基于改进灰熵关联分析的混合型再生粗骨料评价指标及分级研究

摘要/Abstract

摘要： 灰熵关联分析中分辨系数的确定是制约分析结果的关键因素。本文首先推导出了分辨系数的计算公式,在此基础上,通过室内配制混合型再生粗骨料,结合粗骨料路用技术要求,重点探究了废弃砖块对混合型再生粗骨料物理性质的影响;采用室内无侧限抗压强度试验分析了混合型再生粗骨料对水泥稳定碎石力学性能的影响;运用灰熵分析理论对混合型再生粗骨料性能指标与无侧限抗压强度进行关联性分析;通过非线性数据拟合的方法结合交通荷载等级和公路等级,确定出混合型再生粗骨料在基层中的适用范围;并对混合型再生粗骨料进行分级。结果表明:分辨系数取值不固定,在本文中最大值可取为1.000,最小值可取为0.141;混合型再生粗骨料替代石灰岩集料不超过20%(质量分数),且砖块在混合型再生粗骨料中的比例与交通荷载等级相关,最大值不宜超过40%(质量分数);经灰熵关联分析可把吸水率和压碎值作为混合型再生粗骨料分级指标,并将混合型再生粗骨料在道路工程中的应用等级分为三类。

关键词: 道路工程, 灰熵分析理论, 混合型再生粗骨料, 非线性拟合, 分级标准, 分辨系数

Abstract: In grey entropy correlation analysis, the determination of resolution coefficient is the key factor that restricts the analysis result. In this paper, the formula of resolution coefficient was deduced firstly. On this basis, the mixed recycled coarse aggregate was prepared through indoor preparation, and the influence of waste brick on the physical properties of mixed recycled coarse aggregate was studied by the road technical requirements of coarse aggregate. The influence of mixed recycled coarse aggregate on the mechanical properties of cement stabilized macadam was analyzed by the unconfined compressive strength test, and the relationship between the performance index of mixed recycled coarse aggregate and the unconfined compressive strength was analyzed by the grey entropy analysis theory. Through the method of nonlinear data fitting combined with the traffic load grade and the highway grade, the applicable range and the classification of the mixed recycled coarse aggregate were determined in the road engineering base. The results show that the value of resolution coefficient is not fixed, which the maximum and minimum value is 1.000 and 0.141, respectively. The amount of mixture recycled coarse aggregate replacing limestone aggregate does not exceed 20% (mass fraction). Moreover, the proportion of bricks in the mixed recycled coarse aggregate is related to the traffic load grade, and its value could not exceed 40% (mass fraction). Through the grey entropy correlation analysis, the water absorption rate and crushing value are used as grade indexes of the mixed recycled coarse aggregate, of which the application grades are divided into three categories in road engineering.

Key words: road engineering, grey entropy analysis theory, mixed recycled coarse aggregate, nonlinear fitting, grading standard, identification coefficient

中图分类号:

U414

谢祥兵, 包梦, 李广慧, 史科, 李晗. 基于改进灰熵关联分析的混合型再生粗骨料评价指标及分级研究[J]. 硅酸盐通报, 2022, 41(1): 354-362.

XIE Xiangbing, BAO Meng, LI Guanghui, SHI Ke, LI Han. Evaluation Index and Classification of Mixed Recycled Coarse Aggregate Based on Improved Grey Entropy Correlation Analysis[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 354-362.

