添加剂对无水硫酸钙晶须生长的影响及分子动力学模拟

硅酸盐通报 ›› 2023, Vol. 42 ›› Issue (7): 2551-2562.

所属专题：资源综合利用

添加剂对无水硫酸钙晶须生长的影响及分子动力学模拟

秦思成^1,2,3, 吴锦绣^1,2,3, 齐源昊^1,2,3, 柳召刚^1,2,3, 胡艳宏^1,2,3, 冯福山^1,2,3, 李健飞^1,2,3, 张晓伟^1,2,3

1.内蒙古科技大学材料与冶金学院,包头 014010;
2.内蒙古自治区高校稀土现代冶金新技术与应用重点实验室,包头 014010;
3.轻稀土资源绿色提取与高效利用教育部重点实验室,包头 014010

收稿日期:2023-03-22 修订日期:2023-04-18 出版日期:2023-07-15 发布日期:2023-07-25
通信作者: 吴锦绣,博士,副教授。E-mail:wujinxiu888@126.com
作者简介:秦思成(1998—)男,硕士研究生。主要从事稀土固废方面的研究。E-mail:qsc15664666918@163.com
基金资助:
国家自然科学基金(51965053);内蒙古自然科学基金(2021LHMS05018,2022LHMS05022)

Effects of Additives on Anhydrous Calcium Sulfate Whisker Growth and Molecular Dynamics Simulation

QIN Sicheng^1,2,3, WU Jinxiu^1,2,3, QI Yuanhao^1,2,3, LIU Zhaogang^1,2,3, HU Yanhong^1,2,3, FENG Fushan^1,2,3, LI Jianfei^1,2,3, ZHANG Xiaowei^1,2,3

1. School of Materials and Metallurgy, Inner Mongolia University of Science and Technology, Baotou 014010, China;
2. Key Laboratory of Inner Mongolia Autonomous University on New Technologies of Modern Metallurgy and Application of Rare Earth, Baotou 014010, China;
3. Key Laboratory of Green Extraction and Efficient Utilization of Light Rare-Earth Resources, Ministry of Education, Baotou 014010, China

Received:2023-03-22 Revised:2023-04-18 Online:2023-07-15 Published:2023-07-25

摘要/Abstract

摘要： 以硫酸铵废水为原料,采用水热法制备了无水硫酸钙晶须(CSW)。首先研究了十二烷基苯磺酸钠(SDBS)和不同聚合度的聚乙二醇(PEG)对CSW生长行为的影响。然后用Materials Studio 2020软件对SDBS吸附在CSW表面进行分子动力学模拟,计算得到各晶面吸附能。结果表明,产物均为正交晶系的CSW。未加添加剂制备出的CSW平均长度为65.27 μm,长径比为40,但表面粗糙,分布不均匀。加入4%(质量分数)SDBS制备出的CSW形貌最优,分布均匀,表面光滑且均为针状,平均长度为136 μm,长径比为62。SDBS能促进CSW以螺旋位错的形式沿轴向生长,提高CSW长径比。

关键词: 硫酸铵废水, 水热法, 无水硫酸钙晶须, 添加剂, 分子动力学模拟, 吸附能

Abstract: Anhydrous calcium sulfate whiskers (CSW) were prepared by hydrothermal method using ammonium sulfate wastewater as raw material. The influences of sodium dodecylbenzene sulfonate (SDBS) and polyethylene glycol (PEG) with varying polymerization degrees on growth behavior of CSW were researched. Additionally, the molecular dynamics simulation of SDBS adsorption on the surface of CSW using Materials Studio 2020 software was simulated and the adsorption energy of each crystal plane was calculated. The results show that all products belong to CSW of orthogonal crystal system. CSW prepared without additives has an average length of 65.27 μm and an aspect ratio of 40. However, the surface is rough and the distribution is uneven. On the other hand, the CSW prepared by adding 4% (mass fraction) SDBS has the best morphology, uniform distribution, smooth, and needle-like surface, with an average length of 136 μm and an aspect ratio of 62. SDBS promotes the axial growth of CSW in the form of spiral dislocation, so that the aspect ratio of CSW is refined.

