硅灰掺量对免烧粉煤灰陶粒性能的影响

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (2): 506-512.

硅灰掺量对免烧粉煤灰陶粒性能的影响

许事成, 苏壮飞, 刘泽, 王栋民, 张彤

中国矿业大学(北京)化学与环境工程学院,北京 100083

收稿日期:2021-09-30 修回日期:2021-12-06 出版日期:2022-02-15 发布日期:2022-03-01
通讯作者: 刘泽,博士,教授。E-mail:lzk1227@sina.com
作者简介:许事成(1999—),男,硕士研究生。主要从事固废资源化利用的研究。E-mail:862978731@qq.com
基金资助:
国家重点研发计划(2019YFC1904300);宁夏回族自治区重点研发计划(2020BCE01001,2021BEG92002);国家自然科学基金联合基金(U20A20324)

Influence of Silica Fume Content on Performance of Non-Sintered Fly Ash Ceramsite

XU Shicheng, SU Zhuangfei, LIU Ze, WANG Dongmin, ZHANG Tong

School of Chemical and Environmental Engineering, China University of Mining and Technology (Beijing), Beijing 100083, China

Received:2021-09-30 Revised:2021-12-06 Online:2022-02-15 Published:2022-03-01

摘要/Abstract

摘要： 以粉煤灰为原料,辅掺硅灰制备了碱激发免烧陶粒。采用筒压强度试验、吸水率试验、含泥量试验、磨破率试验、耐腐蚀试验、X射线衍射仪和扫描电子显微镜试验,系统地研究了硅灰掺量对陶粒性能的影响。结果表明,3 d、7 d、14 d龄期时,随着硅灰掺量增加,粉煤灰陶粒的筒压强度呈逐渐增加趋势,磨破率与吸水率呈逐渐下降趋势,耐腐蚀性能也得到提高。当硅灰掺量为15%和20%(质量分数)时,龄期为14 d时,陶粒的筒压强度分别达到19.43 MPa和20.37 MPa。由微观分析知,适量的硅灰掺量可以提高粉煤灰的水化程度,增加陶粒结构密实性,但当掺量达到15%~20%时,水化程度有所减弱。

关键词: 免烧, 陶粒, 粉煤灰, 硅灰, 碱激发, 筒压强度

Abstract: Alkali-activated non-sintered ceramsite was prepared with fly ash as raw material and silica fume as supplemented agent. The effect of silica fume content on ceramic properties was systematically studied by means of cylinder compressive strength test, water absorption test, mud content test, abrasion rate test, corrosion resistance test, X-ray diffractometer measurement and scanning electron microscope examination. The results show that at the age of 3 d, 7 d, and 14 d, as the content of silica fume increases, the cylinder compressive strength of fly ash ceramsite gradually increases, while the abrasion rate and water absorption decrease gradually, and the corrosion resistance is also improved. When the silica fume content is 15% and 20% by mass, and the age is 14 d, the cylinder compressive strength of the ceramsite reaches 19.43 MPa and 20.37 MPa. According to the microscopic analysis, appropriate silica fume content increases the hydration degree of fly ash and the compactness of the ceramsite structure, but when the content reaches 15% to 20% by mass, the hydration degree is weakened.

Key words: non-sintered, ceramsite, fly ash, silica fume, alkali-activated, cylinder compressive strength

中图分类号:

许事成, 苏壮飞, 刘泽, 王栋民, 张彤. 硅灰掺量对免烧粉煤灰陶粒性能的影响[J]. 硅酸盐通报, 2022, 41(2): 506-512.

XU Shicheng, SU Zhuangfei, LIU Ze, WANG Dongmin, ZHANG Tong. Influence of Silica Fume Content on Performance of Non-Sintered Fly Ash Ceramsite[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(2): 506-512.

