固废基自发泡烧胀陶粒设计与性能研究

硅酸盐通报 ›› 2023, Vol. 42 ›› Issue (4): 1384-1392.

所属专题：资源综合利用

固废基自发泡烧胀陶粒设计与性能研究

唐佩¹, 蒋事成², 邓腾飞¹, 陈伟^1,3

1.武汉理工大学硅酸盐建筑材料国家重点实验室,武汉 430070;
2.武汉理工大学材料科学与工程学院,武汉 430070;
3.湖北三峡实验室,宜昌 443007

收稿日期:2022-12-08 修订日期:2023-02-15 出版日期:2023-04-15 发布日期:2023-04-25
通信作者: 陈伟,博士,教授。E-mail:chen.wei@whut.edu.cn
作者简介:唐佩(1987—),女,博士,研究员。主要从事生态建筑材料的研究。E-mail:pei-tang@whut.edu.cn
基金资助:
国家重点研发计划(2019YFC1904900);湖北三峡实验室开放/创新基金(SC211004);武汉市知识创新专项-曙光计划项目;深圳市科技计划项目协同创新专项(CJGJZD20200617102601003)

Design and Performance Study of Solid Waste-Based Self-Foaming Expanded Ceramsites

TANG Pei¹, JIANG Shicheng², DENG Tengfei¹, CHEN Wei^1,3

1. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China;
2. School of Materials Science and Engineering, Wuhan University of Technology, Wuhan 430070, China;
3. Hubei Three Gorges Laboratory, Yichang 443007, China

Received:2022-12-08 Revised:2023-02-15 Online:2023-04-15 Published:2023-04-25

摘要/Abstract

摘要： 研究了一种固废基自发泡烧胀陶粒的设计方法,利用赤泥中的赤铁矿高温分解产生气体实现自发泡。固废含量95%(质量分数)的原材料在1 200 ℃煅烧60 min得到了性能优异的轻质高强陶粒,陶粒的颗粒强度为4.86~6.75 MPa,吸水率为0.72%~1.11%,堆积密度为0.53~0.71 g/cm³。利用扫描电子显微镜(SEM)、X射线衍射(XRD)、傅里叶变换红外光谱(FTIR)、热重-差示扫描量热分析(TG-DSC)、X射线光电子能谱(XPS)等测试方法,研究了不同赤泥掺量对烧胀陶粒的物理性能、微观结构、物相组成和化学结构的影响。结果表明,当赤泥的掺量由10%增至25%(质量分数)时,骨料的膨胀率和吸水率呈下降趋势,堆积密度提高,颗粒强度先增后降。赤泥中的赤铁矿高温分解产生的气体被液相包裹是固废基烧胀陶粒自发泡的主要原因。

关键词: 固体废弃物, 烧胀陶粒, 拜耳法高铁赤泥, 赤铁矿, 膨胀率, 自发泡

Abstract: A design method of solid waste-based self-foaming expanded ceramsites was studied, and the gas produced by the decomposition of hematite in red mud at high temperature was used to realize self-foaming. In this study, the ceramsites were produced by sintering the raw materials (95% of which were solid wastes) at 1 200 ℃ for 60 min, and the obtained ceramsites have the characteristics of light weight and high strength. The ceramsites particle strength is 4.86~6.75 MPa, water absorption is 0.72%~1.11%, and bulk density is 0.53~0.71 g/cm³. The influence of red mud content on the physical properties, microstructure, phase components and chemical structure of ceramsites was investigated by SEM, XRD, FTIR, TG-DSC and XPS. The results show that with the content of red mud increases from 10% to 25% (mass fraction), the expansion index and water absorption decrease, the bulk density increases, and the particle strength first increases and then decreases. The main reason of the solid waste-based expanded ceramsites with self-foaming behavior is that hematite decomposed at high temperature to released gas, and the gas is entrapped by the liquid phases.

Key words: solid waste, expanded ceramsite, Bayer Fe-rich red mud, hematite, expansion index, self-foaming

中图分类号:

TQ174.1

唐佩, 蒋事成, 邓腾飞, 陈伟. 固废基自发泡烧胀陶粒设计与性能研究[J]. 硅酸盐通报, 2023, 42(4): 1384-1392.

TANG Pei, JIANG Shicheng, DENG Tengfei, CHEN Wei. Design and Performance Study of Solid Waste-Based Self-Foaming Expanded Ceramsites[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2023, 42(4): 1384-1392.