Key words: ammonium sulfate wastewater, hydrothermal method, anhydrous calcium sulfate whisker, additive, molecular dynamics simulation, adsorption energy

中图分类号:

TQ132.3

秦思成, 吴锦绣, 齐源昊, 柳召刚, 胡艳宏, 冯福山, 李健飞, 张晓伟. 添加剂对无水硫酸钙晶须生长的影响及分子动力学模拟[J]. 硅酸盐通报, 2023, 42(7): 2551-2562.

QIN Sicheng, WU Jinxiu, QI Yuanhao, LIU Zhaogang, HU Yanhong, FENG Fushan, LI Jianfei, ZHANG Xiaowei. Effects of Additives on Anhydrous Calcium Sulfate Whisker Growth and Molecular Dynamics Simulation[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2023, 42(7): 2551-2562.

参考文献

[1] MA X L, TAN H B, HE X C. Preparation and surface modification of anhydrous calcium sulfate whiskers from FGD gypsum in autoclave-free hydrothermal system[J]. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 2018, 40(17): 2055-2062.
[2] 齐源昊, 吴锦绣, 柳召刚, 等. 无水硫酸钙晶须的制备及表征[J]. 无机盐工业, 2022, 54(10): 109-115.
QI Y H, WU J X, LIU Z G, et al. Preparation and characterization of anhydrous calcium sulfate whisker [J]. Inorganic Chemicals Industry, 2022, 54(10): 109-115 (in Chinese).
[3] 杨娜, 肖汉宁, 郭文明. 添加剂辅助水热法制备硫酸钙晶须及生长机理研究[J]. 硅酸盐学报, 2014, 42(4): 539-544.
YANG N, XIAO H N, GUO W M. Additives-assisted hydrothermal synthesis of calcium sulfate whisker and its growth mechanism[J]. Journal of the Chinese Ceramic Society, 2014, 42(4): 539-544 (in Chinese).
[4] MA B Z, XING P, WANG C Y, et al. A novel way to synthesize calcium sulfate whiskers with high aspect ratios from concentrated calcium nitrate solution[J]. Materials Letters, 2018, 219: 1-3.
[5] 吕智慧, 乃学瑛, 朱东海, 等. 一步水热法制备无水硫酸钙晶须[J]. 人工晶体学报, 2016, 45(3): 612-617.
LYU Z H, NAI X Y, ZHU D H, et al. Preparation of anhydrous calcium sulfate whisker by one-step hydrothermal method[J]. Journal of Synthetic Crystals, 2016, 45(3): 612-617 (in Chinese).
[6] WANG X S, WANG L, WANG Y, et al. Calcium sulfate hemihydrate whiskers obtained from flue gas desulfurization gypsum and used for the adsorption removal of lead[J]. Crystals, 2017, 7(9): 270.
[7] DONG F, HUANG Z Y, TAN H, et al. Effect of additives on calcium sulfate hemihydrate whiskers morphology from calcium sulfate dehydrate and phosphogypsum[J]. Materials and Manufacturing Processes, 2016, 31: 2037-2043.
[8] 郝海青. 利用半干法脱硫灰制备硫酸钙晶须[D]. 沈阳: 东北大学, 2015.
HAO H Q. Preparation of calcium sulfate whisker by semi-dry desulfurization residues[D]. Shenyang: Northeastern University, 2015 (in Chinese).
[9] LIU C, ZHAO Q J, WANG Y G, et al. Hydrothermal synthesis of calcium sulfate whisker from flue gas desulfurization gypsum[J]. Chinese Journal of Chemical Engineering, 2016, 24: 1552-1560.
[10] PANG X Z, YANG J B, PANG M J, et al. Enhanced C atom adsorption on Cu(111) substrate by doping rare earth element Y for Cu-diamond composites: a first-principles study[J]. Journal of Alloys and Compounds, 2020, 831: 154747.
[11] FAN T T, WANG X S, GAO Y, et al. Investigating the interaction mechanism and effect of different calcium sulfate whiskers on performance of asphalt binder[J]. Construction and Building Materials, 2019, 224: 515-533.
[12] ZHOU D, WEI R, ZHU Y L, et al. Calcium sulfate whisker one-step preparation using semi-dry flue gas desulfurization ash and directional growth control[J]. Journal of Cleaner Production, 2021, 290: 125754.
