铝酸钙准二元玻璃硬度和抗碎裂性组成依赖的结构起源探究

硅酸盐通报 ›› 2021, Vol. 40 ›› Issue (10): 3504-3510.

铝酸钙准二元玻璃硬度和抗碎裂性组成依赖的结构起源探究

王琰¹, 高运周², 陶海征¹, 顾少轩¹

1.武汉理工大学,硅酸盐建筑材料国家重点实验室,武汉 430070;
2.四川神光石英科技有限公司,绵阳 621700

收稿日期:2021-04-23 修回日期:2021-05-08 出版日期:2021-10-15 发布日期:2021-11-11
通讯作者: 顾少轩,博士,教授。E-mail:gsx@whut.edu.cn
作者简介:王琰(1996—),男,硕士研究生。主要从事氧化物玻璃方面的研究。E-mail:wangyan9936@126.com

Structural Origin Revealing of Dependence of Hardness and Crack Resistance on Composition in CaO-Al₂O₃ Pseudo-Binary Glass System

WANG Yan¹, GAO Yunzhou², TAO Haizheng¹, GU Shaoxuan¹

1. State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070, China;
2. Sichuan Shenguang Quartz Science and Technology Co., Ltd., Mianyang 621700, China

Received:2021-04-23 Revised:2021-05-08 Online:2021-10-15 Published:2021-11-11

摘要/Abstract

摘要： 理解玻璃的硬度和抗碎裂性与结构的关系对制备高硬耐摔功能玻璃具有重要的理论指导意义。为探究铝酸钙(CaO-Al₂O₃)准二元玻璃硬度和抗碎裂性随CaO含量的变化规律,采用激光加热气动悬浮方法,制备了组分为xCaO·(100-x)Al₂O₃(x=42.3、50.0、63.1、75.0,摩尔分数)的系列玻璃样品。利用显微维氏硬度仪、激光共聚焦显微拉曼光谱仪、X-射线衍射仪和魔角旋转固体核磁共振波谱仪,对制备的铝酸钙准二元玻璃的硬度、抗碎裂性和结构进行了详细的表征。结果表明:随着CaO含量增加,玻璃硬度逐渐下降,于x=42.3时硬度最大(8.09 GPa);而玻璃的抗碎裂性随CaO含量增加先降低后急剧增加,并于x=42.3时表现出最大的抗碎裂性(11.8 N)。随着CaO含量增加,平均键能的下降是玻璃硬度下降的原因;高铝含量(x=42.3)的铝酸钙玻璃中部分铝以五配位形式存在,在承受载荷冲击过程中容易改变配位数来耗散能量,是抗碎裂性最大的结构根源。

关键词: 铝酸钙玻璃, 气动悬浮方法, 激光加热, 硬度, 抗碎裂性, 配位环境

Abstract: Understanding the relationship between structure and performances such as hardness and crack resistance has guiding significance for the development of the hard and highly crack resistant glass. To study the structural dependence of hardness and crack resistance on composition in the CaO-Al₂O₃ pseudo-binary glass system, utilizing the laser-heated aerodynamic levitation method, a series of xCaO·(100-x)Al₂O₃ glasses were prepared with x=42.3, 50.0, 63.1, and 75.0, mole fraction. The Vickers hardness (H_V) and crack resistance (C_R) were studied by using a micro-hardness Vicker tester. The structure of these glasses was characterized by Raman spectra, X-ray diffraction (XRD) patterns and magic angle spinning nuclear magnetic resonance (MAS-NMR). The results indicate that with the increase of the CaO content, the H_V values of these glasses decrease whereas the C_R values show a non-linear and non-exponential change. The 42.3CaO·57.7Al₂O₃ glass exhibits the maximum values of H_V (8.09 GPa) and C_R (11.8 N). The decrease of H_V values upon the addition of CaO is attributed to the decrease of average bond energy. The maximum C_R value of the 42.3CaO·57.7Al₂O₃ glass is ascribed to the existence of five coordinated Al, which dissipates the energy in the indentation process through changing the coordination number.

Key words: calcium aluminum glass, aerodynamic levitation method, laser heating, hardness, crack resistance, coordination environment

中图分类号:

TQ171

王琰, 高运周, 陶海征, 顾少轩. 铝酸钙准二元玻璃硬度和抗碎裂性组成依赖的结构起源探究[J]. 硅酸盐通报, 2021, 40(10): 3504-3510.

WANG Yan, GAO Yunzhou, TAO Haizheng, GU Shaoxuan. Structural Origin Revealing of Dependence of Hardness and Crack Resistance on Composition in CaO-Al₂O₃ Pseudo-Binary Glass System[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(10): 3504-3510.

