基于压电陶瓷的地聚合物砂浆强度发展监测研究

硅酸盐通报 ›› 2021, Vol. 40 ›› Issue (9): 2905-2910.

基于压电陶瓷的地聚合物砂浆强度发展监测研究

胡鹏兵, 陈娟, 孙航, 蔡高洁, 胡现岳, 刘谨宁

长江大学城市建设学院,荆州 434023

收稿日期:2021-03-23 修回日期:2021-05-05 出版日期:2021-09-15 发布日期:2021-10-08
通讯作者: 陈娟,博士,副教授。E-mail:chenjuan9876@163.com
作者简介:胡鹏兵(1995—),男,硕士研究生。主要从事地聚合物材料性能与健康监测方面的研究。E-mail:pbhu301@163.com
基金资助:
国家自然科学基金面上项目(51778065)

Strength Development Monitoring of Geopolymer Mortar Based on Piezoelectric Ceramics

HU Pengbing, CHEN Juan, SUN Hang, CAI Gaojie, HU Xianyue, LIU Jinning

School of Urban Construction, Yangtze University, Jingzhou 434023, China

Received:2021-03-23 Revised:2021-05-05 Online:2021-09-15 Published:2021-10-08

摘要/Abstract

摘要： 将压电陶瓷(PZT)智能骨料成对嵌入地聚合物砂浆试件内部,利用主动感应法监测不同龄期地聚合物砂浆压电应力波信号,将时域信号图分析和小波包能量分析相结合,探讨了压电信号能量变化与地聚合物砂浆强度变化的对应关系。时域信号图分析表明,随着地聚合物砂浆养护龄期的增加,压电陶瓷智能电压幅值逐步增加,反映了地聚合物砂浆抗压强度的变化过程。小波包能量分析表明,随龄期的增加,地聚合物砂浆抗压强度变化过程与压电信号幅值计算总能量具有一致性。基于地聚合物砂浆抗压强度试验结果与压电陶瓷应力波所计算的能量值,拟合出地聚合物砂浆强度与压电应力波信号计算总能量的相关函数关系。

关键词: 压电陶瓷智能骨料, 地聚合物砂浆, 主动感应法, 小波包能量分析, 时域信号图, 函数关系

Abstract: The piezoelectric ceramics (PZT) smart aggregates were embedded in the geopolymer mortar specimens in pairs, the active induction method was used to monitor the piezoelectric stress wave signals of the geopolymer mortar at different ages, and the time-domain signal diagram analysis was combined with the wavelet packet energy analysis. The corresponding relationship between the energy change of the piezoelectric signal and the strength change of the geopolymer mortar was discussed. The time-domain signal diagram analysis shows that with the increase of the curing age of the geopolymer mortar, the piezoelectric ceramic intelligent voltage amplitude gradually increases, reflecting the change process of the compressive strength of the geopolymer mortar. The wavelet packet energy analysis shows that with the increase of age, the compressive strength of the geopolymer mortar is consistent with the total energy calculated by piezoelectric signal amplitude. Based on the experimental results of the compressive strength of the geopolymer mortar and the energy calculated by stress wave of piezoelectric ceramics, the correlation function between the strength of the geopolymer mortar and the total energy calculated by piezoelectric stress wave signal is fitted.

Key words: piezoelectric ceramics smart aggregate, geopolymer mortar, active induction method, wavelet packet energy analysis, time-domain signal diagram, function

中图分类号:

胡鹏兵, 陈娟, 孙航, 蔡高洁, 胡现岳, 刘谨宁. 基于压电陶瓷的地聚合物砂浆强度发展监测研究[J]. 硅酸盐通报, 2021, 40(9): 2905-2910.

HU Pengbing, CHEN Juan, SUN Hang, CAI Gaojie, HU Xianyue, LIU Jinning. Strength Development Monitoring of Geopolymer Mortar Based on Piezoelectric Ceramics[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(9): 2905-2910.

