Influence of Coarse Polypropylene Fiber on Performance of Pumping Concrete and Grey Correlation Analysis

Abstract

Abstract: To study the influences of coarse polypropylene fiber content and length-diameter ratio on the workability and mechanical properties of pumped concrete, the tests of slump, expansion, compressive strength and splitting tensile strength of coarse polypropylene fiber reinforced concrete (CPFRC) were carried out with base concrete adding coarse polypropylene fiber with different dosages and length-diameter ratios. In addition, the enhancement effects of the fiber content and length-diameter ratio were quantified on the basis of the gray correlation theory. The research results show that the content of coarse polypropylene fiber and the length-diameter ratio have significant effects on slump, expansion, early compressive strength and splitting tensile strength of pumped concrete. Compared with the base concrete,when the coarse polypropylene fiber content is 3 kg/m³, CPFRC has the best workability and the compressive strength enhancement effect. And the slump and the expansion degree reduce by 1.41% and 15.76%, while the compressive strength of 7 d, 14 d and 28 d increase by 20.42%, 14.96% and 11.49%, respectively. When the content of coarse polypropylene fiber is 6 kg/m³, the splitting tensile strength enhancement effect of concrete is the most obvious, and the splitting tensile strength of 7 d, 14 d and 28 d increase by 27.46%, 13.61% and 15.92%, respectively. The workability and mechanical properties of CPFRC are optimized when the content of coarse polypropylene fiber is 3 kg/m³ and length-diameter ratio reaches 47.5, and the total correlation of the workability and the mechanical properties reaches 0.849.

Key words: coarse polypropylene fiber reinforced concrete, dosage, length-diameter ratio, workability, compressive strength, splitting tensile strength, correlation

CLC Number:

U454
TU528

LIANG Ninghui, REN Lianxi, ZHOU Kan, HU Heng, ZHOU Benwei. Influence of Coarse Polypropylene Fiber on Performance of Pumping Concrete and Grey Correlation Analysis[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 88-99.

