UHPC浆体的工作性和流变性与颗粒膜层厚度的关系

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (3): 766-776.

UHPC浆体的工作性和流变性与颗粒膜层厚度的关系

黄静¹, 季文玉¹, 阎培渝²

1.北京交通大学土木建筑工程学院,北京 100044;
2.清华大学土木工程系,北京 100084

收稿日期:2021-08-22 修回日期:2021-11-27 出版日期:2022-03-15 发布日期:2022-04-08
通讯作者: 阎培渝,教授。E-mail:yanpy@tsinghua.edu.cn
作者简介:黄静(1997—),女,硕士研究生。主要从事超高性能混凝土方面的研究。E-mail:787005432@qq.com
基金资助:
国家自然科学基金(51878381)

Relationship of Workability and Rheological Properties of UHPC Slurry and Film Thickness of Particles

HUANG Jing¹, JI Wenyu¹, YAN Peiyu²

1. School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, China;
2. Department of Civil Engineering, Tsinghua University, Beijing 100084, China

Received:2021-08-22 Revised:2021-11-27 Online:2022-03-15 Published:2022-04-08

摘要/Abstract

摘要： 建立超高性能混凝土(UHPC)浆体的工作性和流变性之间的关系可从理论上研究其工作性变化规律。本文以颗粒膜层厚度为UHPC浆体的工作性的综合衡量指标,设计了正交试验,研究水胶比、超细粉煤灰替代率和硅灰掺量对UHPC浆体的工作性与流变性的影响。根据流动度和流变性测试结果,分析了水胶比和超细粉煤灰替代率的共同作用对UHPC浆体的工作性与流变性的影响,探究了UHPC的净浆与砂浆的工作性关系,基于浆膜层厚度给出了UHPC砂浆的工作性与流变性的关系式。研究结果表明:水胶比是UHPC浆体的工作性与流变性的最主要影响因素,水胶比、超细粉煤灰替代率和硅灰掺量提高均造成UHPC浆体的颗粒表面膜层厚度增大;水胶比和超细粉煤灰替代率的共同作用下,UHPC浆体的流动度和黏度系数具有相关性。

关键词: UHPC, 超细粉煤灰, 水膜层厚度, 浆膜层厚度, 工作性, 流变性, 水胶比

Abstract: The varying principle of workability of ultra-high performance concrete (UHPC) slurry can be theoretically studied with the relationship of its workability and rheological properties. An orthogonal test was designed to study the effects of water-binder ratio (W/B), substituted rate of cement by superfine fly ash and silica fume content on the workability and rheological properties of UHPC slurry. The film thickness on particles was taken as the index to evaluate workability and rheological properties of UHPC slurry. According to the test results of workability and rheological properties, the combined effect of W/B and substituted rate of cement by superfine fly ash on the workability and rheological properties of UHPC slurry were analyzed, and the relationship of workability between paste and mortar was investigated. Based on the film thickness on particles, the relationship between the workability and rheological properties of UHPC mortar was established. The results show that W/B is the most important factor, and as W/B, substituted rate of cement by superfine fly ash and silica fume content substituted increase, the film thickness on particles increases. Flow spread and consistency coefficient of UHPC slurry are correlated due to the combined effect of W/B and substituted rate of cement by superfine fly ash.

Key words: UHPC, superfine fly ash, water film thickness, paste film thickness, workability, rheological property, water-binder ratio

中图分类号:

TU528

黄静, 季文玉, 阎培渝. UHPC浆体的工作性和流变性与颗粒膜层厚度的关系[J]. 硅酸盐通报, 2022, 41(3): 766-776.

HUANG Jing, JI Wenyu, YAN Peiyu. Relationship of Workability and Rheological Properties of UHPC Slurry and Film Thickness of Particles[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(3): 766-776.