[13] MAO X L, SONG X F, LU G, et al. Effect of additives on the morphology of calcium sulfate hemihydrate: experimental and molecular dynamics simulation studies[J]. Chemical Engineering Journal, 2015, 278: 320-327.
[14] CHENG Y S, WANG C W, WANG S L, et al. Comparison of anionic surfactants dodecylbenzene sulfonic acid and 1, 2, 4-triazole for inhibition of Co corrosion and study of the mechanism for passivation of the Co surface by dodecylbenzene sulfonic acid[J]. Journal of Molecular Liquids, 2022, 353: 118792.
[15] 汪潇, 金彪, 王宇斌, 等. 阴离子在脱硫石膏晶须水热结晶中的作用机理[J]. 高等学校化学学报, 2020, 41(3): 473-480.
WANG X, JIN B, WANG Y B, et al. Interaction mechanism of anions in hydrothermal crystallization of desulfurization gypsum whiskers[J]. Chemical Journal of Chinese Universities, 2020, 41(3): 473-480 (in Chinese).
[16] 牛小超. 稀土石膏制备硫酸钙晶须及改性[D]. 包头: 内蒙古科技大学, 2021.
NIU X C. Rare earth gypsum preparation calcium sulfate crystal and modified[D]. Baotou: Inner Mongolia University of Science & Technology, 2021 (in Chinese).
[17] 张绍奇, 郭荣鑫, 林志伟, 等. 工业副产石膏制备半水硫酸钙晶须的研究现状[J]. 硅酸盐通报, 2020, 39(11): 3528-3534.
ZHANG S Q, GUO R X, LIN Z W, et al. Research status of preparation of calcium sulfate hemihydrate whisker from industrial by-product gypsum[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(11): 3528-3534 (in Chinese).
[18] WANG S Z, CHEN D Y, ZHANG K K. Preparation, characterization, and formation mechanism of calcium sulfate hemihydrate whiskers[J].Journal of Wuhan University of Technology-Mater Sci Ed, 2018, 33(6): 1407-1415.
[19] 曹永丹, 赵天悦, 曹钊, 等. 脱硫石膏制备硫酸钙晶须的试验研究[J]. 硅酸盐通报, 2022, 41(5): 1765-1773.
CAO Y D, ZHAO T Y, CAO Z, et al. Preparation of calcium sulfate whiskers from desulfurized gypsum[J]. Bulletin of the Chinese Ceramic Society, 2022, 41(5): 1765-1773 (in Chinese).
[20] ZHANG X T, RAN L, WANG X, et al. Structural characteristic and formation mechanism of hemihydrate calcium sulfate whiskers prepared using FGD gypsum[J]. Particuology, 2022, 62: 98-103.
[21] CAO B H, WANG X, ZHANG X T, et al. A readily monitored and controllable hydrothermal system for the facile, cost-effective transformation of FGD gypsum to calcium sulfate hemihydrate whiskers[J]. Particuology, 2021, 54: 173-180.
[22] MA X, WU Y, LI L, et al. Effect of SDBS on crystallization behavior of pseudoboehmite[J]. The Journal of Physical Chemistry C, 2021, 125(47): 26039-26048.
[23] FAN H, SONG X F, XU Y X, et al. Insights into the modification for improving the surface property of calcium sulfate whisker: experimental and DFT simulation study[J]. Applied Surface Science, 2019, 478: 594-600.
[24] HOU S C, WANG J, WANG X X, et al. Effect of Mg²⁺on hydrothermal formation of alpha-CaSO₄·0.5H₂O whiskers with high aspect ratios[J]. Langmuir, 2014, 30: 9804-9810.
[25] HAN D D, WANG Y, YANG Y, et al. Revealing the role of a surfactant in the nucleation and crystal growth of thiamine nitrate: experiments and simulation studies[J]. CrystEngComm, 2019, 21(23): 3576-3585.
[26] FU H L, JIA C, CHEN Q S, et al. Effect of particle size on the transformation kinetics of flue gas desulfurization gypsum to α-calcium sulfate hemihydrate under hydrothermal conditions[J]. Particuology, 2018, 40: 98-104.