References

[1] PAKRAVAN H R, LATIFI M, JAMSHIDI M. Hybrid short fiber reinforcement system in concrete: a review[J]. Construction and Building Materials, 2017, 142: 280-294.
[2] YIN S, TULADHAR R, SHI F, et al. Use of macro plastic fibers in concrete: a review[J]. Construction & Building Materials, 2015, 93: 180-188.
[3] BRANDT A M. Fiber reinforced cement-based (FRC) composites after over 40 years of development in building and civil engineering[J]. Composite Structures, 2008, 86(1/2/3): 3-9.
[4] 邓宗才.高性能合成纤维混凝土[M].北京:科学出版社,2003.
DENG Z C. High performance synthetic fiber concrete[M]. Beijing: Science Press, 2003 (in Chinese).
[5] 中华人民共和国住房和城乡建设部.混凝土泵送施工技术规程:JGJ/T 10—2011[S].北京:中国建筑工业出版社,2011.
Ministry of Housing and Urban-Rural Development of the People's Republic of China. Technical specification for concrete pumping construction: JGJ/T 10—2011[S].Beijing: China Architecture & Building Press, 2011 (in Chinese).
[6] 杨云鹏,艾纯明,孙振明,等.湿喷混凝土可泵送性试验研究[J].地下空间与工程学报,2015,11(6):1457-1461.
YANG Y P, AI C M, SUN Z M, et al. Experimental study on the pumpability of wet shotcrete[J]. Chinese Journal of Underground Space and Engineering, 2015, 11(6): 1457-1461 (in Chinese).
[7] 牛龙龙,张士萍,韦有信.钢纤维掺量对混凝土力学性能的影响[J].混凝土与水泥制品,2019(3):51-54.
NIU L L, ZHANG S P, WEI Y X. The influence of steel fiber content on mechanical properties of concrete[J]. China Concrete and Cement Products, 2019(3): 51-54 (in Chinese).
[8] 陕亮,张亮.混杂钢-聚丙烯纤维混凝土的试验研究与强度计算[J].长江科学院院报,2015,32(12):114-119.
SHAN L, ZHANG L. Experimental research and strength calculation of hybrid steel-polypropylene fiber reinforced concrete[J]. Journal of Yangtze River Scientific Research Institute, 2015, 32(12): 114-119 (in Chinese).
[9] 蒋金洋,孙伟,戴捷,等.超高程泵送钢纤维混凝土关键性能及试验研究[J].大连理工大学学报,2006(s1):88-93.
JIANG J Y, SUN W, DAI J, et al. Study of key properties of steel fiber reinforced concrete with super-high vertical pumping distance[J]. Journal of Dalian University of Technology, 2006(s1): 88-93 (in Chinese).
[10] 牛建刚,李京军,尹亚柳,等.塑钢纤维轻骨料混凝土力学性能及最佳纤维掺量试验研究[J].硅酸盐通报,2016,35(1):87-91.
NIU J G, LI J J, YIN Y L, et al. Experimental investigation on mechanical properties and optimal fiber content in plastic steel fiber reinforced lightweight aggregate concrete[J]. Bulletin of the Chinese Ceramic Society, 2016, 35(1): 87-91 (in Chinese).
[11] 周继凯,毕枫桐,沈超,等.不同掺量聚丙烯纤维混凝土力学性能试验研究[J].混凝土,2015(11):23-26.
ZHOU J K, BI F T, SHEN C, et al. Experimental study on mechanical property of polypropylene fiber reinforced concrete with different incorporation rates[J]. Concrete, 2015(11): 23-26 (in Chinese).
[12] 罗洪林,杨鼎宜,周兴宇,等.不同长径比聚丙烯纤维增强混凝土的力学特性[J].复合材料学报,2019,36(8):1935-1948.
LUO H L, YANG D Y, ZHOU X Y, et al. Mechanical properties of polypropylene fiber reinforced concrete with different aspect ratios[J]. Acta Materiae Compositae Sinica, 2019, 36(8): 1935-1948 (in Chinese).
[13] 梁宁慧,曹郭俊,刘新荣,等.基于三点弯曲试验的聚丙烯纤维桥接应力研究[J].材料导报,2020,34(2):2153-2158.
LIANG N H, CAO G J, LIU X R, et al. Study on bridging stress of polypropylene fiber based on three-point bending test[J]. Materials Reports, 2020, 34(2): 2153-2158 (in Chinese).
[14] 梁宁慧,缪庆旭,刘新荣,等.聚丙烯纤维增强混凝土断裂韧度及软化本构曲线确定[J].吉林大学学报(工学版),2019,49(4):1144-1152.
LIANG N H, MIAO Q X, LIU X R, et al. Determination of fracture toughness and softening constitutive curve of PFRC[J]. Journal of Jilin University (Engineering and Technology Edition), 2019,49(4):1144-1152 (in Chinese).
[15] 中国工程建设标准化协会.纤维混凝土试验方法标准:CECS 13—2009[S].北京:中国计划出版社,2010.
China Association for Engineering Construction Standardization. Standard test methods of fiber reinforced concrete: CECS 13—2009[S].Beijing: China Planning Press, 2010 (in Chinese).
[16] 中国工程建设标准化协会.纤维混凝土结构技术规程:CECS 38—2004[S].北京:中国计划出版社,2005.
China Association for Engineering Construction Standardization. Technical specification for fiber reinforced concrete structures: CECS 38—2004[S].Beijing: China Planning Press, 2005 (in Chinese).
[17] 中华人民共和国住房和城乡建设部,中华人民共和国国家质量监督检验检疫总局.普通混凝土拌合物性能试验方法标准:GB/T 50080—2016[S].北京:中国建筑工业出版社,2017.
Ministry of Housing and Urban-Rural Development of the People's Republic of China, General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Standard for test method of performance on ordinary fresh concrete: GB/T 50080—2016[S].Beijing: China Architecture & Building Press, 2017 (in Chinese).
[18] 中华人民共和国住房和城乡建设部,中华人民共和国国家质量监督检验检疫总局.混凝土物理力学性能试验方法标准:GB/T 50081—2019[S].北京:中国建筑工业出版社,2020.
Ministry of Housing and Urban-Rural Development of the People's Republic of China, General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Standard for test methods of physical and mechanical properties of concrete: GB/T 50081—2019[S].Beijing: China Architecture & Building Press, 2020 (in Chinese).
[19] SMARZEWSKI P. Flexural toughness of high-performance concrete with basalt and polypropylene short fibres[J]. Advances in Civil Engineering, 2018, 2018:1-8.
[20] 梁宁慧,胡杨,钟杨,等.多尺度聚丙烯纤维混凝土孔结构及抗冻性[J].重庆大学学报,2019,42(11):38-46.
LIANG N H, HU Y, ZHONG Y, et al. Study on pore structure and frost resistance of multi-scale polypropylene fiber reinforced concret[J].Journal of Chongqing University,2019,42(11):38-46 (in Chinese).
[21] 罗洪林,杨鼎宜,周兴宇,等.聚丙烯纤维长径比对混凝土力学性能的影响研究[J].混凝土,2019(9):25-30.
LUO H L, YANG D Y, ZHOU X Y, et al.Study on effect of length-to-diameter ratio of polypropylene fiber on mechanical properties of concrete[J]. Concrete, 2019(9): 25-30 (in Chinese).
[22] 邓聚龙.灰色预测与决策[M].武汉:华中理工大学出版社,1986.
DENG J L. Grey prediction and decision-making[M]. Wuhan: Huazhong University of Science and Technology Press, 1986 (in Chinese).
[23] 刘思峰.灰色系统理论及其应用[M].第7版.北京:科学出版社,2014.
LIU S F. Grey system theory and its application[M]. 7th ed. Beijing: Science Press, 2014 (in Chinese).
[24] 周立霞,王起才.粉煤灰粒度分布及其活性的灰色关联分析[J].硅酸盐通报,2011,30(3):656-661+666.
ZHOU L X, WANG Q C. Grey incidence analysis between particle size distribution of fly ash and its activity[J]. Bulletin of the Chinese Ceramic Society, 2011, 30(3): 656-661+666 (in Chinese).
[25] 虎东霞,冯哲,马洁.基于灰色系统理论的掺钢渣粉C40混凝土性能研究[J].公路,2017,62(9):231-234.
HU D X, FENG Z, MA J. Research on the performance of steel slag powder C40 concrete based on grey system theory [J]. Highway, 2017, 62(9): 231-234 (in Chinese).
[26] 梁宁慧.多尺度聚丙烯纤维混凝土力学性能试验和拉压损伤本构模型研究[D].重庆:重庆大学,2014.
LIANG N H. The mechanics performance test of multi-scale polypropylene fiber concrete and the study of tension and compression damage constitutive model[D]. Chongqing: Chongqing University, 2014 (in Chinese).