参考文献

[1] HAFNER H C, KREIDL N J, WEIDEL R A. Optical and physical properties of some calcium aluminate glasses[J]. Journal of the American Ceramic Society, 1958, 41(8): 315-323.
[2] KALAMPOUNIAS A G, NASIKAS N K, PONTIKES Y, et al. Thermal properties of calcium aluminate xCaO·(1-x)Al₂O₃ glasses[J]. Physics and Chemistry of Glasses-European Journal of Glass Science and Technology Part B, 2012, 53(5): 205-209.
[3] LIN Y N, SMEDSKJAER M M, MAURO J C. Structure, properties, and fabrication of calcium aluminate-based glasses[J]. International Journal of Applied Glass Science, 2019, 10(4): 488-501.
[4] LANGSTAFF D, GUNN M, GREAVES G N, et al. Aerodynamic levitator furnace for measuring thermophysical properties of refractory liquids[J]. Review of Scientific Instruments, 2013, 84(12): 124901.
[5] LIU H, CHEN W L, PAN R K, et al. From molten calcium aluminates through phase transitions to cement phases[J]. Advanced Science, 2020, 7(2): 1902209.
[6] JANUCHTA K, YOUNGMAN R E, GOEL A, et al. Discovery of ultra-crack-resistant oxide glasses with adaptive networks[J]. Chemistry of Materials, 2017, 29(14): 5865-5876.
[7] KE X F, SHAN Z T, LI Z H, et al. Toward hard and highly crack resistant magnesium aluminosilicate glasses and transparent glass-ceramics[J]. Journal of the American Ceramic Society, 2020, 103(6): 3600-3609.
[8] KATO Y, YAMAZAKI H, KUBO Y, et al. Effect of B₂O₃ content on crack initiation under Vickers indentation test[J]. Journal of the Ceramic Society of Japan, 2010, 118(1381): 792-798.
[9] QUINN G D, GREEN P, XU K. Cracking and the indentation size effect for knoop hardness of glasses[J]. Journal of the American Ceramic Society, 2003, 86(3): 441-448.
[10] CHENG Y T, CHENG C M. Scaling, dimensional analysis, and indentation measurements[J]. Materials Science and Engineering: R: Reports, 2004, 44(4/5): 91-149.
[11] SMEDSKJAER M M. Indentation size effect and the plastic compressibility of glass[J]. Applied Physics Letters, 2014, 104(25): 251906.
[12] 张联盟,黄学辉,宋晓岚.材料科学基础[M].2版.武汉:武汉理工大学出版社,2008.
ZHANG L M, HUANG X H, SONG X L. Foundamentals of materials science[M]. 2nd ed. Wuhan: Wuhan University of Technology Press, 2008 (in Chinese).
[13] SHI C J. Corrosion of glasses and expansion mechanism of concrete containing waste glasses as aggregates[J]. Journal of Materials in Civil Engineering, 2009, 21(10): 529-534.
[14] POE B T, MCMILLAN P F, COTÉ B, et al. Structure and dynamics in calcium aluminate liquids: high-temperature ²⁷Al NMR and Raman spectroscopy[J]. Journal of the American Ceramic Society, 1994, 77(7): 1832-1838.
[15] MCMILLAN P, PIRIOU B, NAVROTSKY A. A Raman spectroscopic study of glasses along the joins silica-calcium aluminate, silica-sodium aluminate, and silica-potassium aluminate[J]. Geochimica et Cosmochimica Acta, 1982, 46(11): 2021-2037.
[16] MCMILLAN P, PIRIOU B. Raman spectroscopy of calcium aluminate glasses and crystals[J]. Journal of Non-Crystalline Solids, 1983, 55(2): 221-242.
[17] NEUVILLE D R, HENDERSON G S, CORMIER L, et al. The structure of crystals, glasses, and melts along the CaO-Al₂O₃ join: results from Raman, Al L- and K-edge X-ray absorption, and ²⁷Al NMR spectroscopy[J]. American Mineralogist, 2010, 95(10): 1580-1589.
[18] HIRAO K, MATSUOKA J, SAGA N. Inelastic deformation and structure of borate glasses[J]. Journal of Non-Crystalline Solids, 1989, 112(1/2/3): 336-340.
[19] 林宗寿.无机非金属材料工学[M].3版.武汉:武汉理工大学出版社,2008.
LIN Z T. Inorganic metalloid materials technics[M]. 3rd ed. Wuhan: Wuhan University of Technology Press, 2008 (in Chinese).
[20] IKEDA T, BOERO M, TERAKURA K. Hydration properties of magnesium and calcium ions from constrained first principles molecular dynamics[J]. The Journal of Chemical Physics, 2007, 127(7): 074503.
[21] LIU P F, YOUNGMAN R E, JENSEN L R, et al. Achieving ultrahigh crack resistance in glass through humid aging[J]. Physical Review Materials, 2020, 4(6): 063606.