参考文献

[1] 代文双.轻质球形水处理滤料的研制[J].本溪冶金高等专科学校学报,2002,4(4):14-15+20.
DAI W S. Development of the slight global water filter material[J]. Journal of Benxi College of Metallurgy, 2002, 4(4): 14-15+20 (in Chinese).
[2] 邓怡帆,冷政,曾维,等.轻质超高强混凝土的配合比设计研究[J].商品混凝土,2020(9):58-61.
DENG Y F, LENG Z, ZENG W, et al. Study on mixture proportion design of lightweight ultra-high strength concrete[J]. Commercial Concrete, 2020(9): 58-61 (in Chinese).
[3] 李惠,丁锐.利用厌氧污泥生产轻质陶粒的研究现状及前景分析[J].吉林工程技术师范学院学报,2009,25(11):78-80.
LI H, DING R. Use of anaerobic sludge for manufacturing light ceramisite[J]. Journal of Jilin Teachers Institute of Engineering and Technology, 2009, 25(11): 78-80 (in Chinese).
[4] 柴春镜,宋慧平,冯政君,等.粉煤灰陶粒的研究进展[J].洁净煤技术,2020,26(6):11-22.
CHAI C J, SONG H P, FENG Z J, et al. Research progress on the fly ash ceramsite[J]. Clean Coal Technology, 2020, 26(6): 11-22 (in Chinese).
[5] 王会平.免烧结粉煤灰生物陶粒滤料研制及在曝气生物滤池中的应用研究[D].南昌:南昌大学,2007.
WANG H P. Manufacture of fly ash biological ceramicite filtering material and application research in biological aerated filter[D]. Nanchang: Nanchang University, 2007 (in Chinese).
[6] 高淑燕.高气孔率的免烧粉煤灰陶粒的制备及其隔热性能研究[D].柳州:广西科技大学,2019.
GAO S Y. Preparation of high-porosity sintering-free fly ash ceramsite and its thermal insulation properties[D]. Liuzhou: Guangxi University of Science and Technology, 2019 (in Chinese).
[7] WU H Q, ZHANG T, PAN R J, et al. Sintering-free preparation of porous ceramsite using low-temperature decomposing pore former and its sound-absorbing performance[J]. Construction and Building Materials, 2018, 171: 367-376.
[8] 何小芳,卢军太,李小楠,等.硅灰对混凝土性能影响的研究进展[J].硅酸盐通报,2013,32(3):423-428.
HE X F, LU J T, LI X N, et al. Progress in research of effect of silica fume on the performance of cement concrete[J]. Bulletin of the Chinese Ceramic Society, 2013, 32(3): 423-428 (in Chinese).
[9] FERNÁNDEZ-JIMÉNEZ A, PALOMO A, SOBRADOS I, et al. The role played by the reactive alumina content in the alkaline activation of fly ashes[J]. Microporous and Mesoporous Materials, 2006, 91(1/2/3): 111-119.
[10] 肖佳,周士琼,徐亦冬.粉煤灰、硅灰对水泥胶砂性能影响的试验研究[J].混凝土,2003(8):28-30+36.
XIAO J, ZHOU S Q, XU Y D. Experimental study on the influence of fly ash and silica fume on the performance of cement mortar[J]. Concrete, 2003(8): 28-30+36 (in Chinese).
[11] FERNÁNDEZ-JIMÉNEZ A, PALOMO A, CRIADO M. Microstructure development of alkali-activated fly ash cement: a descriptive model[J]. Cement and Concrete Research, 2005, 35(6): 1204-1209.
[12] LLOYD R R, PROVIS J L, DEVENTER J S J. Microscopy and microanalysis of inorganic polymer cements. 2: the gel binder[J]. Journal of Materials Science, 2009, 44(2): 620-631.
[13] 王亚超,张耀君,徐德龙.碱激发硅灰-粉煤灰基矿物聚合物的研究[J].硅酸盐通报,2011,30(1):50-54.
WANG Y C, ZHANG Y J, XU D L. Study on alkali-activated silica fume and fly ash based geopolymer[J]. Bulletin of the Chinese Ceramic Society, 2011, 30(1): 50-54 (in Chinese).
[14] 中华人民共和国建设部.水处理用人工陶粒滤料:CJ/T 299—2008[S].北京:中国标准出版社,2009.
Ministry of Construction, PRC. Artificial ceramsite filter material for water treatment: CJ/T 299—2008[S]. Beijing: Standards Press of China, 2009 (in Chinese).
[15] KHATER H M. Effect of silica fume on the characterization of the geopolymer materials[J]. International Journal of Advanced Structural Engineering, 2013, 5(1): 1-10.
[16] 张江泳.硅灰在超高强混凝土中的应用[J].国外建材科技,2008,29(2):12-15.
ZHANG J Y. Application of silica fume in super-high strength concrete[J]. Science and Technology of Overseas Building Materials, 2008, 29(2): 12-15 (in Chinese).
[17] CRIADO M, FERNÁNDEZ-JIMÉNEZ A, DE LA TORRE A G, et al. An XRD study of the effect of the SiO₂/Na₂O ratio on the alkali activation of fly ash[J]. Cement and Concrete Research, 2007, 37(5): 671-679.
[18] PROVIS J L, YONG C Z, DUXSON P, et al. Correlating mechanical and thermal properties of sodium silicate-fly ash geopolymers[J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2009, 336(1/2/3): 57-63.