参考文献

[1] CHU S H. Effect of paste volume on fresh and hardened properties of concrete[J]. Construction and Building Materials, 2019, 218: 284-294.
[2] CHEN J J, GUAN G X, NG P L, et al. Packing optimization of paste and aggregate phases for sustainability and performance improvement of concrete[J]. Advanced Powder Technology, 2021, 32(4): 987-997.
[3] BARTOS P. Workability and rheology of fresh concrete: compendium of tests[M]. RILEM Publications, 2002.
[4] FERRARIS C F, DE LARRARD F. Testing and modelling of fresh concrete rheology[R]. National Institute of Standards and Technology, 1998.
[5] ROUSSEL N, STEFANI C, LEROY R. From mini-cone test to Abrams cone test: measurement of cement-based materials yield stress using slump tests[J]. Cement and Concrete Research, 2005, 35(5): 817-822.
[6] TREGGER N, FERRARA L. Identifying viscosity of cement paste from mini-slump-flow test[J]. ACI Materials Journal, 2008, 105(6): 558-566.
[7] 司雯,曹明莉,冯嘉琪.纤维增强水泥基复合材料的流动性与流变性研究进展[J].材料导报,2019,33(5):819-825.
SI W, CAO M L, FENG J Q. Advances in research on flowability and rheological properties of fiber reinforced cementitious composites[J]. Materials Reports, 2019, 33(5): 819-825 (in Chinese).
[8] LI L G, KWAN A K H. Concrete mix design based on water film thickness and paste film thickness[J]. Cement and Concrete Composites, 2013, 39: 33-42.
[9] KWAN A K H, LI L G. Combined effects of water film, paste film and mortar film thicknesses on fresh properties of concrete[J]. Construction and Building Materials, 2014, 50: 598-608.
[10] LI L G, KWAN A K H. Effects of superplasticizer type on packing density, water film thickness and flowability of cementitious paste[J]. Construction and Building Materials, 2015, 86: 113-119.
[11] LI L G, CHU S H, ZENG K L, et al. Roles of water film thickness and fibre factor in workability of polypropylene fibre reinforced mortar[J]. Cement and Concrete Composites, 2018, 93: 196-204.
[12] 国家质量监督检验检疫总局,中国国家标准化管理委员会.混凝土外加剂匀质性试验方法:GB/T 8077—2012[S].北京:中国标准出版社,2013.
General Administration of Quality Supervision, Inspection and Quarantine, Standardization Administration of China. Test method for uniformity of concrete admixture: GB/T 8077—2012[S]. Beijing: Standards Press of China, 2013 (in Chinese).
[13] 中华人民共和国国家质量监督检验总局,中国国家标准化管理委员会.水泥胶砂流动度测定方法:GB/T 2419—2005[S].北京:中国标准出版社,2005.
General Administration of Quality Supervision, Inspection and Inspection of the People's Republic of China, Standardization Administration of China. Determination method of fluidity of cement mortar: GB/T 2419—2005[S]. Beijing: Standards Press of China, 2005 (in Chinese).
[14] WONG H H C, KWAN A K H. Packing density of cementitious materials: part 1—measurement using a wet packing method[J]. Materials and Structures, 2008, 41(4): 689-701.
[15] LI M Y, HAN J G, ZHOU Y Q, et al. A rheological model for evaluating the behavior of shear thickening of highly flowable mortar[J]. Molecules (Basel, Switzerland), 2021, 26(4): 1011.
[16] 黄静,季文玉,阎培渝.新拌UHPC净浆的工作性与流变性试验研究[J].混凝土与水泥制品,2021[2021-11-27].https://kns.cnki.net/kcms/detail/32.1173.TU.20211109.0856.002.html.
HUANG J, JI W Y, YAN P Y. The relationship of workability and rheological properties of UHPC and the film thickness on particles[J]. China Concrete Cement Products, 2021[2021-11-27]. https://kns.cnki.net/kcms/detail/32.1173.TU.20211109.0856.002.html (in Chinese).