超硫酸盐水泥净浆的酸性侵蚀劣化机制

摘要/Abstract

摘要： 本文对比研究了超硫酸盐水泥(SSC)与硅酸盐水泥在盐酸侵蚀条件下的力学性能变化规律,探讨了SSC的酸性侵蚀劣化机制。测试了SSC净浆试件正常养护后在盐酸溶液以及清水中抗压强度的变化,并计算了抗压强度保持率;采用X射线衍射(XRD)、扫描电子显微镜(SEM)和热重分析(TG-DTG)等微观测试方法分析了SSC在盐酸侵蚀下水化产物种类和数量的变化,并探究了其微观结构的演化过程,分析了劣化机理。结果表明:不同于硅酸盐体系,SSC体系主要水化产物为钙矾石和水化硅酸钙;与硅酸盐水泥相比,SSC在酸中具有较高的抗压强度保持率和更好的抗酸性侵蚀性能;盐酸侵蚀SSC后,SSC主要水化产物均被分解,体系中存在二水石膏和大量的二氧化硅胶体,而硅酸盐水泥体系中则存在大量的二氧化硅胶体。

关键词: 超硫酸盐水泥, 酸性侵蚀, 盐酸, 劣化机理, 力学性能, 微观结构

Abstract: The mechanical properties of supersulfated cement (SSC) and Portland cement under hydrochloric acid attack were investigated, and the deterioration mechanism by acid erosion was discussed in this paper. The compressive strength of SSC paste in hydrochloric acid and water were measured and the compressive strength retention rate was calculated. The changes of the types and quantities of hydration products and the evolution of microstructure were analyzed by using X-ray diffraction (XRD), scanning electron microscopy (SEM) and thermogravimetric analysis (TG-DTG). The experiment results show that the main hydration products of SSC are ettringite and calcium silicate hydrate, which are different from Portland cement. Compared with Portland cement, SSC shows better compressive strength retention rate and resistance to acid. The deterioration of SSC in hydrochloric acid can be attributed to the dissolution of main hydration products. There are dihydrate gypsum and a lot of silica gel in SSC system, and silica gel in Portland cement after erosion.

Key words: supersulfated cement, acid erosion, hydrochloric acid, deterioration mechanism, mechanical property, microstructure

中图分类号:

TU502

高富豪, 王露, 刘数华. 超硫酸盐水泥净浆的酸性侵蚀劣化机制[J]. 硅酸盐通报, 2022, 41(8): 2618-2627.

GAO Fuhao, WANG Lu, LIU Shuhua. Deterioration Mechanism of Supersulfated Cement Paste by Acid Erosion[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(8): 2618-2627.

