低碱度水泥基材料固化模拟放射性焚烧灰性能与机理研究

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (1): 182-191.

所属专题：资源综合利用

低碱度水泥基材料固化模拟放射性焚烧灰性能与机理研究

韦琦^1,2, 耿海宁³, 马浩森², 刘艳⁴, 陈伟¹, 王东文⁴, 潘社奇⁴, 李秋¹

1.武汉理工大学硅酸盐建筑材料国家重点实验室,武汉 430070;
2.武汉理工大学材料科学与工程学院,武汉 430070;
3.湖北城市建设职业技术学院,武汉 430205;
4.中国工程物理研究院材料研究所,绵阳 621907

收稿日期:2021-08-26 修订日期:2021-09-29 出版日期:2022-01-15 发布日期:2022-02-10
通信作者: 李秋,博士,研究员。E-mail: Qiu-Li@whut.edu.cn
作者简介:韦琦(1998—),男,硕士研究生。主要从事中低放射性废物水泥固化研究。E-mail:1530574040@qq.com
基金资助:
国家自然科学基金面上项目(52072279);中国工程物理研究院横向科研项目;硅酸盐建筑材料国家重点实验室(武汉理工大学)开放基金(SYSJJ2021-12);深圳市科技计划项目协同创新专项(CJGJZD20200617102601003)

Properties and Mechanism of Solidification of Simulated Radioactive Incineration Ash with Low Alkalinity Cement-Based Materials

WEI Qi^1,2, GENG Haining³, MA Haosen², LIU Yan⁴, CHEN Wei¹, WANG Dongwen⁴, PAN Sheqi⁴, LI Qiu¹

1. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China;
2. School of Materials Science and Engineering, Wuhan University of Technology, Wuhan 430070, China;
3. Hubei Urban Construction Vocational and Technological College, Wuhan 430205, China;
4. Institute of Materials, China Academy of Engineering Physics, Mianyang 621907, China

Received:2021-08-26 Revised:2021-09-29 Online:2022-01-15 Published:2022-02-10

摘要/Abstract

摘要： 放射性焚烧灰中存在铝单质金属,其在碱激发水泥或硅酸盐水泥的高碱性孔溶液环境下会反应产生氢气,造成固化体膨胀与性能劣化。为克服此问题,本研究以水泥、硅灰和粉煤灰为主要原料,添加沸石、聚羧酸减水剂、定优胶和聚合硫酸铝协同改性制备低碱度水泥基材料,开展低碱度水泥基材料对模拟放射性焚烧灰的固化处置研究。结果表明:模拟放射性焚烧灰质量包容量为30%的低碱度水泥基材料固化体的28 d抗压强度达16.6 MPa以上,抗冻融性能、抗浸泡性能及抗冲击性能均满足GB 14569.1—2011《低、中水平放射性废物固化体性能要求-水泥固化体》的要求。Ce³⁺第42 d浸出率为4.41×10^-9 cm/d,累计浸出分数为3.4×10^-7 cm。低碱度水泥基材料固化模拟放射性焚烧灰过程中未产生大量氢气,其原因是,在早期孔溶液pH值较低,同时孔溶液中的高钙离子浓度延缓了焚烧灰中的单质铝与孔溶液发生反应释放氢气的速度,在后期孔溶液pH值低于11.75,焚烧灰中的单质铝不会与孔溶液发生反应。

关键词: 固废处置, 水泥基材料, 低碱度, 放射性焚烧灰, 单质金属, 固化, 浸出率, 累积浸出分数

Abstract: The existence of metallic aluminum in the radioactive incineration ash results in the expansion and deterioration of cement waste forms, due to the reaction of metallic aluminum with high alkali pore solution to produce hydrogen gas in hardened Portland cement or alkali-activated cementitious materials. In this study, low alkalinity cement-based materials were prepared by Portland cement, silica fume and fly ash as the main raw materials, aiming to overcome this problem. Zeolite, polycarboxylate superplasticizer, diutan gum and polyaluminum sulfate were used as well to modify the properties. According to the results, 28 d compressive strength of over 16.6 MPa is achieved by low alkalinity cement-based materials waste forms with 30% (in mass) simulated radioactive incineration ash. The freeze-thaw resistance, immersion resistance and impact resistance meet the requirements of GB 14569.1—2011 specifications. The leaching rate of Ce³⁺ on the 42 d is 4.41×10^-9 cm/d, and the cumulative leaching fraction is 3.4×10^-7 cm. The relatively lower pH value of pore solution in the early age and high Ca concentration in pore solution hinders the reaction between the metallic Al and pore solution. At later age, no reaction between metallic Al and pore solution because the pH value of pore solution is below 11.75.

