粉煤灰对PVA纤维/水泥基体界面作用及复合材料拉伸性能的影响

摘要/Abstract

摘要： 本文研究了粉煤灰掺量对基体强度、聚乙烯醇(PVA)纤维/水泥基体间界面作用以及无表面修饰PVA纤维应变硬化水泥基复合材料(SHCC)拉伸性能的影响。结果表明,随着粉煤灰掺量的增加,基体的28 d抗压强度在18~93 MPa内呈下降趋势。单轴拉伸试验结果表明,掺入20%(质量分数,下同)和50%粉煤灰对SHCC的影响不明显,随着粉煤灰掺量增至67%和80%,SHCC的多微缝开裂和应变硬化特征呈增强趋势,极限应变值也相应增大,最高达7.2%,并且具有轻质特性。单纤维拔出试验结果显示,高掺量粉煤灰不仅可以降低PVA纤维与基体间的化学黏结作用,还能减弱界面摩擦作用,从而有效抑制了PVA纤维在拔出过程中出现过早断裂,显著提高了无表面修饰PVA纤维SHCC的延展性。

关键词: 混凝土, 应变硬化水泥基复合材料, 粉煤灰, 多微缝开裂, 延展性, 单轴拉伸, 纤维拔出

Abstract: The effects of fly ash content on matrix strength, the interfacial interactions between polyvinyl alcohol (PVA) fiber and cementitious matrix, and the tensile properties of strain-hardening cementitious composites (SHCC) with non-surface-modified PVA fibers were investigated. The results show that with the increase of fly ash content, the 28 d compressive strength of the matrix declines within the range of 18~93 MPa. The uniaxial tensile test results show that the effect of fly ash on SHCC at 20% (mass fraction, the same below) and 50% dosages is insignificant. With the fly ash dosage increasing to 67% and 80%, the multiple-microcracks and strain-hardening characteristics of SHCC tend to be enhanced, and the corresponding ultimate strain increases, up to 7.2%, and SHCC has a characteristic of light weight. The results of fiber pullout test display that the high content of fly ash not only reduces the chemical bond between PVA fibers and the matrix, but also weakens the interfacial friction, which effectively inhibits the premature rupture of PVA fibers during the pullout process, and enhances the ductility of SHCC with non-surface-modified PVA fibers.

Key words: concrete, strain-hardening cementitious composite, fly ash, multiple-microcracks, ductility, uniaxial tensile, fiber pullout

中图分类号:

TB332

姚智高, 林常, 蔡舒, 徐树英, 潘莉莎. 粉煤灰对PVA纤维/水泥基体界面作用及复合材料拉伸性能的影响[J]. 硅酸盐通报, 2022, 41(7): 2327-2336.

YAO Zhigao, LIN Chang, CAI Shu, XU Shuying, PAN Lisha. Effect of Fly Ash on PVA Fiber/Cementitious Matrix Interfacial Interactions and Tensile Properties of Composites[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(7): 2327-2336.