参考文献

[1] 马明亮, 孙晓南, 权宗刚, 等. 我国工业固废制备陶粒资源化利用的研究进展[J]. 硅酸盐通报, 2020, 39(8): 2492-2500.
MA M L, SUN X N, QUAN Z G, et al. Research progress on resource utilization of ceramsite prepared from industrial solid waste in China[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(8): 2492-2500 (in Chinese).
[2] 王晓丽, 李秋义, 陈帅超, 等. 工业固体废弃物在新型建材领域中的应用研究与展望[J]. 硅酸盐通报, 2019, 38(11): 3456-3464.
WANG X L, LI Q Y, CHEN S C, et al. Application research and prospect of industrial soild waste in new building materials[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(11): 3456-3464 (in Chinese).
[3] LI X G, WANG P Q, GUO Z Z, et al. Effect of Fe²⁺/Fe³⁺ on high-strength ceramsite prepared by sintering geopolymers using iron ore tailings[J]. Ceramics International, 2022, 48(4): 5681-5688.
[4] 李小龙, 李珠, 赵林, 等. 普通粉煤灰制备超轻陶粒的工艺探究[J]. 新型建筑材料, 2019, 46(3): 143-147.
LI X L, LI Z, ZHAO L, et al. Study on the process of preparing ceramsite from common fly ash[J]. New Building Materials, 2019, 46(3): 143-147 (in Chinese).
[5] 柴倩, 孙豪杰, 张红, 等. 煤矸石造孔制备提钒尾渣基陶粒及其性能研究[J]. 安全与环境学报, 2022, 22(4): 2192-2198.
CHAI Q, SUN H J, ZHANG H, et al. Performances research on the vanadium extraction tailing-based ceramsite prepared by coal gangue pore-forming[J]. Journal of Safety and Environment, 2022, 22(4): 2192-2198 (in Chinese).
[6] GAO W B, JIAN S W, LI X G, et al. The use of contaminated soil and lithium slag for the production of sustainable lightweight aggregate[J]. Journal of Cleaner Production, 2022, 348: 131361.
[7] LI X G, HE C H, LV Y, et al. Effect of sintering temperature and dwelling time on the characteristics of lightweight aggregate produced from sewage sludge and waste glass powder[J]. Ceramics International, 2021, 47(23): 33435-33443.
[8] DONDI M, CAPPELLETTI P, D’AMORE M, et al. Lightweight aggregates from waste materials: reappraisal of expansion behavior and prediction schemes for bloating[J]. Construction and Building Materials, 2016, 127: 394-409.
[9] MOLINARI C, ZANELLI C, GUARINI G, et al. Bloating mechanism in lightweight aggregates: effect of processing variables and properties of the vitreous phase[J]. Construction and Building Materials, 2020, 261: 119980.
[10] 张利祥, 高一强, 黄建洪, 等. 赤泥资源化综合利用研究进展[J]. 硅酸盐通报, 2020, 39(1): 144-149.
ZHANG L X, GAO Y Q, HUANG J H, et al. Research progress on resource comprehensive utilization of red mud[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(1): 144-149 (in Chinese).
[11] MI H C, YI L S, WU Q, et al. Preparation of high-strength ceramsite from red mud, fly ash, and bentonite[J]. Ceramics International, 2021, 47(13): 18218-18229.
[12] SUN Y H, LI J S, CHEN Z, et al. Production of lightweight aggregate ceramsite from red mud and municipal solid waste incineration bottom ash: mechanism and optimization[J]. Construction and Building Materials, 2021, 287: 122993.
[13] SONG C G, ZHANG H L, DONG Y M, et al. Investigation on the fabrication of lightweight aggregate with acid-leaching tailings of vanadium-bearing stone coal minerals and red mud[J]. Chinese Journal of Chemical Engineering, 2021, 32: 353-359.
[14] PEI J N, PAN X L, QI Y F, et al. Preparation of ultra-lightweight ceramsite from red mud and immobilization of hazardous elements[J]. Journal of Environmental Chemical Engineering, 2022, 10(4): 108157.
[15] QU X Y, LIU J N, ZHANG M M, et al. Novel glass foam with microwave absorption properties obtained from waste glass, C and Fe₂O₃[J]. Journal of Non-Crystalline Solids, 2023, 601: 122069.
[16] RILEY C M. Relation of chemical properties to the bloating of clays[J]. Journal of the American Ceramic Society, 1951, 34(4): 121-128.
[17] MORENO-MAROTO J M, COBO-CEACERO C J, UCEDA-RODRÍGUEZ M, et al. Unraveling the expansion mechanism in lightweight aggregates: demonstrating that bloating barely requires gas[J]. Construction and Building Materials, 2020, 247: 118583.
[18] GAO W B, JIAN S W, LI B D, et al. Solidification of zinc in lightweight aggregate produced from contaminated soil[J]. Journal of Cleaner Production, 2020, 265: 121784.
[19] GE X X, ZHOU M K, FAN C G, et al. Investigation on strength and failure behavior of ceramic foams prepared from silicoaluminous industrial waste under uniaxial compression[J]. Construction and Building Materials, 2022, 317: 125912.
[20] ZHU X Y, SUN N, HUANG Y, et al. Preparation of full tailings-based foam ceramics and auxiliary foaming effect of vanadium-titanium magnetite tailings[J]. Journal of Non-Crystalline Solids, 2021, 571: 121063.
[21] 马淑龙, 李勇, 孙加林, 等. 氮气气氛下铁铝尖晶石的合成[J]. 硅酸盐学报, 2011, 39(3): 424-429+457.
MA S L, LI Y, SUN J L, et al. Synthesis of hercynites under N₂ atmosphere[J]. Journal of the Chinese Ceramic Society, 2011, 39(3): 424-429+457 (in Chinese).
[22] DENG T F, LI J F. Study on preparation of thermal storage ceramic by using clay shale[J]. Ceramics International, 2016, 42(16): 18128-18135.

