利用煅烧硅藻土制备高稳态超高性能混凝土基体研究

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (6): 1888-1895.

所属专题：水泥混凝土

利用煅烧硅藻土制备高稳态超高性能混凝土基体研究

刘开志^1,2, 龙勇¹, 陈露一¹, 李晨¹, 吴柏翰¹, 水中和², 余睿², 费顺鑫³

1.中铁大桥局集团有限公司桥梁结构健康与安全国家重点实验室,武汉 430034;
2.武汉理工大学硅酸盐建筑材料国家重点实验室,武汉 430070;
3.安徽工业大学材料科学与工程学院,马鞍山 243002

收稿日期:2022-02-24 修订日期:2022-04-06 出版日期:2022-06-15 发布日期:2022-07-01
作者简介:刘开志(1985—),男,博士,工程师。主要从事超高性能水泥基材料研究。E-mail:303591965@qq.com
基金资助:
中铁大桥局集团有限公司重点研发课题(2021-44-重点);桥梁结构健康与安全国家重点实验室开放研究基金(BHSKL21-08-KF);国家自然科学基金青年基金(51608409);湖北省支持企业技术创新发展项目(2021BLB155)

Preparation of High Stability Ultra-High Performance Concrete Matrix with Calcined Diatomite

LIU Kaizhi^1,2, LONG Yong¹, CHEN Luyi¹, LI Chen¹, WU Baihan¹, SHUI Zhonghe², YU Rui², FEI Shunxin³

1. State Key Laboratory for Health and Safety of Bridge Structures, China Railway Major Bridge Engineering Group Co., Ltd., Wuhan 430034, China;
2. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China;
3. School of Materials Science and Engineering, Anhui University of Technology, Maanshan 243002, China

Received:2022-02-24 Revised:2022-04-06 Online:2022-06-15 Published:2022-07-01

摘要/Abstract

摘要： 超高性能混凝土(UHPC)早期自收缩大,使结构存在收缩开裂风险,掺入天然多孔活性粉料以激发其火山灰和内养护协同效应可有效降低UHPC自收缩,改善基体体积稳定性。本文利用煅烧硅藻土以一定体积分数(3%、6%、9%)置换水泥制备UHPC基体,并对其新拌性能、力学性能、自收缩、耐久性能及孔结构与微观结构进行了系统评价。结果表明:掺入煅烧硅藻土能显著改善UHPC力学性能和体积稳定性,并进一步提升其耐久性能;掺入煅烧硅藻土UHPC基体孔结构得到优化,孔隙率降低,孔径细化;掺入煅烧硅藻土UHPC基体中C-S-H凝胶平均Ca/Si比下降,C-S-H(I)占比提高,水化产物结构及致密性改善。优化设计条件下,UHPC基体56 d抗压强度提高9%,56 d抗折强度提高18%,7 d自收缩下降29%,28 d快速氯离子迁移系数下降35%,28 d电通量下降27%。

关键词: 超高性能混凝土, 煅烧硅藻土, 自收缩, 耐久性能, 孔结构, 微观结构

Abstract: The large early autogenous shrinkage of ultra-high performance concrete (UHPC) will put the concrete at cracking risk, and adding natural porous active powders to stimulate the synergistic effect of pozzolan and internal curing can effectively reduce the shrinkage deformation and improve the volume stability of UHPC matrix. In this study, UHPC matrix was prepared by replacing cement with calcined diatomite in a certain volume fraction (3%, 6%, 9%), its macro performances such as fresh behaviors, mechanical properties, autogenous shrinkage, durability, and microscopic characteristics such as pore structure and microstructure were investigated. The results show that the incorporation of calcined diatomite significantly improves the mechanical properties and volume stability of UHPC matrix, and further enhances its durability. The pore structure of UHPC matrix with calcined diatomite is optimized, the porosity is reduced and the pore diameter is refined. The average Ca/Si ratio of C-S-H gel in UHPC matrix with calcined diatomite decreases, the proportion of C-S-H (I) increases, and the compactness of hydration products is improved. With the optimized design, the 56 d compressive strength of UHPC matrix increases by 9%, 56 d flexural strength increases by 18%, 7 d autogenous shrinkage decreases by 29%, 28 d rapid chloride ion migration coefficient decreases by 35%, and 28 d electric flux decreases by 27%.

Key words: ultra-high performance concrete, calcined diatomite, autogenous shrinkage, durability, pore structure, microstructure

中图分类号:

TU528

刘开志, 龙勇, 陈露一, 李晨, 吴柏翰, 水中和, 余睿, 费顺鑫. 利用煅烧硅藻土制备高稳态超高性能混凝土基体研究[J]. 硅酸盐通报, 2022, 41(6): 1888-1895.

LIU Kaizhi, LONG Yong, CHEN Luyi, LI Chen, WU Baihan, SHUI Zhonghe, YU Rui, FEI Shunxin. Preparation of High Stability Ultra-High Performance Concrete Matrix with Calcined Diatomite[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(6): 1888-1895.

