发泡浆体流变特性对轻质混凝土匀质性的影响

硅酸盐通报 ›› 2023, Vol. 42 ›› Issue (2): 471-477.

所属专题：水泥混凝土

发泡浆体流变特性对轻质混凝土匀质性的影响

潘正华, 蒋亚清, 赵文昊

河海大学力学与材料学院,南京 211100

收稿日期:2022-10-25 修订日期:2022-11-25 出版日期:2023-02-15 发布日期:2023-03-07
通信作者: 蒋亚清,博士,教授。E-mail:yqjiang@hhu.edu.cn
作者简介:潘正华(1998—),男,硕士研究生。主要从事混凝土外加剂方面的研究。E-mail:1006996260@qq.com
基金资助:
国家自然科学基金重点项目(51738003)

Effects of Rheological Properties of Foamed Slurry on Homogeneity of Lightweight Concrete

PAN Zhenghua, JIANG Yaqing, ZHAO Wenhao

College of Mechanics and Materials, Hohai University, Nanjing 211100, China

Received:2022-10-25 Revised:2022-11-25 Online:2023-02-15 Published:2023-03-07

摘要/Abstract

摘要： 为改善轻质混凝土匀质性,提升轻质混凝土力学性能,本文通过建立Herschel-Bulkley(H-B)塑性黏度计算模型,探究了发泡浆体流变特性对泡沫沉降和浆体中陶粒分布的影响。结果表明:随增稠剂掺量的增加,轻质混凝土发泡浆体的屈服应力和基于非线性H-B模型η_H-B=0.016 67K(80ⁿ-20ⁿ)(η_H-B为H-B模型得出的发泡浆体塑性黏度;K为一致性系数;n为流动指数)得到的塑性黏度增大,导致发泡浆体沉降距下降,陶粒在浆体中的分形维数提高;当发泡浆体塑性黏度大于1.74 Pa·s、屈服应力大于92.87 Pa时,可制备抗压强度大于10 MPa的轻质混凝土。由此可见,优化发泡浆体流变特性是克服陶粒在发泡浆体中易上浮问题的关键,可有效改善轻质混凝土匀质性,提升轻质混凝土力学性能。

关键词: 轻质混凝土, 流变特性, 泡沫沉降, 陶粒, 分形维数, 强度

Abstract: In order to improve the homogeneity of lightweight concrete and enhance the mechanical properties of lightweight concrete, the Herschel-Bulkley (H-B) plastic viscosity calculation model was established to explore the influences of rheological characteristics of foamed slurry on the foam settlement and ceramsite distribution in slurry. The results show that with the increase of thickener content, the yield stress and the plastic viscosity of lightweight concrete foamed slurry based on nonlinear H-B model η_H-B=0.016 67K(80ⁿ-20ⁿ) (η_H-B is the plastic viscosity of foamed slurry obtained by H-B calculation model; K is consistency coefficient; n is flow index) increase. As a result, the settlement distance of foamed slurry decreases and the fractal dimension of ceramsite in slurry increases. When the plastic viscosity of foamed slurry is greater than 1.74 Pa·s and the yield stress is greater than 92.87 Pa, the lightweight concrete with compressive strength greater than 10 MPa is prepared. It is seen that optimizing the rheological properties of the foamed slurry is the key to overcome the easy floating problem of ceramsite in foamed slurry, which can effectively improve the homogeneity of lightweight concrete and enhance the mechanical properties of lightweight concrete.

Key words: lightweight concrete, rheological property, foam settlement, ceramsite, fractal dimension, strength

中图分类号:

TU528.2

潘正华, 蒋亚清, 赵文昊. 发泡浆体流变特性对轻质混凝土匀质性的影响[J]. 硅酸盐通报, 2023, 42(2): 471-477.

PAN Zhenghua, JIANG Yaqing, ZHAO Wenhao. Effects of Rheological Properties of Foamed Slurry on Homogeneity of Lightweight Concrete[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2023, 42(2): 471-477.

