掺花岗岩石粉的管桩高强混凝土微结构和力学性能研究

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (1): 109-117.

所属专题：水泥混凝土

掺花岗岩石粉的管桩高强混凝土微结构和力学性能研究

黄晓燕

福州市交通建设集团有限公司,福州 350002

收稿日期:2021-09-09 修订日期:2021-11-24 出版日期:2022-01-15 发布日期:2022-02-10
作者简介:黄晓燕(1982—),女,高工。主要从事道路工程结构、材料的研究。E-mail:64046585@qq.com
基金资助:
福建省交通运输科技项目(202112);闽北山地地质灾害防治福建省高校工程研究中心(WYERC2020-4)

Microstructure and Mechanical Properties of Pile High-Strength Concrete Incorporating Granite Powder

HUANG Xiaoyan

Fuzhou Traffic Construction Group Co. Ltd., Fuzhou 350002, China

Received:2021-09-09 Revised:2021-11-24 Online:2022-01-15 Published:2022-02-10

摘要/Abstract

摘要： 本文采用蒸压养护方式制备管桩高强混凝土,以相同配合比的标准养护混凝土为对比组,分别研究磨细砂和石粉双掺时石粉取代率(花岗岩石粉/(花岗岩石粉+磨细砂),质量比)和石粉单掺时石粉掺量(花岗岩石粉/(花岗岩石粉+水泥),质量比)对管桩高强混凝土强度的影响,并通过XRD、ESEM等方法研究掺花岗岩石粉的管桩高强混凝土水化产物的种类及形貌特征。结果表明:蒸压养护下,混凝土强度随石粉取代率和石粉掺量的增加均先增大后减小, 石粉取代率为25%和石粉掺量为20%时混凝土强度分别达到最大值。由于花岗岩石粉中的SiO₂在蒸压条件下会与水泥水化产物Ca(OH)₂发生火山灰反应并生成托勃莫来石,使混凝土更为密实,因此相同配合比条件下蒸压养护3 d的混凝土强度高于标准养护28 d的混凝土强度。

关键词: 蒸压养护, 花岗岩石粉, 管桩高强混凝土, 力学性能, 微观结构

Abstract: This paper intended to prepare high-strength pipe concrete using autoclaved curing, while the concrete with standard curing was used as control sample. The influences of the stone powder replacement rate (granite stone powder/(granite stone powder+ground) sand, by mass), and the stone powder content (granite stone powder/(granite stone powder+cement), by mass) without adding ground sand on the strength of the pipe high-strength concrete were conducted, respectively. The types and morphological characteristics of hydration products of pipe high-strength concrete with granite powder were investigated by XRD and ESEM. The results show that under autoclaved curing, the concrete strength increases first, and then decreases with the increase of stone powder replacement rate and stone powder content. The strengths of the concretes are highest when the stone powder replacement rate is 25% and the stone powder content is 20%, respectively. The SiO₂ in the granite powder has a pozzolanic reaction with Ca(OH)₂ (cement hydration product) and produce tobermorite under autoclaved condition, and consequently the concrete become more compact. Therefore, the strength of concrete under autoclave curing at 3 d is higher than that of the concrete under standard curing at 28 d in the same mix ratio.

Key words: autoclave curing, granite powder, pile high-strength concrete, mechanical property, microstructure

中图分类号:

TU521

黄晓燕. 掺花岗岩石粉的管桩高强混凝土微结构和力学性能研究[J]. 硅酸盐通报, 2022, 41(1): 109-117.

HUANG Xiaoyan. Microstructure and Mechanical Properties of Pile High-Strength Concrete Incorporating Granite Powder[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(1): 109-117.