Key words: solid waste disposal, cement-based material, low alkalinity, radioactive incineration ash, elemental metal, solidification, leaching rate, cumulative leaching fraction

中图分类号:

TL941

韦琦, 耿海宁, 马浩森, 刘艳, 陈伟, 王东文, 潘社奇, 李秋. 低碱度水泥基材料固化模拟放射性焚烧灰性能与机理研究[J]. 硅酸盐通报, 2022, 41(1): 182-191.

WEI Qi, GENG Haining, MA Haosen, LIU Yan, CHEN Wei, WANG Dongwen, PAN Sheqi, LI Qiu. Properties and Mechanism of Solidification of Simulated Radioactive Incineration Ash with Low Alkalinity Cement-Based Materials[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 182-191.

参考文献

[1] 李长成,姚燕,崔琪,等.改性碱激发水泥固化处置模拟放射性焚烧灰[J].硅酸盐学报,2010,38(7):1215-1219.
LI C C, YAO Y, CUI Q, et al. Solidification and disposal of simulated radioactive incineration ash by modified alkali-activated cement[J]. Journal of the Chinese Ceramic Society, 2010, 38(7): 1215-1219 (in Chinese).
[2] 华正韬,刘自强,侯辉娟.放射性焚烧灰处理工艺研究[J].产业与科技论坛,2020,19(21):45-47.
HUA Z T, LIU Z Q, HOU H J. Study on treatment technology of radioactive incineration ash[J]. Industrial & Science Tribune, 2020, 19(21): 45-47 (in Chinese).
[3] 逯迎春.放射性焚烧灰处理方法的研究[J].广东化工,2013,40(7):70-71+78.
LU Y C. Research on the treatment of incineration ash[J]. Guangdong Chemical Industry, 2013, 40(7): 70-71+78 (in Chinese).
[4] 陈乔,陈寒斌,许春霞.建筑胶凝材料固化生活垃圾焚烧飞灰研究进展[J].重庆建筑,2014,13(10):47-49.
CHEN Q, CHEN H B, XU C X. Study progress on fly ash by household garbage burning of building gelation materials solidification[J]. Chongqing Architecture, 2014, 13(10): 47-49 (in Chinese).
[5] XUAN D X, POON C S. Removal of metallic Al and Al/Zn alloys in MSWI bottom ash by alkaline treatment[J]. Journal of Hazardous Materials, 2018, 344: 73-80.
[6] 陈娟.硫铝酸盐水泥的性能调整与应用研究[D].武汉:武汉大学,2005.
CHEN J. Research of properties modification and applications of sulphoaluminate cement[D]. Wuhan: Wuhan University, 2005 (in Chinese).
[7] XUAN D X, TANG P, POON C S. Effect of casting methods and SCMs on properties of mortars prepared with fine MSW incineration bottom ash[J]. Construction and Building Materials, 2018, 167: 890-898.
[8] 沈晓冬,严生,吴学权,等.放射性废物水泥固化的理论基础、研究现状及对水泥化学研究的思考[J].硅酸盐学报,1994,22(2):181-187
SHEN X D, YAN S, WU X Q, et al. The theoretical basis and state-of-art of study on the immobilization of radioactive waste by means of cement and some considerations for the research of cement chemistry[J]. Journal of the Chinese Ceramic Society, 1994, 22(2): 181-187 (in Chinese)
[9] JACKSON M D, MOON J, GOTTI E, et al. Material and elastic properties of Al-tobermorite in ancient Roman seawater concrete[J]. Journal of the American Ceramic Society, 2013, 96(8): 2598-2606.
[10] 蒲心诚,王勇威.高效活性矿物掺料与混凝土的高性能化[J].混凝土,2002(2):3-6.
PU X C, WANG Y W. High efficiency active mineral admixture and high performance of concrete[J]. Concrete, 2002(2): 3-6 (in Chinese).
[11] 李顺,文梓芸.聚羧酸系减水剂的分散作用及引气性能[J].硅酸盐学报,2009,37(4):616-621.
LI S, WEN Z Y. Dispersibility and air entraining performance of polycarboxylate-type water reducers[J]. Journal of the Chinese Ceramic Society, 2009, 37(4): 616-621 (in Chinese).
[12] 张振国,张铭栋,顾平,等.沸石材料吸附水中放射性锶和铯的研究进展[J].化工进展,2019,38(4):1984-1995.
ZHANG Z G, ZHANG M D, GU P, et al. Progress in adsorption of radioactive strontium and cesium from aqueous solution on zeolite materials[J]. Chemical Industry and Engineering Progress, 2019, 38(4): 1984-1995 (in Chinese).
[13] 张郁,权娟娟,刘小华.高掺量矿渣水泥与普硅水泥的水化进程对比研究[J].硅酸盐通报,2014,33(11):3041-3045.
ZHANG Y, QUAN J J, LIU X H. Comparative study of slurry hydration process on high volume content slag cement and ordinary Portland cement[J]. Bulletin of the Chinese Ceramic Society, 2014, 33(11): 3041-3045 (in Chinese).
[14] 胡博,王建朝,刘影,等.铝合金在碱性环境中的耐腐蚀研究进展[J].电镀与环保,2014,34(3):4-6.
HU B, WANG J C, LIU Y, et al. Research progress in corrosion resistance of aluminum alloy in alkaline environment[J]. Electroplating & Pollution Control, 2014, 34(3): 4-6 (in Chinese).
[15] 邵海波,王晓艳,王建明,等.碱土金属离子与EDTA对纯铝在碱性溶液中的协同缓蚀作用[J].物理化学学报,2006,22(3):312-315.
SHAO H B, WANG X Y, WANG J M, et al. The cooperative inhibition effects of alkaline earth metal ions and EDTA on the corrosion of pure aluminum in an alkaline solution[J]. Acta Physico-Chimica Sinica, 2006, 22(3): 312-315 (in Chinese).