参考文献

[1] 赵晓燕,李宏男.基于压电陶瓷的混凝土裂缝损伤监测[J].压电与声光,2009,31(3):437-439+443.
ZHAO X Y, LI H N. Crack monitoring of concrete beam based on piezoelectric sensor[J]. Piezoelectrics & Acoustooptics, 2009, 31(3): 437-439+443 (in Chinese).
[2] 李鹏飞.基于压电陶瓷传感器的混凝土早期强度及裂缝监测试验研究[D].长沙:长沙理工大学,2019.
LI P F. The research on early strength and crack monitoring of concrete based on piezoelectric ceramic sensor[D]. Changsha: Changsha University of Science & Technology, 2019 (in Chinese).
[3] 崔俊,王秋良.小波包和功率谱密度分析法在混凝土龄期强度监测中的应用[J].传感技术学报,2017,30(7):1131-1138.
CUI J, WANG Q L. Application of wavelet packet and power spectral density analysis in early age of concrete strength monitoring[J]. Chinese Journal of Sensors and Actuators, 2017, 30(7): 1131-1138 (in Chinese).
[4] GU H, SONG G, DHONDE H, et al. Concrete early-age strength monitoring using embedded piezoelectric transducers[J]. Smart Materials and Structures, 2006, 15(6): 1837-1845.
[5] SONG G, GU H, MO Y L, et al. Concrete structural health monitoring using embedded piezoceramic transducers[J]. Smart Materials and Structures, 2007, 16(4): 959-968.
[6] GU H, SONG G, DHONDE H, et al. Early age strength monitoring of concrete structures using embedded smart piezoelectric transducers[C]//Nondestructive Evaluation for Health Monitoring and Diagnostics. Proc SPIE 6179, Advanced Sensor Technologies for Nondestructive Evaluation and Structural Health Monitoring II, San Diego, CA, USA. 2006, 6179: 61790H.
[7] SHIN S W, QURESHI A R, LEE J Y, et al. Piezoelectric sensor based nondestructive active monitoring of strength gain in concrete[J]. Smart Materials and Structures, 2008, 17(5): 055002.
[8] SHIN S W, OH T K. Application of electro-mechanical impedance sensing technique for online monitoring of strength development in concrete using smart PZT patches[J]. Construction and Building Materials, 2009, 23(2): 1185-1188.
[9] 孙威,陈佳,阎石,等.基于压电智能骨料的混凝土强度监测方法研究[J].混凝土与水泥制品,2016(2):1-5.
SUN W, CHEN J, YAN S, et al. Research on monitor method lo strength of concrete based on piezoelectric smart aggregate[J]. China Concrete and Cement Products, 2016(2): 1-5 (in Chinese).
[10] 朱茜.基于压电主动监测技术的硫铝酸盐水泥水化过程研究[D].武汉:武汉科技大学,2018.
ZHU Q. Monitoring of hydration process of sulphoaluminate cement based on piezoelectric active monitoring technology[D]. Wuhan: Wuhan University of Science and Technology, 2018 (in Chinese).
[11] 杜永峰,杜进府.基于压电智能骨料的套筒灌浆料早期强度监测[J].压电与声光,2020,42(1):142-148.
DU Y F, DU J F. Early strength monitoring of sleeve grouting material with piezoelectric smart aggregate[J]. Piezoelectrics & Acoustooptics, 2020, 42(1): 142-148 (in Chinese).
[12] 闫佳,张海燕,吴波.钢筋-地聚物混凝土黏结性能梁式试验研究[J].建筑结构学报,2019,40(12):178-186.
YAN J, ZHANG H Y, WU B. Beam tests on bond behavior between geopolymer concrete and steel bars[J]. Journal of Building Structures, 2019, 40(12): 178-186 (in Chinese).
[13] KANTARCI F, TÜRKMEN İ, EKINCI E. Optimization of production parameters of geopolymer mortar and concrete: a comprehensive experimental study[J]. Construction and Building Materials, 2019, 228: 116770.
[14] ZHANG H Y, YAN J, KODUR V, et al. Mechanical behavior of concrete beams shear strengthened with textile reinforced geopolymer mortar[J]. Engineering Structures, 2019, 196: 109348.
[15] 国家质量技术监督局.水泥胶砂强度检验方法(ISO法):GB/T 17671—1999[S].北京:中国标准出版社,1999.
The State Bureau of Quality and Technical Supervision. Method of testing cements: determination of strength: GB/T 17671—1999[S]. Beijing: Standards Press of China, 1999 (in Chinese).
[16] ZHANG J C, LI Y, HUANG Y S, et al. A feasibility study on timber moisture monitoring using piezoceramic transducer-enabled active sensing[J]. Sensors, 2018, 18(9): 3100.
[17] 余亮平.基于封装埋入式PZT的混凝土强度监测试验研究[D].武汉:华中科技大学,2013.
YU L P. Experimental study on monitoring of concrete strength based on embedded and packaged PZT[D]. Wuhan: Huazhong University of Science and Technology, 2013 (in Chinese).