煤矸石对泡沫混凝土孔结构的影响

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (6): 2047-2052.

所属专题：资源综合利用

煤矸石对泡沫混凝土孔结构的影响

白应华, 潘秋阳

湖北工业大学土木建筑与环境学院,武汉 430068

收稿日期:2022-01-08 修订日期:2022-03-19 出版日期:2022-06-15 发布日期:2022-07-01
作者简介:白应华(1975—),男,副教授。主要从事新型混凝土材料与结构研究。E-mail:yhbai750608@163.com
基金资助:
硅酸盐建筑材料国家重点实验室(武汉理工大学)开放基金(SYSJJ2019-22)

Effect of Coal Gangue on Pore Structure of Foam Concrete

BAI Yinghua, PAN Qiuyang

School of Civil Engineering, Architecture and Environment, Hubei University of Technology, Wuhan 430068, China

Received:2022-01-08 Revised:2022-03-19 Online:2022-06-15 Published:2022-07-01

摘要/Abstract

摘要： 本文将粉磨之后的煤矸石替代部分水泥掺入到混凝土中,通过物理发泡工艺制备煤矸石泡沫混凝土。采用FiJi-imageJ图像分析技术等对泡沫混凝土的孔径分布、平均孔径、气孔直径等进行表征,分析了煤矸石改善泡沫混凝土成孔的原因以及煤矸石粉磨粒径对泡沫混凝土抗压强度的影响。结果表明:当掺入粒径为45 μm的煤矸石粉时,泡沫混凝土的强度随着掺量的增加逐步下降,而掺入粒径为15 μm的煤矸石粉时,强度则随掺量的增加呈先上升后下降的趋势;在调节孔结构方面,粒径为45 μm的煤矸石粉优于粒径为15 μm的煤矸石粉,并在50%(质量分数)掺量下达到最优效果。

关键词: 煤矸石, 泡沫混凝土, 孔径分布, 抗压强度, 平均孔径, 气孔直径

Abstract: The coal gangue after grinding was added into concrete instead of part of cement, and the coal gangue foam concrete was prepared by physical foaming process. Then, the pore size distribution, average pore size and pore diameter of foam concrete were characterized by FiJi-imageJ image analysis technology. The reasons for improving the porosity of foam concrete by coal gangue and the effect of coal gangue particle size on the compressive strength of foam concrete were analyzed. The results show that when the coal gangue powder with particle size of 45 μm is added, the strength of foam concrete decreases with the increase of coal gangue content, while when the coal gangue powder with particle size of 15 μm is added, the strength increases first and then decreases with the increase of coal gangue content. The coal gangue powder with particle size of 45 μm is better than the coal gangue powder with particle size of 15 μm in adjusting the pore structure, and the optimal effect is achieved at the content of 50% (mass fraction).

Key words: coal gangue, foam concrete, pore size distribution, compressive strength, average pore size, pore diameter

中图分类号:

TU528

白应华, 潘秋阳. 煤矸石对泡沫混凝土孔结构的影响[J]. 硅酸盐通报, 2022, 41(6): 2047-2052.

BAI Yinghua, PAN Qiuyang. Effect of Coal Gangue on Pore Structure of Foam Concrete[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(6): 2047-2052.

参考文献

[1] ZHANG Y L, LING T C. Reactivity activation of waste coal gangue and its impact on the properties of cement-based materials: a review[J]. Construction and Building Materials, 2020, 234.
[2] LI Y F, LIU S H, GUAN X M. Multitechnique investigation of concrete with coal gangue[J]. Construction and Building Materials, 2021, 301: 124114.
[3] QIN L, GAO X J. Properties of coal gangue-Portland cement mixture with carbonation[J]. Fuel, 2019, 245: 1-12.
[4] WANG C L, NI W, ZHANG S Q, et al. Preparation and properties of autoclaved aerated concrete using coal gangue and iron ore tailings[J]. Construction and Building Materials, 2016, 104: 109-115.
[5] 田国鑫,黄俊.浅谈国内外泡沫混凝土的发展与应用[J].混凝土,2017(3):124-128.
TIAN G X, HUANG J. Discussion on the development and application of foamed concrete[J]. Concrete, 2017(3): 124-128 (in Chinese).
[6] FALLIANO D, DE DOMENICO D, RICCIARDI G, et al. Experimental investigation on the compressive strength of foamed concrete: effect of curing conditions, cement type, foaming agent and dry density[J]. Construction and Building Materials, 2018, 165: 735-749.
[7] JONES M R, OZLUTAS K, ZHENG L. High-volume, ultra-low-density fly ash foamed concrete[J]. Magazine of Concrete Research, 2017, 69(22): 1146-1156.
[8] 揣丹,温久然,刘开平,等.煤矸石泡沫混凝土的试验研究[J].混凝土,2013(6):132-135.
CHUAI D, WEN J R, LIU K P, et al. Research on preparation of coal gangue foam concrete[J]. Concrete, 2013(6): 132-135 (in Chinese).
[9] 李德军.煤矸石泡沫混凝土的研究[D].重庆:重庆大学,2007.
LI D J. Study on coal gangue foam concrete[D]. Chongqing: Chongqing University, 2007 (in Chinese).
[10] WU R D, DAI S B, JIAN S W, et al. Utilization of solid waste high-volume calcium coal gangue in autoclaved aerated concrete: physico-mechanical properties, hydration products and economic costs[J]. Journal of Cleaner Production, 2021, 278: 123416.
[11] 张林春,张爱莲,王倩,等.掺煤矸石泡沫混凝土制备及力学性能[J].硅酸盐通报,2020,39(9):2800-2806.
ZHANG L C, ZHANG A L, WANG Q, et al. Preparation and mechanical properties of foamed concrete mixed with coal gangue[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(9): 2800-2806 (in Chinese).
[12] 杨志渊.过火煤矸石对中等密度泡沫混凝土性能的影响[D].哈尔滨:哈尔滨工业大学,2017:3-6.
YANG Z Y. The influence of calcined coal gangue on the properties of medium-density foam concrete[D]. Harbin: Harbin Institute of Technology, 2017: 3-6 (in Chinese).
[13] 李月香,李超刚,俞心刚.煤矸石掺量对泡沫混凝土性能的影响[J].新型建筑材料,2017,44(11):117-120.
LI Y X, LI C G, YU X G. Effect of gangue content on the properties of foam concrete[J]. New Building Materials, 2017, 44(11): 117-120 (in Chinese).
[14] 张旭,王武祥,杨鼎宜,等.超轻泡沫混凝土孔结构调控措施研究[J].硅酸盐通报,2019,38(7):2255-2259+2267.
ZHANG X, WANG W X, YANG D Y, et al. Study on control measures of pore structure of ultra light foam concrete[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(7): 2255-2259+2267 (in Chinese).
[15] 嵇鹰,张军,武艳文,等.粉煤灰对泡沫混凝土气孔结构及抗压强度的影响[J].硅酸盐通报,2018,37(11):3657-3662.
JI Y, ZHANG J, WU Y W, et al. Influence of fly ash on void and compressive strength of foam concrete[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(11): 3657-3662 (in Chinese).
[16] RAJ A, SATHYAN D, MINI K M. Physical and functional characteristics of foam concrete: a review[J]. Construction and Building Materials, 2019, 221: 787-799.
[17] ZENG X H, LAN X L, ZHU H S, et al. A review on bubble stability in fresh concrete: mechanisms and main factors[J]. Materials (Basel, Switzerland), 2020, 13(8): 1820.
[18] 张文华,杨冯皓,吕毓静,等.泡沫混凝土的稳泡措施和机理研究进展[J].硅酸盐学报,2021,49(10):2266-2275.
ZHANG W H, YANG F H, LV Y J, et al. Research progress on foam stabilization method and mechanism of foamed concrete[J]. Journal of the Chinese Ceramic Society, 2021, 49(10): 2266-2275 (in Chinese).

