝土力学性能的影响及微观机理分析[J].江苏大学学报(自然科学版),2019,40(5):614-620.
LI Q, FENG Q, CAO H. Effects of recycled aggregates gradation on mechanical performance of concrete and microscopic performance analysis[J]. Journal of Jiangsu University (Natural Science Edition), 2019, 40(5): 614-620 (in Chinese).
[4] 霍洪媛,范程程,陈爱玖,等.不同强度等级的再生骨料对再生混凝土基本力学性能影响[J].混凝土,2017(2):60-62+65.
HUO H Y, FAN C C, CHEN A J, et al. Influence of the recycled aggregate with different strength on recycled concrete[J]. Concrete, 2017(2): 60-62+65 (in Chinese).
[5] 商效瑀,杨经纬,李江山.基于CT图像的再生混凝土细观破坏裂纹分形特征[J].复合材料学报,2020,37(7):1774-1784.
SHANG X Y, YANG J W, LI J S. Fractal characteristics of meso-failure crack in recycled coarse aggregate concrete based on CT image[J]. Acta Materiae Compositae Sinica, 2020, 37(7): 1774-1784 (in Chinese).
[6] 孔祥清,何文昌,邢丽丽,等.钢纤维-聚丙烯纤维混杂对再生混凝土抗冲击性能的影响[J].复合材料学报,2020,37(7):1763-1773.
KONG X Q, HE W C, XING L L, et al. Effect of steel fiber-polypropylene fiber hybrid additon on impact resistance of recycled aggregate concrete[J]. Acta Materiae Compositae Sinica, 2020, 37(7): 1763-1773 (in Chinese).
[7] MATAR P, ZÉHIL G P. Effects of polypropylene fibers on the physical and mechanical properties of recycled aggregate concrete[J]. Journal of Wuhan University of Technology-Mater Sci Ed, 2019, 34(6): 1327-1344.
[8] 何文昌,孔祥清,高化东,等.高掺量聚丙烯纤维再生混凝土力学性能及微观结构研究[J].混凝土,2020(1):82-86.
HE W C, KONG X Q, GAO H D, et al. Research on the mechanical properties and microstructure of recycled aggregate concrete with high content polypropylene fiber[J]. Concrete, 2020(1): 82-86 (in Chinese).
[9] 姚运,陈艳.骨料替代率对玻璃纤维再生混凝土力学性能的影响[J].混凝土,2017(4):58-61.
YAO Y, CHEN Y. Effect of replacement rate of recycled coarse aggregates on physical properties of glass fiber recycled concrete[J]. Concrete, 2017(4): 58-61 (in Chinese).
[10] ALI B, QURESHI L A. Influence of glass fibers on mechanical and durability performance of concrete with recycled aggregates[J]. Construction and Building Materials, 2019, 228: 116783.
[11] 黄伟,葛进进,方张平,等.钢纤维补偿收缩再生混凝土制备及性能[J].硅酸盐通报,2020,39(9):2789-2794.
HUANG W, GE J J, FANG Z P, et al. Preparation and performance of steel fiber shrinkage-compensating recycled concrete[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(9): 2789-2794 (in Chinese).
[12] AIELLO M A, LEUZZI F, CENTONZE G, et al. Use of steel fibres recovered from waste tyres as reinforcement in concrete: pull-out behaviour, compressive and flexural strength[J]. Waste Management, 2009, 29(6): 1960-1970.
[13] HU H, PAPASTERGIOU P, ANGELAKOPOULOS H, et al. Mechanical properties of SFRC using blended manufactured and recycled tyre steel fibres[J]. Construction and Building Materials, 2018, 163: 376-389.
[14] ZAMANZADEH Z, LOURENÇO L, BARROS J. Recycled steel fibre reinforced concrete failing in bending and in shear[J]. Construction and Building Materials, 2015, 85: 195-207.
[15] CAGGIANO A, XARGAY H, FOLINO P, et al. Experimental and numerical characterization of the bond behavior of steel fibers recovered from waste tires embedded in cementitious matrices[J]. Cement and Concrete Composites, 2015, 62: 146-155.
[16] 李唱,张鹏程,朱方尺,等.废弃混凝土作为再生粗骨料对新拌混凝土性能的影响[J].硅酸盐通报,2020,39(8):2587-2593.
LI C, ZHANG P C, ZHU F C, et al. Influence of waste concrete as recycled coarse aggregate on performance of fresh concrete[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(8): 2587-2593 (in Chinese).
[17] ADESSINA A, BEN FRAJ A, BARTHÉLÉMY J F, et al. Experimental and micromechanical investigation on the mechanical and durability properties of recycled aggregates concrete[J]. Cement and Concrete Research, 2019, 126: 105900.
[18] LI L J, RUAN S H, ZENG L. Mechanical properties and constitutive equations of concrete containing a low volume of tire rubber particles[J]. Construction and Building Materials, 2014, 70: 291-308.
[19] AHMADI M, FARZIN S, HASSANI A, et al. Mechanical properties of the concrete containing recycled fibers and aggregates[J]. Construction and Building Materials, 2017, 144: 392-398.
[20] KHALOO A R, ESRAFILI A, KALANI M, et al. Use of polymer fibres recovered from waste car timing belts in high performance concrete[J]. Construction and Building Materials, 2015, 80: 31-37.
[21] CENTONZE G, LEONE M, AIELLO M A. Steel fibers from waste tires as reinforcement in concrete: a mechanical characterization[J]. Construction and Building Materials, 2012, 36: 46-57.
[22] 杨粉,陈爱玖,王静,等.钢纤维再生混凝土劈拉、抗折强度试验研究[J].混凝土,2012(12):11-14.
YANG F, CHEN A J, WANG J, et al. Experiments of splitting tensile and flexural strength mechanical properties of steel fiber recycled concrete[J]. Concrete, 2012(12): 11-14 (in Chinese).
[23] MARTINELLI E, CAGGIANO A, XARGAY H. An experimental study on the post-cracking behaviour of hybrid industrial/recycled steel fibre-reinforced concrete[J]. Construction and Building Materials, 2015, 94: 290-298.