养护温度对喷射混凝土性能影响的试验研究

硅酸盐通报 ›› 2017, Vol. 36 ›› Issue (10): 3487-3492.

养护温度对喷射混凝土性能影响的试验研究

范利丹;李培涛;余永强;张子建

河南理工大学河南省高等学校深部矿井建设重点学科开放试验室,焦作 454000;河南理工大学土木工程学院,焦作 454000;河南理工大学土木工程学院,焦作,454000

出版日期:2017-10-15 发布日期:2021-01-18
基金资助:
河南理工大学青年科学基金项目(Q2017-5)%河南省高等学校深部矿井建设重点学科开放实验室基金课题(2014KF-02)%中铁隧道集团有限公司科技创新计划项目(H14-233)

Experimental Study on the Effect of Curing Temperature on Shotcrete Properties

FAN Li-dan;LI Pei-tao;YU Yong-qiang;ZHANG Zi-jian

Online:2017-10-15 Published:2021-01-18

摘要/Abstract

摘要： 为探究不同地温环境对喷射混凝土性能的影响,本研究在实验室模拟相应温度条件,开展不同养护温度下喷射混凝土强度、耐久性及混凝土与岩石粘结强度的研究.结果表明,在25～40℃养护条件下,随养护温度的提高,喷射混凝土的抗压强度、混凝土与岩石的粘结强度呈增大趋势,但在60℃养护条件下抗压强度和粘结强度均降低并随龄期呈先增大后降低的趋势;25～60℃养护条件下的混凝土抗渗等级都为最高等级,氯离子渗透性皆处于低级;随温度升高,其抗渗性、抗氯离子渗透性、抗碳化能力均有所降低.

关键词: 喷射混凝土;养护温度;抗压强度;耐久性;粘结强度

Abstract: In order to explore the effect of different geothermal environment on shotcrete properties , the simulation environments of different temperatures were designed in the laboratory .Then, the compressive strength and durability of shotcrete , bond strength of shotcrete and rock were carried out .The results showed that the compressive strength and the bond strength between concrete and rock increased with the curing temperature rising during 25-40 ℃, but decreased at 60 ℃.What is more , the compressive strength and the bond strength increased first and then decreased with the increase of age at 60 ℃curing temperature .The shotcrete cured at different temperatures all had the highest permeability resistance grade, and the penetrabilities of chloride ion all were low-grade.Moreover, the permeability resistance , the chlorion penetration resistance and the carbonation resistance were gradually reduced as the curing temperature rised .

Key words: shotcrete;curing temperature;compressive strength;durability;bond strength

中图分类号:

TU528.53

范利丹;李培涛;余永强;张子建. 养护温度对喷射混凝土性能影响的试验研究[J]. 硅酸盐通报, 2017, 36(10): 3487-3492.

FAN Li-dan;LI Pei-tao;YU Yong-qiang;ZHANG Zi-jian. Experimental Study on the Effect of Curing Temperature on Shotcrete Properties[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2017, 36(10): 3487-3492.

[1]	王子明;王杰;甘杰忠;张佳乐. “水泥-速凝剂-水”系统的水化反应特征及凝结硬化机理研究现状[J]. 硅酸盐通报, 2020, 39(10): 3045-3054.
[2]	张志超. 骨料粒径对自密实混凝土流变性、工作性和静态稳定性影响研究[J]. 硅酸盐通报, 2020, 39(7): 2139-2144.
[3]	李悦;田小璇;金彩云;王子赓;李亚强;王睿. 基于CFD的泵送混凝土流变性能数值模拟研究[J]. 硅酸盐通报, 2020, 39(4): 1139-1144.
[4]	孟亚锋;张宇星;沈卫国;谢兼量;杨文亚;唐祥春. 清水自密实混凝土清水效果表征与研究[J]. 硅酸盐通报, 2019, 38(8): 2683-268.
[5]	龙广成;刘赫;刘昊. 充填层自密实混凝土力学性能[J]. 硅酸盐通报, 2017, 36(12): 3964-3970.
[6]	袁斌;牛荻涛;王家滨. 复合盐蚀环境下喷射混凝土离子分布规律及氯离子扩散系数[J]. 硅酸盐通报, 2017, 36(6): 1860-1867.
[7]	袁斌;牛荻涛;蒿洋;王家滨. 干湿循环与盐湖卤水侵蚀共同作用下喷射混凝土的劣化及其机理[J]. 硅酸盐通报, 2017, 36(2): 607-613.