参考文献

[1] 陈志纯, 李应权, 扈士凯, 等. 我国聚苯乙烯颗粒泡沫混凝土发展现状[J]. 混凝土世界, 2018(4): 26-28.
CHEN Z C, LI Y Q, HU S K, et al. Development status of polystyrene particle foam concrete in China[J]. China Concrete, 2018(4): 26-28 (in Chinese).
[2] 李辛庚, 闫风洁, 岳雪涛, 等. 陶粒混凝土的研究进展[J]. 硅酸盐通报, 2020, 39(11): 3407-3418+3452.
LI X G, YAN F J, YUE X T, et al. Research progress on ceramsite concrete[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(11): 3407-3418+3452 (in Chinese).
[3] 陈松和. 泡沫混凝土体积稳定性及力学性能研究[D]. 南京: 南京航空航天大学, 2016.
CHEN S H. Study on volume stability and mechanical properties of foam concrete[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2016 (in Chinese).
[4] 秦程. 陶粒泡沫混凝土的制备与性能研究[D]. 重庆: 重庆大学, 2018.
QIN C. Study on the preparation and properties of ceramsite foam concrete[D]. Chongqing: Chongqing University, 2018 (in Chinese).
[5] 陈迪森. 搅拌工艺对多孔类骨料混凝土性能的影响[D]. 南宁: 广西大学, 2017.
CHEN D S. Effect of different mixing methods on performance of porous aggregate concrete[D]. Nanning: Guangxi University, 2017 (in Chinese).
[6] 李晋禹, 翁鹤森, 王哲, 等. 滨海软土区泡沫混凝土路基施工技术与沉降控制研究[J]. 路基工程, 2021(1): 127-131.
LI J Y, WENG H S, WANG Z, et al. Research on construction technology and settlement control of foam concrete subgrade in coastal soft soil area[J]. Subgrade Engineering, 2021(1): 127-131 (in Chinese).
[7] 周涛涛. 超细粉体对泡沫混凝土性能的影响研究[D]. 重庆: 重庆大学, 2020.
ZHOU T T. Study on the influence of ultrafine powder on the performance of foam concrete[D]. Chongqing: Chongqing University, 2020 (in Chinese).
[8] 景帅帅. 铁尾矿粉泡沫混凝土特性研究[D]. 西安: 长安大学, 2014.
JING S S. Characteristics and properties of foam concrete with iron ore tailings[D]. Xi'an: Chang'an University, 2014 (in Chinese).
[9] 周翔. 纤维素醚基稳泡剂对泡沫混凝土性能影响的研究[J]. 福建建设科技, 2018(3): 1-3+49.
ZHOU X. Investigation of effect of cellulose ether based foam stabilizer on properties of foamed concrete[J]. Fujian Construction Science & Technology, 2018(3): 1-3+49 (in Chinese).
[10] 詹镇峰, 李从波, 甘伟. 大流动度陶粒混凝土的配制与应用[J]. 混凝土, 2012(6): 114-116.
ZHAN Z F, LI C B, GAN W. Preparation and application of high fluidity ceramsite concrete[J]. Concrete, 2012(6): 114-116 (in Chinese).
[11] 张郁. 铁尾矿陶粒轻质混凝土早期变形及其对物理力学性能的影响研究[D]. 西安: 长安大学, 2021.
ZHANG Y. Study on early deformation of iron ore tailings ceramsite lightweight concrete and its effect on physical and mechanical properties[D]. Xi'an: Chang'an University, 2021 (in Chinese).
[12] ROUSSEL N. Rheology of fresh concrete: from measurements to predictions of casting processes[J]. Materials and Structures, 2007, 40(10): 1001-1012.
[13] 吉旭平, 蒋亚清, 张风臣, 等. 马来酸三乙醇胺酯对水泥水化的影响[J]. 硅酸盐通报, 2020, 39(12): 3770-3774.
JI X P, JIANG Y Q, ZHANG F C, et al. Effect of triethanolamine maleate on cement hydration[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(12): 3770-3774 (in Chinese).
[14] 孙友康. 功能性轻集料及高比强轻质混凝土开发与应用[D]. 南京: 东南大学, 2017.
SUN Y K. Development and application of lightweight aggregate and high strength lightweight concrete[D]. Nanjing: Southeast University, 2017 (in Chinese).
[15] 严锐. 泡沫混凝土的流变性能研究[D]. 合肥: 合肥工业大学, 2017.
YAN R. Research on rheological properties of foam concrete[D]. Hefei: Hefei University of Technology, 2017 (in Chinese).
[16] 白应华, 田冉, 李华伟, 等. 增稠剂与减水剂对泡沫混凝土孔结构稳定性的影响[J]. 新型建筑材料, 2021, 48(9): 115-119.
BAI Y H, TIAN R, LI H W, et al. Influence of thickener and water reducer on stability of cellular concrete pore structure[J]. New Building Materials, 2021, 48(9): 115-119 (in Chinese).
[17] CAI Y D, LIU D M, YAO Y B, et al. Fractal characteristics of coal pores based on classic geometry and thermodynamics models[J]. Acta Geologica Sinica-English Edition, 2011, 85(5): 1150-1162.
[18] 王培铭, 赵国荣, 张国防. 纤维素醚在新拌砂浆中保水增稠作用及其机理[J]. 硅酸盐学报, 2017, 45(8): 1190-1196.
WANG P M, ZHAO G R, ZHANG G F. Mechanism on water retention and thickening of cellulose ethers in fresh mortars[J]. Journal of the Chinese Ceramic Society, 2017, 45(8): 1190-1196 (in Chinese).
[19] EUGENIN C, NAVARRETE I, BREVIS W, et al. Air bubbles as an admixture for printable concrete: a review of the rheological effect of entrained air[J]. 3D Printing and Additive Manufacturing, 2022, 9(1): 64-80.

