季冻区粉煤灰加固路基土力学性能试验研究

摘要/Abstract

摘要： 为探究冻融循环作用对粉煤灰加固路基土力学性能影响,对冻融循环次数、含水率、粉煤灰掺量不同的盐渍土开展无侧限抗压试验和三轴剪切试验,研究冻融循环后土体的应力-应变曲线、无侧限抗压强度、黏聚力和内摩擦角的变化情况。使用Design-Expert 8.0软件,研究冻融循环次数、粉煤灰掺量、含水率及各因素交互作用对盐渍土力学性质影响的显著性程度。结果表明:多次冻融循环后,盐渍土无侧限抗压强度、黏聚力和内摩擦角均有下降,经历1~7次冻融循环时,土体各力学参数下降速率较快;随着粉煤灰掺量的增加,盐渍土的内摩擦角、黏聚力、无侧限抗压强度和抗剪强度呈现出先升高后下降的变化趋势。基于显著性分析理论,冻融循环次数与含水率的交互作用对盐渍土无侧限抗压强度和黏聚力的影响较为显著,粉煤灰掺量与冻融循环次数的交互作用仅对无侧限抗压强度影响较为显著。为提高路基土强度及抗冻融的能力,加快粉煤灰综合利用进度,根据软件和公式模拟结果,推荐在路基土中依据质量比掺加15%粉煤灰,并将经历7次冻融循环后压实盐渍土的力学指标作为工程设计参考值。

关键词: 路基土, 粉煤灰, 粉煤灰加固路基土, 季冻地区, 盐渍土, 冻融循环, 力学性能

Abstract: In order to investigate the influence of freeze-thaw cycle on the mechanical properties of subgrade soil reinforced with fly ash, unconfined compression test and triaxial shear test were carried out on saline soil with different freeze-thaw cycle times, moisture content and fly ash content. What's more, the changes of stress-strain curve, unconfined compressive strength, cohesion and internal friction angle of soil after freeze-thaw cycle were studied. Based on Design-Expert 8.0 software, the influence of freeze-thaw cycle times, fly ash content, moisture content and the interaction of various factors on the mechanical properties of saline soil was explored. The results show that the unconfined compressive strength, cohesion and internal friction angle of saline soil decrease after several freeze-thaw cycles, and the mechanical parameters of soil decrease rapidly after 1 to 7 freeze-thaw cycles. With the increase of fly ash content, the internal friction angle, cohesion, unconfined compressive strength and shear strength of saline soil increase at first and then decrease. Based on the theory of significance analysis, the interaction between freeze-thaw cycles and moisture content has a significant effect on the unconfined compressive strength and cohesion of saline soil. The interaction between fly ash content and freeze-thaw cycles only has obvious significance on unconfined compressive strength. In order to improve the strength and frost-thaw resistance of subgrade soil and speed up the comprehensive utilization of fly ash, it is recommended to add 15% fly ash to subgrade soil according to the mass ratio. The mechanical index of compacted saline soil after seven freeze-thaw cycles is taken as the reference value of engineering design.

Key words: subgrade soil, fly ash, fly ash reinforcing subgrade soil, seasonal freezing area, saline soil, freeze-thaw cycle, mechanical property

中图分类号:

TU43

程卓, 崔高航, 高原昊, 刚浩航, 高泽宁, 杨政, 张鑫. 季冻区粉煤灰加固路基土力学性能试验研究[J]. 硅酸盐通报, 2021, 40(11): 3854-3864.

CHENG Zhuo, CUI Gaohang, GAO Yuanhao, GANG Haohang, GAO Zening, YANG Zheng, ZHANG Xin. Mechanical Properties of Fly Ash Reinforced Subgrade Soil in Seasonally Frozen Area[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(11): 3854-3864.