参考文献

[1] RICHARD P, CHEYREZY M. Composition of reactive powder concretes[J]. Cement and Concrete Research, 1995, 25(7): 1501-1511.
[2] 王德辉,史才军,吴林妹.超高性能混凝土在中国的研究和应用[J].硅酸盐通报,2016,35(1):141-149.
WANG D H, SHI C J, WU L M. Research and applications of ultra-high performance concrete (UHPC) in China[J]. Bulletin of the Chinese Ceramic Society, 2016, 35(1): 141-149 (in Chinese).
[3] VAN V T A, RÖβLER C, BUI D D, et al. Rice husk ash as both pozzolanic admixture and internal curing agent in ultra-high performance concrete[J]. Cement and Concrete Composites, 2014, 53: 270-278.
[4] YE G, NGUYEN V T. Mitigation of autogenous shrinkage of ultra-high performance concrete by rice husk ash[J]. Journal of the Chinese Ceramic Society, 2012, 40(2): 212-216.
[5] 黄政宇,张猜兵.多孔超细粉对超高性能混凝土性能的影响研究[J].硅酸盐通报,2015,34(7):1736-1743.
HUANG Z Y, ZHANG C B. Effect of porous superfine powder on the performance of ultra high performance concrete[J]. Bulletin of the Chinese Ceramic Society, 2015, 34(7): 1736-1743 (in Chinese).
[6] MUHD NORHASRI M S, HAMIDAH M S, FADZIL A M, et al. Inclusion of nano metakaolin as additive in ultra high performance concrete (UHPC)[J]. Construction and Building Materials, 2016, 127: 167-175.
[7] LI Z Q. Drying shrinkage prediction of paste containing meta-kaolin and ultrafine fly ash for developing ultra-high performance concrete[J]. Materials Today Communications, 2016, 6: 74-80.
[8] 蒋春园,余睿,马东华,等.复合火山灰材料对超高性能混凝土性能与微观结构的物理化学效应[J].硅酸盐通报,2019,38(4):1102-1107.
JIANG C Y, YU R, MA D H, et al. Physical and chemical influences of compounded pozzolanic material on the properties and microstructure development of ultra-high performance concrete (UHPC)[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(4): 1102-1107 (in Chinese).
[9] 黄政宇,王理胜.掺偏高岭土超高性能装饰混凝土的研究[J].混凝土,2018(5):118-122.
HUANG Z Y, WANG L S. Research on ultra high performance decorative concrete with metakaolin[J]. Concrete, 2018(5): 118-122 (in Chinese).
[10] 夏明钢.煅烧硅藻土对轻集料保温混凝土性能的影响[J].硅酸盐通报,2018,37(9):3012-3016+3035.
XIA M G. Effects of calcined diatomite on the performances of light aggregate insulation concrete[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(9): 3012-3016+3035 (in Chinese).
[11] 刘东升,黄谦,王朝强.煅烧改性硅藻土基干混砂浆的制备及性能研究[J].非金属矿,2018,41(5):41-44.
LIU D S, HUANG Q, WANG C Q. Research on the preparation and properties of calcined modified diatomite based dry-mixed mortar[J]. Non-Metallic Mines, 2018, 41(5): 41-44 (in Chinese).
[12] YU R, SPIESZ P, BROUWERS H J H. Mix design and properties assessment of ultra-high performance fibre reinforced concrete (UHPFRC)[J]. Cement and Concrete Research, 2014, 56: 29-39.
[13] WANG X P, YU R, SHUI Z H, et al. Mix design and characteristics evaluation of an eco-friendly ultra-high performance concrete incorporating recycled coral based materials[J]. Journal of Cleaner Production, 2017, 165: 70-80.
[14] GALLUCCI E, MATHUR P, SCRIVENER K. Microstructural development of early age hydration shells around cement grains[J]. Cement and Concrete Research, 2010, 40(1): 4-13.
[15] DING M X, YU R, FENG Y, et al. Possibility and advantages of producing an ultra-high performance concrete (UHPC) with ultra-low cement content[J]. Construction and Building Materials, 2021, 273: 122023.
[16] LOTHENBACH B, SCRIVENER K, HOOTON R D. Supplementary cementitious materials[J]. Cement and Concrete Research, 2011, 41(12): 1244-1256.
[17] ZHANG X Z, LIU Z C, WANG F Z. Autogenous shrinkage behavior of ultra-high performance concrete[J]. Construction and Building Materials, 2019, 226: 459-468.
[18] RICHARDSON I G. The calcium silicate hydrates[J]. Cement and Concrete Research, 2008, 38(2): 137-158.
[19] RICHARDSON I G. Model structures for C-(A)-S-H (I)[J]. Acta Crystallographica Section B Structural Science, Crystal Engineering and Materials, 2014, 70(6): 903-923.
[20] LOTHENBACH B, MATSCHEI T, MÖSCHNER G, et al. Thermodynamic modelling of the effect of temperature on the hydration and porosity of Portland cement[J]. Cement and Concrete Research, 2008, 38(1): 1-18.
[21] KULIK D A. Improving the structural consistency of C-S-H solid solution thermodynamic models[J]. Cement and Concrete Research, 2011, 41(5): 477-495.
[22] 何真,王磊,邵一心,等.脱钙对水泥浆体中C-S-H凝胶结构的影响[J].建筑材料学报,2011,14(3):293-298.
HE Z, WANG L, SHAO Y X, et al. Effect of decalcification on C-S-H gel microstructure in cement paste[J]. Journal of Building Materials, 2011, 14(3): 293-298 (in Chinese).
[23] PELISSER F, GLEIZE P J P, MIKOWSKI A. Effect of the Ca/Si molar ratio on the micro/nanomechanical properties of synthetic C-S-H measured by nanoindentation[J]. The Journal of Physical Chemistry C, 2012, 116(32): 17219-17227.