添加剂对无水硫酸钙晶须生长的影响及分子动力学模拟

Effects of Additives on Anhydrous Calcium Sulfate Whisker Growth and Molecular Dynamics Simulation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	任鹏程, 郑和平, 金祖权, 李梦圆, 李金鑫, 逄博. 地热环境下AFt和AFm的转化机制[J]. 硅酸盐通报, 2023, 42(5): 1551-1560.
[2]	刘佳宁, 洪梅, 魏涛, 陈日, 宋博宇. CTAB改性地质聚合物对地下污染源的阻截作用[J]. 硅酸盐通报, 2023, 42(5): 1831-1840.
[3]	徐宁, 杨恒, 熊传胜, 张栋, 蒋鹏, 刘璨, 刘欣昕, 程星燎. 钢筋混凝土中防腐添加剂的研究进展[J]. 硅酸盐通报, 2023, 42(1): 1-21.
[4]	刘强, 汪潇, 金彪, 林星彤, 张建武, 王宇斌. H₂SO₄-NaCl-H₂O体系中滤液循环利用对脱硫石膏晶须制备的影响[J]. 硅酸盐通报, 2022, 41(9): 3202-3207.
[5]	黄佳, 金应荣, 杨华琳, 陈伟, 李玉玲, 王志杰. 碱性条件下钛石膏晶须生长工艺及机理分析[J]. 硅酸盐通报, 2022, 41(8): 2828-2835.
[6]	陈大业, 陈鹏, 钱家盛, 夏茹, 伍斌. 缺陷对氮化硅导热性能影响的模拟研究[J]. 硅酸盐通报, 2022, 41(5): 1797-1804.
[7]	罗彦恒, 马国军, 李志, 郑顶立, 张翔, 朱俊霖. 添加剂对铜渣还原尾渣微晶玻璃析晶行为及性能的影响[J]. 硅酸盐通报, 2022, 41(11): 3852-3860.
[8]	陈帅, 王庆平, 王彦君, 吴求刚, 赵恒, 陈孝杨, 卢春阳. 地质聚合物固定重金属离子的研究进展[J]. 硅酸盐通报, 2022, 41(10): 3501-3510.
[9]	王波, 段晓波, 邓丽荣, 王嘉博, 陆树河, 王晓刚. β-SiC粉体中常见金属杂质的亚临界水热去除工艺[J]. 硅酸盐通报, 2021, 40(8): 2713-2718.
[10]	金新新, 林鹏, 刘峰, 李赛赛, 李明辉, 夏晓宇, 劳栋, 贾文宝, 单卿. 碳纤维长度以及添加量对碳化硅网状多孔陶瓷性能的影响[J]. 硅酸盐通报, 2021, 40(4): 1330-1337.
[11]	王波, 段晓波, 邓丽荣, 陆树河, 王晓刚, 白枭. β-SiC粉体Si杂质的亚临界水热去除工艺[J]. 硅酸盐通报, 2021, 40(2): 591-596.
[12]	许志强, 左海滨, 刘林程. 铝碳质耐火材料研究进展及展望[J]. 硅酸盐通报, 2021, 40(2): 664-675.
[13]	姚小辉, 黄李金鸿, 黄万抚, 曾祥荣, 黄彪林, 包亚晴. La(H₂O)³⁺₁₀在蒙脱石(001)表面吸附的密度泛函计算[J]. 硅酸盐通报, 2021, 40(11): 3769-3776.
[14]	杨雨菲, 刘浩, 王周福, 刘文元, 马妍, 王玺堂, 柳茂林. 添加剂对酸性硅溶胶及料浆胶凝与流变行为的影响[J]. 硅酸盐通报, 2021, 40(10): 3292-3297.
[15]	王文凯, 谭涓, 王诗涵, 邱鑫. 高硅铝比小晶粒NaY分子筛/高岭土复合物的合成及其催化裂化性能[J]. 硅酸盐通报, 2021, 40(10): 3479-3489.