多源石墨固废制备电热板材配方试验研究

硅酸盐通报 ›› 2023, Vol. 42 ›› Issue (2): 637-643.

所属专题：资源综合利用

多源石墨固废制备电热板材配方试验研究

李思颖¹, 任子杰^1,2, 高惠民^1,2, 马骏辉¹, 杨云平¹, 吕阳^3,4, 李相国^3,4

1.武汉理工大学资源与环境工程学院,武汉 430070;
2.矿物资源加工与环境湖北省重点实验室,武汉 430070;
3.武汉理工大学材料科学与工程学院,武汉 430070;
4.武汉理工大学硅酸盐建筑材料国家重点实验室,武汉 430070

收稿日期:2022-10-26 修订日期:2022-11-30 出版日期:2023-02-15 发布日期:2023-03-07
通信作者: 任子杰,博士,副教授。E-mail:renzijie@whut.edu.cn
作者简介:李思颖(1998—),女,硕士研究生。主要从事非金属矿的研究。E-mail:843448231@qq.com
基金资助:
科技部重点研发计划(2020YFC1909605)

Experimental Study on Formula of Electrothermal Plate Prepared from Multi-Source Graphite Solid Waste

LI Siying¹, REN Zijie^1,2, GAO Huimin^1,2, MA Junhui¹, YANG Yunping¹, LYU Yang^3,4, LI Xiangguo^3,4

1. School of Resources and Environment Engineering, Wuhan University of Technology, Wuhan 430070, China;
2. Hubei Province Key Laboratory of Mineral Resources Processing and Environment, Wuhan 430070, China;
3. School of Materials Science and Engineering, Wuhan University of Technology, Wuhan 430070, China;
4. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China

Received:2022-10-26 Revised:2022-11-30 Online:2023-02-15 Published:2023-03-07

摘要/Abstract

摘要： 为了提高石墨固废利用率,本文以石墨开采废石为细骨料,添加球形石墨尾料以及不同质量分数的废石石粉进行电热板材配方试验,探究了石墨开采废石取代量、石粉掺量对电热板材性能的影响。结果表明:在100%(质量分数)使用石墨开采废石作为细骨料时,养护28 d的水泥板材抗折强度及抗压强度分别达到11.09 MPa和50.90 MPa,虽然略低于使用标准砂的水泥板材的强度指标,但是仍可满足相关要求,说明石墨开采废石可以作为细骨料使用;在废石石粉掺量为7%(质量分数)时,电热板材的抗折强度和抗压强度最高分别达到6.21 MPa和33.00 MPa,虽然强度有所降低,但是仍可满足低强度板材的要求;在球形石墨尾料掺量为9%(质量分数)时,电热板材体积电阻率为1.94 Ω·m,发热温度为71 ℃,具有良好的电热效果。

关键词: 石墨固废, 电热板材, 球形石墨尾料, 力学性能, 电学性能, 体积电阻率

Abstract: In order to improve the utilization rate of graphite solid waste, this paper used graphite mining waste stone as fine aggregate, added spherical graphite tailing and waste stone stone powder with different mass fraction to carry out an experimental study on the formula of electrothermal plate. The influences of graphite mining waste stone replacement and stone powder content on the performance of electrothermal plate were explored. The results show that using 100% (mass fraction) graphite mining waste stone as fine aggregate, the bending strength and compressive strength of cement plate maintained for 28 d are 11.09 MPa and 50.90 MPa, respectively. Although they are slightly lower than the strength index of cement plate using standard sand, but they meet the relevant requirements. This shows that graphite mining waste stone can be used as fine aggregate. When waste stone stone powder content is 7% (mass fraction), the bending strength and compressive strength of electrothermal plate reach up to 6.21 MPa and 33.00 MPa. Although the strength is reduced, it can still meet the requirements of low-strength plate. When spherical graphite tailing content is 9% (mass fraction), the volume resistivity of electrothermal plate is 1.94 Ω·m, and the heating temperature is 71 ℃, which has a good electrothermal effect.

Key words: graphite solid waste, electrothermal plate, spherical graphite tailing, mechanical property, electrical performance, volume resistivity

中图分类号:

X754
TD985

李思颖, 任子杰, 高惠民, 马骏辉, 杨云平, 吕阳, 李相国. 多源石墨固废制备电热板材配方试验研究[J]. 硅酸盐通报, 2023, 42(2): 637-643.