利用煅烧硅藻土制备高稳态超高性能混凝土基体研究

Preparation of High Stability Ultra-High Performance Concrete Matrix with Calcined Diatomite

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	朱晓岗, 黄艳萍, 黄文浩, 卢佳妍, 刘毅. 光伏镀膜玻璃研究进展及发展趋势[J]. 硅酸盐通报, 2024, 43(4): 1211-1218.
[2]	卫志洋, 王晓东, 苏腾, 陈欢乐, 高峰, 苗洋. CaO-B₂O₃-SiO₂微晶玻璃的制备及介电性能[J]. 硅酸盐通报, 2024, 43(4): 1274-1283.
[3]	毛翔, 杨鼎宜, 曹忠露, 赵健, 陈龙祥, 王彤章. 基于图像法对自密实超高性能混凝土性能提升的研究[J]. 硅酸盐通报, 2024, 43(4): 1398-1409.
[4]	张全红, 王涛, 穆松, 蔡佳豪, 刘凯, 周莹, 刘光严. 不同侵蚀环境下喷射混凝土耐久性提升技术及作用机理[J]. 硅酸盐通报, 2024, 43(4): 1410-1419.
[5]	刘佳敏, 马玉薇, 李刚. 粉煤灰对渠道用混凝土抗冻及抗冲磨性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1436-1444.
[6]	吕亚军, 宋彩红, 党钧陶, 董宾宾, 乔敏, 张康捷, 马肖峰. 两种耐水处理长余辉材料制备发光混凝土的性能对比研究[J]. 硅酸盐通报, 2024, 43(3): 781-792.
[7]	刘富强, 马芹永. 纤维素-玄武岩混杂纤维喷射混凝土力学性能及能量演化[J]. 硅酸盐通报, 2024, 43(3): 806-815.
[8]	罗伊明, 张博, 刘彦钰, 吴守军, 付国. 混杂纤维增强超高性能混凝土的高温性能试验研究[J]. 硅酸盐通报, 2024, 43(3): 825-832.
[9]	郭子荣, 杨鼎宜, 曹忠露, 贾向锋, 赵健, 陈龙祥, 毛翔. 混掺纤维水泥砂浆的高温性能研究[J]. 硅酸盐通报, 2024, 43(3): 851-865.
[10]	陈士军, 龚木联, 刘溯逸, 花思旭, 金修伟, 王昊. 基于响应曲面法的三元地聚合物注浆材料耐久性能研究[J]. 硅酸盐通报, 2024, 43(3): 938-947.
[11]	尹鹏翔, 李静. 废玻璃粉对泡沫混凝土性能和微观孔结构的影响及其价值工程分析[J]. 硅酸盐通报, 2024, 43(3): 1021-1029.
[12]	丁正, 廖国胜, 廖宜顺, 何军林, 胡思达. 搅拌站废浆对水泥水化硬化的影响机理[J]. 硅酸盐通报, 2024, 43(3): 1039-1047.
[13]	祝毫华, 杨黎, 刘剑辉, 史才军. 杨木纤维对砂浆流动度、力学性能和自收缩的影响[J]. 硅酸盐通报, 2024, 43(2): 487-494.
[14]	郭威, 庞来学, 王文超, 张佳丽, 王华, 白书霞. 粉煤灰无溶剂法合成方钠石新方法及效果验证[J]. 硅酸盐通报, 2024, 43(2): 584-592.
[15]	汪伟, 赵田贵, 孟子豪, 刘溧, 董伟霞, 徐和良, 包启富. n(Bi₂O₃)/n(SiO₂)对Bi₂O₃-B₂O₃-SiO₂系光伏玻璃背板油墨微观结构和反射率的影响[J]. 硅酸盐通报, 2024, 43(2): 702-709.