低碱度水泥基材料固化模拟放射性焚烧灰性能与机理研究

Properties and Mechanism of Solidification of Simulated Radioactive Incineration Ash with Low Alkalinity Cement-Based Materials

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	郭强, 张晓雷, 史晨曦, 门杰. 赤泥-矿渣基地聚物固化黄土冻融后力学特性研究[J]. 硅酸盐通报, 2024, 43(4): 1482-1489.
[2]	吕亚军, 宋彩红, 党钧陶, 董宾宾, 乔敏, 张康捷, 马肖峰. 两种耐水处理长余辉材料制备发光混凝土的性能对比研究[J]. 硅酸盐通报, 2024, 43(3): 781-792.
[3]	缪新宇, 刘双宇, 陆萍, 张福隆, Vasilieva Tatiana Mikhailovna, 黄传锦, 王立岩, 王斌华. 硅烷偶联剂对氧化铝陶瓷浆料流动性能和3D打印性能的影响[J]. 硅酸盐通报, 2024, 43(3): 1058-1069.
[4]	向杰, 王胜, 李玉杰, 王文杰. 基于响应面法的地热钻采碳纳米管复合水泥基材料的研究[J]. 硅酸盐通报, 2024, 43(2): 495-508.
[5]	刘刚, 李心诚, 刘金军, 蹇守卫, 范璐璐, 涂亮亮. 碱激发垃圾焚烧底灰地聚物的制备及其水化特性研究[J]. 硅酸盐通报, 2024, 43(1): 287-294.
[6]	沈月, 周亚辉, 贾璐, 贾路瑶, 李浩, 姚彬, 邓磊波. 利用不锈钢渣制备微晶玻璃的研究进展[J]. 硅酸盐通报, 2024, 43(1): 347-353.
[7]	刘玉美, 杨浪, 饶峰, 张凯铭, 孙传琳. 氯离子对海工混凝土钢筋腐蚀的研究进展[J]. 硅酸盐通报, 2023, 42(9): 3059-3074.
[8]	郭政, 穆松, 庄智杰, 张浩, 张蕾. 中/高度真空环境下水泥基材料性能的研究进展[J]. 硅酸盐通报, 2023, 42(9): 3075-3082.
[9]	张品乐, 邓让, 胡静, 吴磊, 陶忠. 钢-PVA混杂纤维增强工程水泥基复合材料弯曲性能研究[J]. 硅酸盐通报, 2023, 42(9): 3125-3134.
[10]	张涛, 王腾, 张琰, 谭洪波, 刘佳龙, 董超. 矿渣微粉对水泥净浆性能及氯离子固化作用的影响[J]. 硅酸盐通报, 2023, 42(9): 3240-3247.
[11]	梁文杰, 谭洪波, 吕周岭. 混凝土内源氯离子固化的研究进展[J]. 硅酸盐通报, 2023, 42(8): 2667-2682.
[12]	石信超, 房晶瑞, 郅晓, 陈阁, 马腾坤, 张帅, 曲齐齐. 孔结构和含水量对水泥净浆矿化养护性能的影响[J]. 硅酸盐通报, 2023, 42(8): 2692-2702.
[13]	刘春雨, 袁誉坤, 李丽丽, 方广, 徐凯. 模拟结构用混凝土核废物高温熔融处理研究[J]. 硅酸盐通报, 2023, 42(8): 2781-2786.
[14]	王嘉毅, 汪涛, 聂云鹏, 王琪. IP6-HA改性磷酸镁基复合骨水泥的制备与性能研究[J]. 硅酸盐通报, 2023, 42(8): 2888-2894.
[15]	韩炎兴, 邵斯杰, 施韬, 蓝滢佳. 碳化硅晶须对水泥基材料抗拉及断裂性能的影响[J]. 硅酸盐通报, 2023, 42(7): 2300-2308.