LI Siying, REN Zijie, GAO Huimin, MA Junhui, YANG Yunping, LYU Yang, LI Xiangguo. Experimental Study on Formula of Electrothermal Plate Prepared from Multi-Source Graphite Solid Waste[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2023, 42(2): 637-643.

参考文献

[1] 孙明俊, 李兆峰. 我国砂石骨料工艺现状研究[J]. 中国矿山工程, 2022, 51(2): 84-87.
SUN M J, LI Z F. Research on sand-gravel aggregate status in China[J]. China Mine Engineering, 2022, 51(2): 84-87 (in Chinese).
[2] 黄朕宇. 建筑砂石骨料应用现状与矿砂废渣利用分析[J]. 绿色环保建材, 2021(5): 7-8.
HUANG Z Y. Application status of building sand and gravel aggregate and utilization analysis of mineral sand and waste residue[J]. Green Environmental Protection Building Materials, 2021(5): 7-8 (in Chinese).
[3] 周起忠, 闫卫东, 尹丽文, 等. 世界石墨资源概况及需求分析[J]. 国土资源情报, 2019(6): 28-32.
ZHOU Q Z, YAN W D, YIN L W, et al. Overview and demand analysis of global graphite resource[J]. Land and Resources Information, 2019(6): 28-32 (in Chinese).
[4] 刘欢, 王笑峰, 杨忠华, 等. 黑龙江省东部矿区废弃地重金属潜在生态危害评价[J]. 黑龙江大学工程学报, 2018, 9(1): 40-45.
LIU H, WANG X F, YANG Z H, et al. Evaluation of heavy metal potential ecological risks in eastern mining area of Heilongjiang Province[J]. Journal of Engineering of Heilongjiang University, 2018, 9(1): 40-45 (in Chinese).
[5] 张大双. 石墨尾矿混凝土受力和导电性能研究[D]. 哈尔滨: 黑龙江大学, 2015.
ZHANG D S. Study on mechanical and electrical conductivity of graphite tailings concrete[D]. Harbin: Helongjiang University, 2015 (in Chinese).
[6] 刘洪波, 赵艳, 李化明. 一种掺石墨尾矿的导电混凝土及其制备方法和应用: CN107445525A[P]. 2017-12-08.
LIU H B, ZHAO Y, LI H M. A conductive concrete mixed with graphite tailings and its preparation method and application: CN107445525A[P]. 2017-12-08 (in Chinese).
[7] LIU H B, LIU K, LAN Z, et al. Mechanical and electrical characteristics of graphite tailing concrete[J]. Advances in Materials Science and Engineering, 2018, 2018: 1-9.
[8] 王琴, 李时雨, 王健, 等. 氧化石墨烯对水泥水化进程及其主要水化产物的影响[J]. 硅酸盐学报, 2018, 46(2): 163-172.
WANG Q, LI S Y, WANG J, et al. Effect of graphene oxide on hydration process and main hydration products of cement[J]. Journal of the Chinese Ceramic Society, 2018, 46(2): 163-172 (in Chinese).
[9] 谢华兵. 机制砂粒形与级配特性及其对混凝土性能的影响[D]. 广州: 华南理工大学, 2016.
XIE H B. The characteristics of shape and grading of manufactured sand and theirs effects on the properties of concrete[D]. Guangzhou: South China University of Technology, 2016 (in Chinese).
[10] 杨智勇. 浅谈石粉含量对机制砂混凝土的和易性及抗压强度的影响[J]. 黑龙江交通科技, 2021, 44(10): 214-215.
YANG Z Y. Influence of stone powder content on workability and compressive strength of machine-made sand concrete[J]. Communications Science and Technology Heilongjiang, 2021, 44(10): 214-215 (in Chinese).
[11] 满奇斐. 内掺玄武岩石粉对水工混凝土性能影响的试验研究[J]. 水利科学与寒区工程, 2022, 5(2): 14-16.
MAN Q F. Study on the influence of basalt powder on the performance of hydraulic concrete[J]. Hydro Science and Cold Zone Engineering, 2022, 5(2): 14-16 (in Chinese).
[12] 范德科, 马强, 周宗辉, 等. 石粉对机制砂混凝土性能的影响[J]. 硅酸盐通报, 2016, 35(3): 913-917.
FAN D K, MA Q, ZHOU Z H, et al. Influence of stone dust on properties of concrete with manufactured sand[J]. Bulletin of the Chinese Ceramic Society, 2016, 35(3): 913-917 (in Chinese).
[13] 彭兴华, 张朝宏, 李国栋, 等. 高性能混凝土用机制骨料品质特征及影响因素分析[J]. 山西建筑, 2022, 48(2): 114-118.
PENG X H, ZHANG C H, LI G D, et al. Analysis of quality characteristics and influencing factors of manufactured aggregate for high performance concrete[J]. Shanxi Architecture, 2022, 48(2): 114-118 (in Chinese).
[14] DEL MORAL B, BAEZA F J, NAVARRO R, et al. Temperature and humidity influence on the strain sensing performance of hybrid carbon nanotubes and graphite cement composites[J]. Construction and Building Materials, 2021, 284: 122786.