参考文献

[1] 陈克伟.先张法预应力混凝土竹节管桩抗弯性能试验研究[J].混凝土与水泥制品,2021(7):33-37.
CHEN K W. Flexural performance experiment of pretensioned spun nodular concrete piles[J]. China Concrete and Cement Products, 2021(7): 33-37 (in Chinese).
[2] 王湛德,杨全兵,黄士元,等.在蒸压预应力高强混凝土配料中掺加磨细砂的研究[M].中国混凝土与水泥制品协会2012年会论文集,2012:143-145.
WANG Z D, YANG Q B, HUANG S Y, et al. Research on adding ground fine sand in autoclaved prestressed high strength concrete ingredients[M]. China Association of Concrete and Cement Products Conference Papers, 2012: 143-145 (in Chinese).
[3] RUCIŃSKA T, GĿOWACKA A, SIDEĿKO R. The influence of incinerated sewage sludge as an aggregate on the selected properties of cement mortars[J]. Materials, 2021, 14(19): 5846.
[4] SRINATH D, REDDY SUDA V B. Performance of binary steel fibre concrete consisting of copper slag as partial replacement to fine aggregate[J]. IOP Conference Series: Materials Science and Engineering, 2021, 1185(1): 012018.
[5] PROKOPSKI G, MARCHUK V, HUTS A. The effect of using granite dust as a component of concrete mixture[J]. Case Studies in Construction Materials, 2020, 13: e00349.
[6] GHANNAM S, NAJM H, VASCONEZ R. Experimental study of concrete made with granite and iron powders as partial replacement of sand[J]. Sustainable Materials and Technologies, 2016, 9: 1-9.
[7] DONG G G, LIU F S, REN S X, et al. The influence of granite powder on mechanics properties of cement mortar[J]. Advanced Materials Research, 2012, 580: 521-527.
[8] MATOS A M, RAMOS T, SOUSA-COUTINHO J. Strength, ASR and chloride penetration of mortar with granite waste powder[J]. Key Engineering Materials, 2014, 634: 139-150.
[9] SAVADKOOHI M S, REISI M. Environmental protection based sustainable development by utilization of granite waste in reactive powder concrete[J]. Journal of Cleaner Production, 2020, 266: 121973.
[10] ZHANG H R, JI T, LIN X Y. Pullout behavior of steel fibers with different shapes from ultra-high performance concrete (UHPC) prepared with granite powder under different curing conditions[J]. Construction and Building Materials, 2019, 211: 688-702.
[11] 中华人民共和国住房和城乡建设部.混凝土物理力学性能试验方法标准:GB/T 50081—2019[S].北京:中国标准出版社,2019.
Ministry of Housing and Urban-Rural Development of the People's Republic of China. Standard test methods for physical and mechanical properties of concrete: GB/T 50081—2019[S]. Beijing: Standards Press of China, 2019 (in Chinese).
[12] YAZICI H, YIĞITER H, KARABULUT A Ş, et al. Utilization of fly ash and ground granulated blast furnace slag as an alternative silica source in reactive powder concrete[J]. Fuel, 2008, 87(12): 2401-2407.
[13] 刘春,陶元洪,何涛,等.花岗岩石粉掺量对混凝土力学性能的影响[J].建材世界,2020,41(3):18-21+38.
LIU C, TAO Y H, HE T, et al. Influence of added amount of granite stone powder on mechanical properties of concrete[J]. The World of Building Materials, 2020, 41(3): 18-21+38 (in Chinese).
[14] YANG Q B, ZHANG S Q, HUANG S Y, et al. Effect of ground quartz sand on properties of high-strength concrete in the steam-autoclaved curing[J]. Cement and Concrete Research, 2000, 30(12): 1993-1998.
[15] 陈聪,柯国军,谭天戈,等.蒸压养护对废玻璃粉复合砂浆力学性能的改善[J].中国粉体技术,2020,26(4):46-51.
CHEN C, KE G J, TAN T G, et al. Improvement of mechanical properties of waste glass powder composite mortar by autoclave curing[J]. China Powder Science and Technology, 2020, 26(4): 46-51 (in Chinese).
[16] 耿春东,丁庆军,刘勇强,等.压蒸条件下花岗岩石粉对UHPC性能的影响[J].硅酸盐通报,2018,37(2):533-540.
GENG C D, DING Q J, LIU Y Q, et al. Effects of granite powder on the performance of ultra high performance concrete under autoclaved condition[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(2): 533-540 (in Chinese).