煤矸石对泡沫混凝土孔结构的影响

Effect of Coal Gangue on Pore Structure of Foam Concrete

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	马继树, 杨淑雁. 西北大温差环境下温度对硫铝酸盐水泥砂浆抗压强度的影响[J]. 硅酸盐通报, 2024, 43(4): 1388-1397.
[2]	毛翔, 杨鼎宜, 曹忠露, 赵健, 陈龙祥, 王彤章. 基于图像法对自密实超高性能混凝土性能提升的研究[J]. 硅酸盐通报, 2024, 43(4): 1398-1409.
[3]	曹启坤, 景昊星, 李豪. 基于响应曲面法的粉煤灰泡沫混凝土配合比优化[J]. 硅酸盐通报, 2024, 43(4): 1427-1435.
[4]	郑述芳, 李华影, 陈祥花, 梁莹, 陈宗平. 粉煤灰掺量对全再生自密实混凝土工作性能与力学性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1445-1454.
[5]	郭强, 张晓雷, 史晨曦, 门杰. 赤泥-矿渣基地聚物固化黄土冻融后力学特性研究[J]. 硅酸盐通报, 2024, 43(4): 1482-1489.
[6]	付思远, 吕文欣, 韦家崭, 柯善军. 工艺参数对抛光渣轻质陶瓷砖性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1524-1531.
[7]	李兆睿, 王振军, 张海宝, 张亚明, 张松林, 张博伦. 三乙醇胺和硬脂酸锌对泡沫混凝土性能的影响[J]. 硅酸盐通报, 2024, 43(3): 793-805.
[8]	付弯弯, 劳家岳, 郭柯钰, 陈柳维, 吴世芳, 周薇, 谭晓明, 彭浩. 装配式建筑用聚合物乳液改性套筒灌浆料的制备及性能研究[J]. 硅酸盐通报, 2024, 43(3): 833-843.
[9]	张梦真, 娄广辉, 刘子娴, 蔡基伟, 许鸽龙, 乔一佳, 张祥飞. 硫酸亚铁对铝酸盐水泥浆体性能及水化产物的影响[J]. 硅酸盐通报, 2024, 43(3): 844-850.
[10]	宁慧员, 张菊, 闫长旺, 白茹. 基于高斯过程回归模型的电石渣激发煤矸石地聚合物强度响应预测与分析[J]. 硅酸盐通报, 2024, 43(3): 905-913.
[11]	蒋明屾, 李飞, 周理安, 宁佳蕊, 张政. 碳酸钠、氢氧化钠与水玻璃复合激发对地聚物胶凝材料性能的影响[J]. 硅酸盐通报, 2024, 43(3): 929-937.
[12]	盖珂瑜, 龙勇, 陈露一, 李信, 刘开志, 王宇, 孙涛. 矿物掺合料复掺对超高性能湿接缝混凝土性能的影响[J]. 硅酸盐通报, 2024, 43(3): 948-955.
[13]	王若愚, 王焕焕, 陈衡, 侯鹏坤, 李贝贝. 纳米二氧化硅对超硫酸盐水泥中石膏最佳掺量的影响[J]. 硅酸盐通报, 2024, 43(3): 995-1002.
[14]	尹鹏翔, 李静. 废玻璃粉对泡沫混凝土性能和微观孔结构的影响及其价值工程分析[J]. 硅酸盐通报, 2024, 43(3): 1021-1029.
[15]	胡川, 杨文伟, 赵环环. CaF₂污泥对硅酸盐水泥性能的影响及机理分析[J]. 硅酸盐通报, 2024, 43(3): 1030-1038.