固废基自发泡烧胀陶粒设计与性能研究

Design and Performance Study of Solid Waste-Based Self-Foaming Expanded Ceramsites

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	赵珂萍, 李晓玉, 李瑞红, 李浩然, 杨天佐, 犹家进, 彭康. 固废源CaO基CO₂捕集材料的制备与捕集性能研究进展[J]. 硅酸盐通报, 2023, 42(2): 520-530.
[2]	陈潇, 张浩宇, 薛鑫, 杨寅, 龚天天, 张刘阳. 固体废弃物在蒸压加气混凝土中的应用现状综述[J]. 硅酸盐通报, 2023, 42(2): 541-553.
[3]	王璨, 彭同江, 孙红娟, 陈涛, 李湘. 石棉尾渣和粉煤灰制备堇青石多孔陶瓷及其理化性能[J]. 硅酸盐通报, 2023, 42(1): 151-161.
[4]	张日红, 明维, 万文豪, 刘云鹏. 高强粉煤灰-渣土人造骨料的制备与微结构表征[J]. 硅酸盐通报, 2022, 41(8): 2819-2827.
[5]	周永祥, 刘倩, 王祖琦, 郝彤, 冷发光. 流态固化土用无熟料胶凝材料的性能研究[J]. 硅酸盐通报, 2022, 41(10): 3548-3555.
[6]	郭兵兵, 贾雪梅, 张恒基, 刘力源. 固废填料对改性沥青老化过程中的疲劳特性影响研究[J]. 硅酸盐通报, 2021, 40(8): 2822-2830.
[7]	胡星, 陈东平, 余林文, 汪文文, 吴文杰. 环保型套筒灌浆料的配合比设计及性能研究[J]. 硅酸盐通报, 2021, 40(2): 557-564.
[8]	林科杰;弥海晨;向豪;陈华鑫;张晓峰. 沥青路面快速修复用单组分树脂冷补料性能研究[J]. 硅酸盐通报, 2020, 39(5): 1585-1593.
[9]	荣辉;张鸿飞;张磊;张颖;徐蕊;宁彩珍;王雪平. 造纸污泥掺量对污泥陶粒性能的影响[J]. 硅酸盐通报, 2019, 38(9): 2972-297.
[10]	郝惠兰;田玉明;秦梅;郝建英;王凯悦;力国民. 烧结温度对添加镁渣制备陶粒支撑剂性能的影响[J]. 硅酸盐通报, 2019, 38(2): 367-370.
[11]	张洁;张营;孙国文;杨建明. 磷酸钾镁水泥浆体早期变形机制[J]. 硅酸盐通报, 2019, 38(2): 465-470.
[12]	黄春丽;阮永芬;李志伟;马金龙;张涛. 改性膨胀土的膨胀率研究[J]. 硅酸盐通报, 2019, 38(12): 3759-376.
[13]	王晓丽;李秋义;陈帅超;岳公冰. 工业固体废弃物在新型建材领域中的应用研究与展望[J]. 硅酸盐通报, 2019, 38(11): 3456-346.
[14]	李爽;张之璐;唐德莎;黄文聪;余林文;杨凯. CaO类膨胀剂对碱矿渣水泥砂浆限制膨胀率影响研究[J]. 硅酸盐通报, 2018, 37(5): 1747-1752.
[15]	储玉婷;魏亦军;潘路;张连凤;吴凯翔. 菱镁矿尾渣煅烧MgO膨胀剂在一维限制砂浆中的膨胀性能[J]. 硅酸盐通报, 2018, 37(4): 1231-1234.