铁尾矿粉、砂泥粉对水泥-减水剂体系工作性能的影响

硅酸盐通报 ›› 2016, Vol. 35 ›› Issue (9): 3020-3024.

铁尾矿粉、砂泥粉对水泥-减水剂体系工作性能的影响

李晓光;杨俊;万桥;屈雅安

长安大学建筑工程学院,西安,710061

出版日期:2016-09-15 发布日期:2021-01-18
基金资助:
陕西省科技统筹创新工程计划项目(2013KTCG02-02)；2015年度中央高校基本科研业务费(310828152016)

Effect of Iron Ore Tailing and Sand Mud Powder on Workability of Cement Paste with Water-reducer

LI Xiao-guang;YANG Jun;WAN Qiao;QU Ya-an

Online:2016-09-15 Published:2021-01-18

摘要/Abstract

摘要： 为揭示铁尾矿粉和天然河砂中砂泥粉对水泥净浆体系的影响规律，分别测试了聚羧酸减水剂（ PCA）和萘系减水剂（ FDN）与两类粉体双掺后水泥浆动电电位和流变参数。结果表明：铁尾矿粉与砂泥粉对水泥-减水剂体系工作性能的影响存在显著差异。在PCA-水泥浆与铁尾矿粉或砂泥粉的双掺体系中，含铁尾矿粉水泥浆动电电位及塑性粘度变化率明显低于含砂泥粉水泥浆体系，铁尾矿粉对水泥浆流动性影响较小；采用FDN时，含砂泥粉的水泥浆体系流动性能优于掺铁尾矿粉的水泥浆体系；当水泥浆体系中粉体外掺量达到7％时，浆体塑性粘度显著增加，浆体体系流动性较差。

关键词: 铁尾矿粉;砂泥粉;动电电位;塑性粘度

Abstract: To reveal the effect of iron ore tailing(IOT) and sand mud powder(SMP)on workability of cement paste , measurement of electrokinetic potential and rheological parameters were employed as polycarboxylic superplasticizer ( PCA) and naphthalene superplasticizer ( FDN) respectively with the two sorts of powders were added into cement pastes .The results show that the influence of IOT and SMP on the workability of pastes make remarkable difference .The rate of change of plastic viscosity and change ofζpotential keep significantly lower in the paste containing IOT compared with SMP by adding PCA ,the influence of IOT to the slurry liquidity and rheological properties is significantly lower .As FDN is used as admixture,great fluctuation of plastic viscosities of the pastes occur with increasing amount of fine powder , however workability of pastes with SMP is superior to of IOT with prolongation of time .When the mass fraction of powder in paste is 7%,the fluxility of paste will decrease .

Key words: iron ore tailing;sand mud powder;electrokinetic potential;plastic viscosity

中图分类号:

TD98

李晓光;杨俊;万桥;屈雅安. 铁尾矿粉、砂泥粉对水泥-减水剂体系工作性能的影响[J]. 硅酸盐通报, 2016, 35(9): 3020-3024.

LI Xiao-guang;YANG Jun;WAN Qiao;QU Ya-an. Effect of Iron Ore Tailing and Sand Mud Powder on Workability of Cement Paste with Water-reducer[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2016, 35(9): 3020-3024.

[1]	董红娟;王博;张金山;袁治国;温磊. 粉煤灰基复合胶凝喷浆材料的强度及水化机理[J]. 硅酸盐通报, 2020, 39(10): 3293-3297.
[2]	邢行;杨仕教. 某铅锌矿超细全尾砂炼铅炉渣-水泥复合充填胶凝材料研究[J]. 硅酸盐通报, 2020, 39(7): 2232-2240.
[3]	钱玉鹏;王路路;吴望妮;田忍杰;江学峰;王飞. 表面改性对蛭石流延浆料性能的影响[J]. 硅酸盐通报, 2020, 39(7): 2326-2329.
[4]	惠博;陈伟;毛益林. 秦岭地区某页岩型钒矿中钒的赋存状态研究[J]. 硅酸盐通报, 2020, 39(6): 1882-1886.
[5]	王飞;钱玉鹏;江学峰;胡善海;吴望妮;田忍杰;王路路. 高温膨胀蛭石粉末分散稳定性研究[J]. 硅酸盐通报, 2020, 39(5): 1403-1407.
[6]	李佩悦;马立云;吴建新;高惠民;管俊芳. TFT-LCD玻璃基板用海相沉积型天然石英砂的工艺矿物学研究[J]. 硅酸盐通报, 2020, 39(5): 1650-1658.
[7]	孙青;柯美林;撒玉彪;张俭;严俊;盛嘉伟. 水热法制备Bi2MoO6/埃洛石复合光催化剂及其性能研究[J]. 硅酸盐通报, 2020, 39(5): 1677-1680.
[8]	李鑫;吴雪兰;龙红明;王为奎;余正伟;张洋. 低品质膨润土提质改性技术研究[J]. 硅酸盐通报, 2020, 39(3): 837-843.
[9]	田增愿;赵博. 磷矿悬浮态焙烧半工业化试验研究[J]. 硅酸盐通报, 2020, 39(3): 849-854.
[10]	闫琨;刘万超;和新忠;张英. 水化石榴石对赤泥基地聚物形成过程的影响研究[J]. 硅酸盐通报, 2020, 39(2): 527-531.
[11]	孔德顺;吴红;连明磊. 高铁含量煤矸石制备4A分子筛的研究[J]. 硅酸盐通报, 2019, 38(9): 2999-300.
[12]	刘璇;李如燕;崔孝炜;谢喆敏;南宁. 机械力对高硅钒尾矿活化性能的影响[J]. 硅酸盐通报, 2019, 38(8): 2662-266.
[13]	周飞;杨林;曹建新. 中低品位磷矿焙烧过程中白云石热分解动力学研究[J]. 硅酸盐通报, 2019, 38(5): 1377-138.
[14]	张超凡;管学茂;勾密峰;张海波. 改性钙基膨润土对水泥浆体悬浮性的影响[J]. 硅酸盐通报, 2019, 38(3): 717-721.
[15]	潘妮;陈平安;肖水方;高标;戴方钦. 过渡金属催化剂及热解条件对新疆吉木萨尔油页岩热解的影响[J]. 硅酸盐通报, 2019, 38(3): 865-871.