参考文献

[1] SUN Z J. Durability of cement concrete under chemical erosion[J]. Chemical Engineering Transactions, 2018, 66: 193-198.
[2] KURDOWSKI W. Cement and concrete chemistry[M]. Springer Netherlands, 2014.
[3] CHEN M C, WANG K, XIE L. Deterioration mechanism of cementitious materials under acid rain attack[J]. Engineering Failure Analysis, 2013, 27: 272-285.
[4] ZIVICA V, BAJZA A. Acidic attack of cement-based materials: a review Part 2. Factors of rate of acidic attack and protective measures[J]. Construction and Building Materials, 2002, 16(4): 215-222.
[5] REVERTEGAT E, RICHET C, GÉGOUT P. Effect of pH on the durability of cement pastes[J]. Cement and Concrete Research, 1992, 22(2/3): 259-272.
[6] 钱觉时,余金城,孙化强,等.钙矾石的形成与作用[J].硅酸盐学报,2017,45(11):1569-1581.
QIAN J S, YU J C, SUN H Q, et al. Formation and function of ettringite in cement hydrates[J]. Journal of the Chinese Ceramic Society, 2017, 45(11): 1569-1581 (in Chinese).
[7] GABRISOVÁ A, HAVLICA J, SAHU S. Stability of calcium sulphoaluminate hydrates in water solutions with various pH values[J]. Cement and Concrete Research, 1991, 21(6): 1023-1027.
[8] KISHAR E A. Hydration reaction of tricalciumaluminate in different systems[J]. Cement and Concrete Research, 2005, 35(8): 1638-1640.
[9] WU L P, HUANG G P, LIU W V. Performance evaluation of nano-silica and silica fume on enhancing acid resistance of cement-based composites for underground structures[J]. Journal of Central South University, 2020, 27(12): 3821-3838.
[10] MUTHU M, YANG E H, UNLUER C. Resistance of graphene oxide-modified cement pastes to hydrochloric acid attack[J]. Construction and Building Materials, 2021, 273: 121990.
[11] GRUYAERT E, VAN DEN HEEDE P, MAES M, et al. Investigation of the influence of blast-furnace slag on the resistance of concrete against organic acid or sulphate attack by means of accelerated degradation tests[J]. Cement and Concrete Research, 2012, 42(1): 173-185.
[12] LI H F, GUO L, XIA Y. Acid rain erosion resistance of concretes containing super-fine mineral admixtures[J]. Applied Mechanics and Materials, 2012, 174/175/176/177: 1402-1405.
[13] KAWAI K, SAKO A, IKUTA T, et al. Deterioration of cement hydrates containing mineral admixtures due to sulfuric acid attack[C]//11th International Conference on Durability of Building Materials and Components. 2008.
[14] WANG L, LIU S H, GAO Y X, et al. Hydration kinetics model of supersulfated cement[C]//RILEM International Symposium on Concrete Modelling. 2014.
[15] Supersulfated cement-composition, specifications and conformity criteria: EN 15743—2010[S]. CEN, Brussels (BE), 2010.
[16] LIU S H, WANG L. Investigation on strength and pore structure of supersulfated cement paste[J]. Materials Science, 2018, 24(3): 314-321.
[17] 王露.超硫酸盐水泥水化特性研究[D].武汉:武汉大学,2015:42-83.
WANG L. The hydration properties research of supersulfated cement[D]. Wuhan: Wuhan University, 2015: 42-83 (in Chinese).
[18] RUBERT S, ANGULSKI DA LUZ C, VARELA M V F, et al. Hydration mechanisms of supersulfated cement[J]. Journal of Thermal Analysis and Calorimetry, 2018, 134(2): 971-980.
[19] PINTO S R, ANGULSKI DA LUZ C, MUNHOZ G S, et al. Durability of phosphogypsum-based supersulfated cement mortar against external attack by sodium and magnesium sulfate[J]. Cement and Concrete Research, 2020, 136: 106172.
[20] GROUNDS T, NOWELL D V, WILBURN F. Resistance of supersulfated cement to strong sulfate solutions[J]. Journal of Thermal Analysis and Calorimetry, 2003, 72: 181-190.
[21] YANG Y, JI T, LIN X J, et al. Biogenic sulfuric acid corrosion resistance of new artificial reef concrete[J]. Construction and Building Materials, 2018, 158: 33-41.
[22] DE WINDT L, DEVILLERS P. Modeling the degradation of Portland cement pastes by biogenic organic acids[J]. Cement and Concrete Research, 2010, 40(8): 1165-1174.
[23] 国家标准化管理委员会.水泥标准稠度用水量、凝结时间、安定性检验方法:GB/T 1346—2011[S].北京:中国标准出版社,2012.
Standardization Administration of the People's Republic of China. Test methods for water requirement of normal consistency, setting time and soundness of the Portland cement: GB/T 1346—2011[S].Beijing: Standards Press of China, 2012 (in Chinese).
[24] LIU S H, WANG Z G. Effect of limestone powder on acid attack characteristics of cement pastes[J]. Materials Science, 2014, 20(4): 503-508.
[25] CAO R Z, YANG J F, LI G X, et al. Resistance of the composite cementitious system of ordinary Portland/calcium sulfoaluminate cement to sulfuric acid attack[J]. Construction and Building Materials, 2022, 329: 127171.
[26] YERRAMALA A, DESAI B. Influence of fly ash replacement on strength properties of cement mortar[J]. International Journal of Engineering Science and Technology, 2012, 4(8): 3657-3665.
[27] 余保英,高育欣,王军.含不同石膏种类的超硫酸盐水泥的水化行为[J].建筑材料学报,2014,17(6):965-971.
YU B Y, GAO Y X, WANG J. Hydration behavior of super sulphated cement with different types of gypsum[J]. Journal of Building Materials, 2014, 17(6): 965-971 (in Chinese).
[28] 国家标准化管理委员会.水泥抗海水侵蚀试验方法:GB/T 38140—2019[S].北京:中国标准出版社,2019.
Standardization Administration of the People's Republic of China. Test method for determining capability of cement exposed to seawater: GB/T 38140—2019[S]. China: Standards Press of China, 2019 (in Chinese).
[29] GUTBERLET T, HILBIG H, BEDDOE R E. Acid attack on hydrated cement: effect of mineral acids on the degradation process[J]. Cement and Concrete Research, 2015, 74: 35-43.
[30] SHI C J, STEGEMANN J A. Acid corrosion resistance of different cementing materials[J]. Cement and Concrete Research, 2000, 30(5): 803-808.
[31] HAVLICA J, SAHU S. Mechanism of ettringite and monosulphate formation[J]. Cement and Concrete Research, 1992, 22(4): 671-677.
[32] ALLAHVERDI A, ŠKVÁRA F. Acidic corrosion of hydrated cement based materials. Part 1. Mechanism of the phenomenon[J]. Ceramics Silikaty, 2000, 44(3): 114-120.