掺花岗岩石粉的管桩高强混凝土微结构和力学性能研究

Microstructure and Mechanical Properties of Pile High-Strength Concrete Incorporating Granite Powder

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	朱晓岗, 黄艳萍, 黄文浩, 卢佳妍, 刘毅. 光伏镀膜玻璃研究进展及发展趋势[J]. 硅酸盐通报, 2024, 43(4): 1211-1218.
[2]	尚楷浡, 李铭涵, 李军葛, 马艳平, 姜宏, 赵亚军, 张吉亮, 董闯. 基于团簇加连接原子模型的一种工业微晶玻璃成分优化初探[J]. 硅酸盐通报, 2024, 43(4): 1257-1266.
[3]	卫志洋, 王晓东, 苏腾, 陈欢乐, 高峰, 苗洋. CaO-B₂O₃-SiO₂微晶玻璃的制备及介电性能[J]. 硅酸盐通报, 2024, 43(4): 1274-1283.
[4]	刘佳敏, 马玉薇, 李刚. 粉煤灰对渠道用混凝土抗冻及抗冲磨性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1436-1444.
[5]	张兆锐, 单俊鸿, 王荣荣, 李春, 史圣然. 磷建筑石膏基无砂自流平砂浆的制备与性能研究[J]. 硅酸盐通报, 2024, 43(4): 1455-1462.
[6]	王本仁, 张刘阳, 刘西峰, 段旭林, 陈潇. 水泥钢渣稳定土的路用性能研究与工程应用[J]. 硅酸盐通报, 2024, 43(4): 1472-1481.
[7]	杨家瑞, 杜景红, 黄涛, 孟雪, 陈家兴, 秦朝乾, 何胜阳. 氧化钪对钾长石结晶釉组织结构和性能的影响[J]. 硅酸盐通报, 2024, 43(4): 1506-1514.
[8]	吕亚军, 宋彩红, 党钧陶, 董宾宾, 乔敏, 张康捷, 马肖峰. 两种耐水处理长余辉材料制备发光混凝土的性能对比研究[J]. 硅酸盐通报, 2024, 43(3): 781-792.
[9]	李兆睿, 王振军, 张海宝, 张亚明, 张松林, 张博伦. 三乙醇胺和硬脂酸锌对泡沫混凝土性能的影响[J]. 硅酸盐通报, 2024, 43(3): 793-805.
[10]	刘富强, 马芹永. 纤维素-玄武岩混杂纤维喷射混凝土力学性能及能量演化[J]. 硅酸盐通报, 2024, 43(3): 806-815.
[11]	罗伊明, 张博, 刘彦钰, 吴守军, 付国. 混杂纤维增强超高性能混凝土的高温性能试验研究[J]. 硅酸盐通报, 2024, 43(3): 825-832.
[12]	郭子荣, 杨鼎宜, 曹忠露, 贾向锋, 赵健, 陈龙祥, 毛翔. 混掺纤维水泥砂浆的高温性能研究[J]. 硅酸盐通报, 2024, 43(3): 851-865.
[13]	张路曼, 侯风. 相变调温墙板热工性能试验和数值模拟研究[J]. 硅酸盐通报, 2024, 43(3): 866-877.
[14]	冷玲倻, 张鹏飞, 梁文文. 高温下玄武岩纤维增强地质聚合物混凝土的动态压缩力学行为[J]. 硅酸盐通报, 2024, 43(3): 914-921.
[15]	薛文浩, 蹇守卫, 李宝栋, 黄健翔, 谭洪波, 马逍遥, 汪才峰. 不同生物质炉渣对蒸压加气混凝土浆料性能与力学性能的影响[J]. 硅酸盐通报, 2024, 43(3): 987-994.