参考文献

[1] 李家豪.建筑废弃物再生集料路用性能研究[D].广州:广州大学,2016.
LI J H. Study on pavement performance of construction waste recycled aggregate[D]. Guangzhou: Guangzhou University, 2016 (in Chinese).
[2] 邓陈记,陈玉宏,陈华鑫,等.水泥稳定基层用再生粗骨料匀质性评价及控制技术研究[J].公路,2020,65(9):251-255.
DENG C J, CHEN Y H, CHEN H X, et al. Study on homogeneity evaluation and control technology of recycled coarse aggregate for cement stabilized base[J]. Highway, 2020, 65(9): 251-255 (in Chinese).
[3] 李福海,靳贺松,余泳江,等.再生混凝土粗骨料的质量分级优选评价[J].西南交通大学学报,2019,54(4):793-800+815.
LI F H, JIN H S, YU Y J, et al. Optimization evaluation of quality classification of concrete with recycled coarse aggregate[J]. Journal of Southwest Jiaotong University, 2019, 54(4): 793-800+815 (in Chinese).
[4] 鲍学英,王起才,张磊.基于灰色关联分析的再生混凝土粗骨料质量优选研究[J].硅酸盐通报,2014,33(4):741-745.
BAO X Y, WANG Q C, ZHANG L. Study on quality optimization of recycled concrete coarse aggregate based on grey relational analysis[J]. Bulletin of the Chinese Ceramic Society, 2014, 33(4): 741-745 (in Chinese).
[5] MA K L, HUANG X Y, SHEN J T, et al. The morphological characteristics of brick-concrete recycled coarse aggregate based on the digital image processing technique[J]. Journal of Building Engineering, 2021, 44: 103292.
[6] 闫洪生.纳米SiO₂强化再生粗骨料混凝土力学性能的试验研究[D].青岛:青岛理工大学,2018.
YAN H S. Experimental study on mechanical properties of recycled coarse aggregate concrete strengthened with nano SiO₂[D]. Qingdao: Qingdao Tehcnology University, 2018 (in Chinese).
[7] 龙初.纳米材料改性再生骨料混凝土破坏机理研究[D].长沙:湖南大学,2017.
LONG C. Research on failure mechanism of recycled aggregate concrete modified by nano materials[D]. Changsha: Hunan University, 2017 (in Chinese).
[8] 肖建庄,雷斌,袁飚.废混凝土再生粗集料性能试验与分级标准研究[J].四川大学学报(工程科学版),2009,41(s1):23-28.
XIAO J Z, LEI B, YUAN B. On the properties and classification standard of recycled coarse aggregate derived from waste concrete[J]. Journal of Sichuan University (Engineering Science Edition), 2009, 41(s1): 23-28 (in Chinese).
[9] 徐开东,王继娜,李志新,等.砖混建筑垃圾再生骨料应用技术指标系统化研究[J].硅酸盐通报,2020,39(9):2905-2911.
XU K D, WANG J N, LI Z X, et al. Systematized study on application technology indicators of recycled aggregate reproduced by masonry construction waste[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(9): 2905-2911 (in Chinese).
[10] 肖杰,吴超凡,湛哲宏,等.水泥稳定砖与混凝土再生集料基层的性能研究[J].中国公路学报,2017,30(2):25-32.
XIAO J, WU C F, ZHAN Z H, et al. Research on performances of cement stabilized brick and concrete recycled aggregate base[J]. China Journal of Highway and Transport, 2017, 30(2): 25-32 (in Chinese).
[11] 元成方,李爽,曾力,等.混合再生骨料材料性能试验研究[J].混凝土,2018(3):98-100.
YUAN C F, LI S, ZENG L, et al. Experimental study on material properties of mixed recycled aggregate[J]. Concrete, 2018(3): 98-100 (in Chinese).
[12] 张明明,王社良,张世民,等.砖替率对再生粗骨料的性能影响试验研究[J].混凝土,2017(11):91-93+99.
ZHANG M M, WANG S L, ZHANG S M, et al. Brick for rate of experimental study on the influence on the performance of recycled coarse aggregate[J]. Concrete, 2017(11): 91-93+99 (in Chinese).
[13] 张献蒙,刘旭,柏彬,等.利用砖混建筑废弃物制备再生混凝土的性能研究[J].硅酸盐通报,2021,40(8):2680-2686.
ZHANG X M, LIU X, BAI B, et al. Research on properties of recycled concrete prepared with brick and concrete construction waste[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(8): 2680-2686 (in Chinese).
[14] 刘超,余伟航,刘化威,等.再生砖骨料混凝土力学性能及破坏机理研究[J].材料导报,2021,35(13):13025-13031.
LIU C, YU W H, LIU H W, et al. Study on mechanical properties and failure mechanism of recycled brick aggregate concrete[J]. Materials Reports, 2021, 35(13): 13025-13031 (in Chinese).
[15] 蔡旭,肖天佑,吴旷怀.混凝土再生集料水泥稳定碎石强度及影响因素研究[J].中国科技论文,2018,13(1):56-59.
CAI X, XIAO T Y, WU K H. Study on strength and influencing factors of cement stabilized macadam with recycled concrete aggregates[J]. China Sciencepaper, 2018, 13(1): 56-59 (in Chinese).
[16] 吴超凡,肖杰,田振,等.水泥稳定再生砖砼集料基层性能及路面结构受力分析[J].硅酸盐通报,2017,36(s1):158-164.
WU C F, XIAO J, TIAN Z, et al. Mechanical properties and pavement structure of cement stabilized recycled brick and concrete aggregate base[J]. Bulletin of the Chinese Ceramic Society, 2017, 36(s1): 158-164 (in Chinese).
[17] 邹桂莲,刘新海,周浩浩.水泥粉煤灰稳定再生集料的路用性能研究[J].中外公路,2018,38(3):254-258.
ZOU G L, LIU X H, ZHOU H H. Research on the road performance of cement-fly ash stabilized recycled aggregates[J]. Journal of China & Foreign Highway, 2018, 38(3): 254-258 (in Chinese).
[18] 刘思峰,郭天榜,党耀国.灰色系统理论及其应用[M].第2版.北京:科学出版社,1999.
LIU S F, GUO T B, DANG Y G. Grey system theory and its application[M]. 2nd ed. Beijing: Science Press, 1999 (in Chinese).
[19] 谢祥兵.基于胶浆特性的紫外光老化下沥青混合料路用性能及细观力学分析[D].西安:西安建筑科技大学,2017.
XIE X B. Analysis on micromechanical and road performance of asphalt mixture after UV-aging based on mortar character[D]. Xi'an: Xi'an University of Architecture and Technology, 2017 (in Chinese).
[20] 东亚斌,段志善.灰色关联度分辨系数的一种新的确定方法[J].西安建筑科技大学学报(自然科学版),2008,40(4):589-592.
DONG Y B, DUAN Z S. A new determination method for identification coefficient of grey relational grade[J]. Journal of Xi'an University of Architecture & Technology (Natural Science Edition), 2008, 40(4): 589-592 (in Chinese).
[21] 钱隼驰,仇蕾.灰色关联分析中分辨系数取值的定量研究[J].统计与决策,2019,35(10):10-14.
QIAN S C, QIU L. Quantitative study on value of distinguishing coefficient in grey correlation analysis[J]. Statistics & Decision, 2019, 35(10): 10-14 (in Chinese).