参考文献

[1] 程卓,崔高航,高泽宁,等.冻融循环对粉煤灰改良盐渍土抗剪特性影响研究[J/OL].中外公路:1-12[2021-04-04].http://kns.cnki.net/kcms/detail/43.1363.U.20210318.1945.008.html.
CHENG Z, CUI G H, GAO Z N, et al. Effect of freeze-thaw cycles on shear properties of fly ash modified saline soil[J/OL]. Journal of China & Foreign Highway: 1-12 [2021-04-04]. http://kns.cnki.net/kcms/detail/43.1363.U.20210318.1945.008.html (in Chinese).
[2] 杨晓华,张莎莎,刘伟,等.粗颗粒盐渍土工程特性研究进展[J].交通运输工程学报,2020,20(5):22-40.
YANG X H, ZHANG S S, LIU W, et al. Research progress on engineering properties of coarse-grained saline soil[J]. Journal of Traffic and Transportation Engineering, 2020, 20(5): 22-40 (in Chinese).
[3] 许健,张明辉,李彦锋,等.Na₂SO₄盐渍原状黄土冻融过程劣化特性试验研究[J].岩土工程学报,2020,42(9):1642-1650.
XU J, ZHANG M H, LI Y F, et al. Experimental study on deterioration behavior of saline undisturbed loess with sodium sulphate under freeze-thaw action[J]. Chinese Journal of Geotechnical Engineering, 2020, 42(9): 1642-1650 (in Chinese).
[4] 宫滢,王正君,赵安平.压实度对苏打型盐渍土冻融特性影响研究[J].森林工程,2020,36(5):112-118.
GONG Y, WANG Z J, ZHAO A P. Influence of compaction degree on freezing-thawing characteristics of soda saline soil[J]. Forest Engineering, 2020, 36(5): 112-118 (in Chinese).
[5] 行文静,牛浩,李娇,等.冻融对东北黑土硒酸盐吸附解吸的影响[J].土壤通报,2021,52(2):338-345.
XING W J, NIU H, LI J, et al. Effects of initial water content and freeze-thawing cycles on adsorption and desorption of selenate in black soil of Northeast China[J]. Chinese Journal of Soil Science, 2021, 52(2): 338-345 (in Chinese).
[6] LOLI M, TSATSIS A, KOURKOULIS R, et al. A simplified numerical method to simulate the thawing of frozen soil[J]. Proceedings of the Institution of Civil Engineers-Geotechnical Engineering, 2020, 173(5): 408-427.
[7] ZHANG X D, WANG Q, YU T W, et al. Numerical study on the multifield mathematical coupled model of hydraulic-thermal-salt-mechanical in saturated freezing saline soil[J]. International Journal of Geomechanics, 2018, 18(7): 04018064.
[8] WANG D Y, LIU J K, LI X. Numerical simulation of coupled water and salt transfer in soil and a case study of the expansion of subgrade composed by saline soil[J]. Procedia Engineering, 2016, 143: 315-322.
[9] KONRAD J M. Physical processes during freeze-thaw cycles in clayey silts[J]. Cold Regions Science and Technology, 1989, 16(3): 291-303.
[10] ZHANG W B, MA J Z, TANG L. Experimental study on shear strength characteristics of sulfate saline soil in Ningxia region under long-term freeze-thaw cycles[J]. Cold Regions Science and Technology, 2019, 160: 48-57.
[11] XU J, LI Y F, LAN W, et al. Shear strength and damage mechanism of saline intact loess after freeze-thaw cycling[J]. Cold Regions Science and Technology, 2019, 164: 102779.
[12] WANG J Q, WANG Q, LIN S, et al. Relationship between the shear strength and microscopic pore parameters of saline soil with different freeze-thaw cycles and salinities[J]. Symmetry, 2020, 12(10): 1709.
[13] 吕翔.季冻区路基土宏观力学行为与微观结构特征关系研究[D].长春:吉林建筑大学,2018.
LV X. Research on the relationship of subgrade soil macroscopic mechanical behavior and microstructural characteristics in seasonally frozen soil region[D].Changchun: Jilin Jianzhu University, 2018 (in Chinese).
[14] 陈诚,郭伟,任宇晓.冻融循环条件下木质素纤维改良土性质研究及微观分析[J].岩土工程学报,2020,42(s2):135-140.
CHEN C, GUO W, REN Y X. Properties and microscopic analysis of lignin fiber-reinforced soils under freeze-thaw cycles[J]. Chinese Journal of Geotechnical Engineering, 2020, 42(s2): 135-140 (in Chinese).