发泡浆体流变特性对轻质混凝土匀质性的影响

Effects of Rheological Properties of Foamed Slurry on Homogeneity of Lightweight Concrete

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王洪镇, 沈昊, 曹万智, 甘季中, 李文琦, 王海瑞, 褚文斌. 硼酸对硫铝酸盐基复合胶凝材料性能的影响[J]. 硅酸盐通报, 2023, 42(4): 1166-1173.
[2]	殷实, 李北星, 陈鹏博, 金德川. 再生砂混凝土毛细吸水特性研究[J]. 硅酸盐通报, 2023, 42(4): 1205-1216.
[3]	陈春红, 俞江, 刘荣桂, 王磊, 刘惠, 伍金龙. 干湿循环下再生细骨料混凝土的氯离子渗透性能[J]. 硅酸盐通报, 2023, 42(4): 1217-1225.
[4]	张劲竹, 刘华新, 王家贺, 柳根金, 王学志. 混杂纤维混凝土高温后性能劣化分析与强度预测[J]. 硅酸盐通报, 2023, 42(4): 1260-1269.
[5]	汪凯, 燕远岭, 赵哲, 张杯, 李致坤. 界面过渡区与骨料特征对混凝土强度及变形影响的数值模拟研究[J]. 硅酸盐通报, 2023, 42(4): 1298-1308.
[6]	何俊, 管家贤, 吕晓龙, 张驰. 纳米硅粉改良碱渣-矿渣固化淤泥的抗硫酸镁侵蚀性能[J]. 硅酸盐通报, 2023, 42(4): 1344-1352.
[7]	刘扬, 陈湘, 王柏文, 鲁乃唯, 肖欣欣, 罗冬. 碱激发粉煤灰-矿渣-电石渣基地聚物的制备及强度机理[J]. 硅酸盐通报, 2023, 42(4): 1353-1362.
[8]	张先伟, 高永红, 王平, 李江山, 刘世宇, 郎雷, 雷学文. 电解锰渣-生活垃圾焚烧底渣协同制备路面基层材料试验研究[J]. 硅酸盐通报, 2023, 42(4): 1363-1373.
[9]	冯玉林, 高鸽, 柴喜林, 毛攀, 董晶亮, 徐光前, 黄柯靓. 城市污泥尾矿陶粒的制备工艺及其性能与应用[J]. 硅酸盐通报, 2023, 42(4): 1374-1383.
[10]	唐佩, 蒋事成, 邓腾飞, 陈伟. 固废基自发泡烧胀陶粒设计与性能研究[J]. 硅酸盐通报, 2023, 42(4): 1384-1392.
[11]	黄利祥, 刘泽, 原航, 王栋民, 危鹏, 姜宏健. 赤泥-石膏复合激发蒸压加气混凝土的制备与性能研究[J]. 硅酸盐通报, 2023, 42(4): 1393-1399.
[12]	赵竞一, 王闻之, 王其琛, 符有杰, 段佳岐, 李铭涵, 姜宏. 自增韧锌尖晶石-透辉石微晶玻璃力学性能的研究[J]. 硅酸盐通报, 2023, 42(4): 1458-1465.
[13]	陈富文, 桑绍柏, 万卓夫, 马宇洲, 廖宁. 粉煤灰和烧成温度对矾土基轻量莫来石材料结构及性能的影响[J]. 硅酸盐通报, 2023, 42(4): 1488-1495.
[14]	施晓晨, 水中和, 李浩源, 肖勋光, 孙涛, 王雷冲. 紫外预处理对硅酸盐水泥浆体早期碳化性能的影响[J]. 硅酸盐通报, 2023, 42(3): 786-792.
[15]	葛津宇, 韦华, 徐菲, 韩雪松, 朱鹏飞, 肖怀前, 李怀森. CSH-蒙脱石界面能对水泥固化蒙脱土抗压强度的影响[J]. 硅酸盐通报, 2023, 42(3): 827-836.