参考文献

[1] KIM B J, YI C K, AHN Y R. Effect of embedment length on pullout behavior of amorphous steel fiber in Portland cement composites[J]. Construction and Building Materials, 2017, 143: 83-91.
[2] 朱弘康,林常,蔡舒,等.PVA纤维类型对应变硬化地聚合物基复合材料力学性能的影响[J].硅酸盐通报,2021,40(11):3693-3701.
ZHU H K, LIN C, CAI S, et al. Influence of PVA fiber type on mechanical properties of strain-hardening geopolymer composites[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(11): 3693-3701 (in Chinese).
[3] WANG S, LI V C. Engineered cementitious composites with high-volume fly ash[J]. ACI Materials Journal, 2007, 104(3): 233-241.
[4] ŞAHMARAN M, ÖZBAY E, YÜCEL H E, et al. Frost resistance and microstructure of engineered cementitious composites: influence of fly ash and micro poly-vinyl-alcohol fiber[J]. Cement and Concrete Composites, 2012, 34(2): 156-165.
[5] PASSUELLO A, MORICONI G, SHAH S P. Cracking behavior of concrete with shrinkage reducing admixtures and PVA fibers[J]. Cement and Concrete Composites, 2009, 31(10): 699-704.
[6] 丁聪,郭丽萍,陈波,等.高强高模PVA纤维表面改性及耐碱性能[J].硅酸盐学报,2019,47(2):228-235.
DING C, GUO L P, CHEN B, et al. Alkali resistance and surface modification of high strength and high modulus PVA fibers[J]. Journal of the Chinese Ceramic Society, 2019, 47(2): 228-235 (in Chinese).
[7] ZHANG Y S, SUN W, LI Z J, et al. Impact properties of geopolymer based extrudates incorporated with fly ash and PVA short fiber[J]. Construction and Building Materials, 2008, 22(3): 370-383.
[8] 崔小燕.PVA纤维混凝土的研究及应用现状[J].江苏建材,2015(2):21-23.
CUI X Y. Research and application progress on PVA concrete[J]. Jiangsu Building Materials, 2015(2): 21-23 (in Chinese).
[9] 王明学.国产聚乙烯醇纤维增韧水泥基复合材料的界面调控及性能研究[D].杭州:浙江理工大学,2019.
WANG M X. Study on interface control and properties of domestic polyvinyl alcohol fiber-engineered cementitious composites[D]. Hangzhou: Zhejiang Sci-Tech University, 2019 (in Chinese).
[10] KANDA T, LI V C. Multiple cracking sequence and saturation in fiber reinforced cementitious composites[J]. Concrete Research and Technology, 1998, 9(2): 19-33.
[11] BHUTTA A, FAROOQ M, BANTHIA N. Matrix hybridization using waste fuel ash and slag in alkali-activated composites and its influence on maturity of fiber-matrix bond[J]. Journal of Cleaner Production, 2018, 177: 857-867.
[12] HISSEINE O A, TAGNIT-HAMOU A. Characterization and nano-engineering the interface properties of PVA fibers in strain-hardening cementitious composites incorporating high-volume ground-glass pozzolans[J]. Construction and Building Materials, 2020, 234: 117213.
[13] LI V C, WU C, WANG S, et al. Interface tailoring for strain-hardening polyvinyl alcohol-engineered cementitious composite (PVA-ECC)[J]. ACI Materials Journal, 2002, 99(5): 463-472.
[14] 林水东,李莉,王琪.熔纺聚乙烯醇纤维对水泥砂浆的增强增韧作用[J].高分子材料科学与工程,2011,27(5):120-123+128.
LIN S D, LI L, WANG Q. Cement-mortar composites reinforced and toughened by melt spun PVA fibers[J]. Polymer Materials Science & Engineering, 2011, 27(5): 120-123+128 (in Chinese).
[15] 王海超,张玲玲,高淑玲,等.PVA纤维对超高韧性纤维增强水泥基复合材料力学性能的影响[J].混凝土,2013(4):4-7+14.
WANG H C, ZHANG L L, GAO S L, et al. Experimental study on influence of PVA fiber on mechanical properties of engineered cementitious composites[J]. Concrete, 2013(4): 4-7+14 (in Chinese).
[16] 彭明强,李国友,范磊,等.国产PVA纤维用于高韧性纤维增强水泥基复合材料的试验研究[J].混凝土与水泥制品,2016(2):58-62.
PENG M Q, LI G Y, FAN L, et al. Experimenlal research on high tougliness fiber cementitious composite materials used by domestic PVA fiber[J]. China Concrete and Cement Products, 2016(2): 58-62 (in Chinese).
[17] 潘钻峰,汪卫,孟少平,等.混杂聚乙烯醇纤维增强水泥基复合材料力学性能[J].同济大学学报(自然科学版),2015,43(1):33-40.
PAN Z F, WANG W, MENG S P, et al. Study on mechanical properties of hybrid PVA fibers reinforced cementitious composites[J]. Journal of Tongji University (Natural Science), 2015, 43(1): 33-40 (in Chinese).
[18] 汪卫,潘钻峰,孟少平,等.国产PVA纤维增强水泥基复合材料力学性能研究[J].工业建筑,2014,44(s1):958-964.
WANG W, PAN Z F, MENG S P, et al. Study on mechanical properties of domestic pva fiber reinforced cementitious composite[J]. Industrial Construction, 2014, 44(s1): 958-964 (in Chinese).
[19] ZHANG Z G, ZHANG Q. Matrix tailoring of engineered cementitious composites (ECC) with non-oil-coated, low tensile strength PVA fiber[J]. Construction and Building Materials, 2018, 161: 420-431.
[20] MA H, QIAN S Z, ZHANG Z G, et al. Tailoring engineered cementitious composites with local ingredients[J]. Construction and Building Materials, 2015, 101: 584-595.
[21] ARAIN M F, WANG M X, CHEN J Y, et al. Study on PVA fiber surface modification for strain-hardening cementitious composites (PVA-SHCC)[J]. Construction and Building Materials, 2019, 197: 107-116.
[22] DING C, GUO L P, CHEN B, et al. Micromechanics theory guidelines and method exploration for surface treatment of PVA fibers used in high-ductility cementitious composites[J]. Construction and Building Materials, 2019, 196: 154-165.
[23] 阚黎黎,章志,张利,等.低成本PVA纤维对超高韧性水泥基复合材料力学性能的影响[J].工程力学,2019,36(11):121-129+182.
KAN L L, ZHANG Z, ZHANG L, et al. Effect of low-cost PVA fibers on the mechanical properties of engineered cementitious composites[J]. Engineering Mechanics, 2019, 36(11): 121-129+182 (in Chinese).
[24] 张亚男,臧栋,林常,等.无表面修饰PVA纤维增强高韧应变硬化水泥基复合材料的性能研究[J].硅酸盐通报,2020,39(9):2745-2753.
ZHANG Y N, ZANG D, LIN C, et al. Properties of high-toughness strain-hardening cementitious composites reinforced by PVA fiber without surface modification[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(9): 2745-2753 (in Chinese).
[25] ASTM Standards. Standard test method for compressive strength of hydraulic cement mortars: C109/C109M-21[S]. West Conshohocken: ASTM International, 2016.
[26] KANDA T, LI V C. Interface property and apparent strength of high-strength hydrophilic fiber in cement matrix[J]. Journal of Materials in Civil Engineering, 1998, 10(1): 5-13.
[27] YANG E H, YANG Y, LI V C. Use of high volumes of fly ash to improve ECC mechanical properties and material greenness[J]. ACI Materials Journal, 2007, 104(6): 620.