[15] ZHANG S S, YANG X H, XIE S J, et al. Experimental study on improving the engineering properties of coarse grain sulphate saline soils with inorganic materials[J]. Cold Regions Science and Technology, 2020, 170: 102909.
[16] KAMEI T, AHMED A, DE SHIBI T. Effect of freeze-thaw cycles on durability and strength of very soft clay soil stabilised with recycled bassanite[J]. Cold Regions Science and Technology, 2012, 82: 124-129.
[17] LV Q, JIANG L S, MA B, et al. A study on the effect of the salt content on the solidification of sulfate saline soil solidified with an alkali-activated geopolymer[J]. Construction and Building Materials, 2018, 176: 68-74.
[18] BIN-SHAFIQUE S, RAHMAN K, YAYKIRAN M, et al. The long-term performance of two fly ash stabilized fine-grained soil subbases[J]. Resources, Conservation and Recycling, 2010, 54(10): 666-672.
[19] 中华人民共和国建设部.岩土工程勘察规范:GB 50021—2001[S].北京:中国建筑工业出版社,2004.
Ministry of Construction, PRC. Code for geotechnical engineering investigation: GB 50021—2001[S]. Beijing: China Architecture and Building Press, 2004 (in Chinese).
[20] MÄKELÄ M. Experimental design and response surface methodology in energy applications: a tutorial review[J]. Energy Conversion and Management, 2017, 151: 630-640.
[21] ZHAO H Y, ZHANG Y, GAO X Q. Analysis of the engineering characteristics of solidified saline soil based on the microstructure index using response surface methodology[P]. International Conference on Applied Mechanics and Mechanical Automation (AMMA 2017), 2017.
[22] 中华人民共和国交通运输部.公路土工试验规程:JTG 3430—2020[S].北京:人民交通出版社,2020.
Ministry of Transport, PRC. Highway geotechnical test specification: JTG 3430—2020[S]. Beijing: People's Communications Press, 2020 (in Chinese).
[23] FERREIRA F B, VIEIRA C S, LOPES M L. Direct shear behaviour of residual soil-geosynthetic interfaces-influence of soil moisture content, soil density and geosynthetic type[J]. Geosynthetics International, 2015, 22(3): 257-272.
[24] WEI J, SHI B L, LI J L, et al. Shear strength of purple soil bunds under different soil water contents and dry densities: a case study in the Three Gorges Reservoir Area, China[J]. CATENA, 2018, 166: 124-133.
[25] KHURI A I, MUKHOPADHYAY S. Response surface methodology[J]. Wiley Interdisciplinary Reviews: Computational Statistics, 2010, 2(2): 128-149.
[26] SARKAR A, RANO R, MISHRA K K, et al. Particle size distribution profile of some Indian fly ash: a comparative study to assess their possible uses[J]. Fuel Processing Technology, 2005, 86(11): 1221-1238.
[27] CHENG Z, CUI G H, YANG Z, et al. Improvement of the salinized soil properties of fly ash by freeze-thaw cycles: an impact test study[J]. Sustainability, 2021, 13(5): 2908.
[28] AHMARUZZAMAN M. A review on the utilization of fly ash[J]. Progress in Energy and Combustion Science, 2010, 36(3): 327-363.
[29] 陈洁.粉煤灰改良硫酸盐渍土工程特性的试验研究[D].银川:宁夏大学,2015.
CHEN J. Experimental research on the engineering property of sulphate saline soil improved by fly ash[D]. Yinchuan: Ningxia University, 2015 (in Chinese).
[30] XIE S B, QU J J, LAI Y M, et al. Effects of freeze-thaw cycles on soil mechanical and physical properties in the Qinghai-Tibet Plateau[J]. Journal of Mountain Science, 2015, 12(4): 999-1009.
[31] CHEN H E, ZHANG J, YAN H. Quantitative evaluation of microstructure characteristics of cement consolidated soil[J]. Bulletin of Engineering Geology and the Environment, 2013, 72(2): 233-236.
[32] WANG S H, DING J L, XU J, et al. Shear strength behavior of coarse-grained saline soils after freeze-thaw[J]. KSCE Journal of Civil Engineering, 2019, 23(6): 2437-2452.