[1]	陈娅, 万小梅, 崔允铮, 李辉. 纤维表面改性对EGC力学性能的影响[J]. 硅酸盐通报, 2023, 42(4): 1174-1182.
[2]	张虹宇, 郑玉龙, 陆春华. 两种养护制度下C100高强混凝土韧性对比试验研究[J]. 硅酸盐通报, 2023, 42(4): 1252-1259.
[3]	张劲竹, 刘华新, 王家贺, 柳根金, 王学志. 混杂纤维混凝土高温后性能劣化分析与强度预测[J]. 硅酸盐通报, 2023, 42(4): 1260-1269.
[4]	姜晓丹, 孙梦琪, 刘昂, 王攀, 侯东帅. 碳化对环氧树脂与混凝土界面黏结性能影响的分子模拟研究[J]. 硅酸盐通报, 2023, 42(4): 1291-1297.
[5]	胡彪, 李先海, 晏祥政, 赵永庆. 热活化煤矸石粉对基体-骨料界面过渡区性能的影响[J]. 硅酸盐通报, 2023, 42(4): 1315-1322.
[6]	葛成龙, 周海龙, 陈岩, 吕志刚. 不同MB值机制砂混凝土的性能和微观孔隙结构[J]. 硅酸盐通报, 2023, 42(3): 888-897.
[7]	刘德嵩, 杨忠德, 林鑫, 谢虎, 张菡欣, 王开, 黄守武, 刘振英. 轻质氧化镁含量对方镁石-镁铝尖晶石砖性能的影响[J]. 硅酸盐通报, 2023, 42(3): 1122-1129.
[8]	唐咸远, 马杰灵, 罗杰, 何滨冰, 陆澄剑. 钢渣微粉生态型超高性能混凝土力学性能影响因素分析[J]. 硅酸盐通报, 2023, 42(2): 607-617.
[9]	樊璐洋, 金子豪, 苏英, 崔程嘉, 王斌. 基于响应面法的半水磷石膏复合胶凝材料优化设计及性能研究[J]. 硅酸盐通报, 2023, 42(2): 626-636.
[10]	彭全敏, 陈炳蔚, 张彦, 鹿群, 刘洛源, 郭晓宇. 废PET塑料纤维对再生混凝土基本性能的影响[J]. 硅酸盐通报, 2023, 42(2): 666-673.
[11]	王晶, 陶耀华, 于康, 赵佳一, 庄凤明, 李辉. 混凝土帆布力学性能与应用研究进展[J]. 硅酸盐通报, 2023, 42(1): 22-30.
[12]	周凌峰, 林旭健, 王威. MgO活性对新型水化硅酸镁水泥性能的影响[J]. 硅酸盐通报, 2023, 42(1): 57-65.
[13]	李建林, 张智强, 余林文. 低密度碱矿渣发泡混凝土的制备及基本力学性能[J]. 硅酸盐通报, 2023, 42(1): 76-84.
[14]	冯春花, 陈钰, 黄益宏, 郭晖, 朱建平. 煤矸石骨料及其改性技术研究进展[J]. 硅酸盐通报, 2023, 42(1): 133-143.
[15]	王富平, 张默, 周博宇. 再生风机叶片纤维对混凝土力学和抗冻性能的影响[J]. 硅酸盐通报, 2023, 42(1): 231-238.

多源石墨固废制备电热板材配方试验研究

Experimental Study on Formula of Electrothermal Plate Prepared from Multi-Source Graphite Solid Waste

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价