含粗骨料超高性能混凝土静态稳定性研究

硅酸盐通报 ›› 2024, Vol. 43 ›› Issue (7): 2441-2450.

所属专题：水泥混凝土

含粗骨料超高性能混凝土静态稳定性研究

蒋健^1,2, 李传习^1,2,3, 邓帅^1,2, 司睹英胡^1,2, 杨赛^1,2

1.长沙理工大学桥梁工程安全控制教育部重点实验室,长沙 410114;
2.长沙理工大学土木工程学院,长沙 410114;
3.广西大学土木与建筑学院,南宁 530004

收稿日期:2023-12-09 修订日期:2024-01-02 出版日期:2024-07-15 发布日期:2024-07-24
通信作者: 李传习,博士,教授。E-mail:lichuanxi2@163.com
作者简介:蒋健(2000—),男,硕士研究生。主要从事超高性能混凝土新材料的研究。E-mail:2412697349@qq.com
基金资助:
国家自然科学基金(52078059);长沙理工大学研究生“实践创新与创业能力提升计划”项目(CLSJCX22053)

Static Stability of Ultra-High Performance Concrete Containing Coarse Aggregate

JIANG Jian^1,2, LI Chuanxi^1,2,3, DENG Shuai^1,2, SIDU Yinghu^1,2, YANG Sai^1,2

1. Key Laboratory of Safety Control of Bridge Engineering Ministry of Education, Changsha University of Science and Technology, Changsha 410114, China;
2. College of Civil Engineering, Changsha University of Science and Technology, Changsha 410114, China;
3. College of Civil Engineering and Architecture, Guangxi University, Nanning 530004, China

Received:2023-12-09 Revised:2024-01-02 Online:2024-07-15 Published:2024-07-24

摘要/Abstract

摘要： 为改善含粗骨料超高性能混凝土(CA-UHPC)整体静态稳定性,采用图像技术分别研究了拌合物(未加纤维)流变参数、粗骨料掺量和粗骨料级配对不含纤维和含纤维CA-UHPC静态稳定性的影响规律。结果表明:粗骨料整体均匀性随粗骨料平均初始净距的减小而升高;当拌合物的屈服应力和塑性粘度较小时,纤维分布的均匀性会因纤维沉降而降低;纤维的加入降低了粗骨料的整体均匀性,同时粗骨料也会影响纤维的整体均匀性;对CA-UHPC体系而言,粗骨料平均初始净距的减小可以增加粗骨料分布稳定性,但过小的粗骨料平均初始净距会影响纤维的分布。因此,在粗骨料掺量一定时,可以通过适当调整粗骨料级配或砂率,在不影响粗骨料分布稳定性的前提下,提高纤维分布系数。

关键词: 超高性能混凝土, 静态稳定性, 平均初始净距, 流变参数, 粗骨料, 纤维分布

Abstract: In order to improve the overall static stability of ultra-high performance concrete containing coarse aggregate (CA-UHPC), the image analysis was employed to investigate the effects of rheological parameters of the mixture (before adding fiber), coarse aggregate content and coarse aggregate gradation on the static stability of CA-UHPC without fiber and with fiber. The results show that the overall uniformity of coarse aggregate increases with the decrease of the average initial clear distance of coarse aggregate. When the yield stress and plastic viscosity of the mixture are small, the uniformity of fiber distribution decreases due to fiber settlement. The addition of fiber reduces the overall uniformity of coarse aggregate, and the coarse aggregate also affects the uniform distribution of fiber. For the CA-UHPC system, the reduction of the average initial clear distance of coarse aggregate particles increases the distribution stability of coarse aggregate, but too low average initial clear distance between coarse aggregate particles affects the distribution of fiber. Therefore, when the content of coarse aggregate is constant, the fiber distribution coefficient can increase without affecting the stability of coarse aggregate by adjusting the coarse aggregate gradation or sand ratio.

Key words: ultra-high performance concrete, static stability, average initial clear distance, rheological parameter, coarse aggregate, fiber distribution

中图分类号:

TU528

蒋健, 李传习, 邓帅, 司睹英胡, 杨赛. 含粗骨料超高性能混凝土静态稳定性研究[J]. 硅酸盐通报, 2024, 43(7): 2441-2450.

JIANG Jian, LI Chuanxi, DENG Shuai, SIDU Yinghu, YANG Sai. Static Stability of Ultra-High Performance Concrete Containing Coarse Aggregate[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2024, 43(7): 2441-2450.

参考文献

[1] ARORA A, ALMUJADDIDI A, KIANMOFRAD F, et al. Material design of economical ultra-high performance concrete (UHPC) and evaluation of their properties[J]. Cement and Concrete Composites, 2019, 104: 103346.
[2] 杨博文, 戴磊, 金鹭云, 等. 超高性能混凝土(UHPC)研究综述[J]. 建筑技术, 2020, 51(12): 1422-1425.
YANG B W, DAI L, JIN L Y, et al. Review of research on ultra-high performance concrete[J]. Architecture Technology, 2020, 51(12): 1422-1425 (in Chinese).
[3] 黄维蓉, 杨玉柱, 崔通, 等. 含粗骨料超高性能混凝土收缩变形性能的研究[J]. 混凝土, 2021(8): 99-103.
HUANG W R, YANG Y Z, CUI T, et al. Study on the workability and mechanical properties of ultra-high performance concrete containing coarse aggregate[J]. Concrete, 2021(8): 99-103 (in Chinese).
[4] 史占崇, 苏庆田, 邵长宇, 等. 粗骨料UHPC的基本力学性能及弯曲韧性评价方法[J]. 土木工程学报, 2020, 53(12): 86-97.
SHI Z C, SU Q T, SHAO C Y, et al. Basic mechanical behavior and flexural toughness evaluation method of coarse aggregate UHPC[J]. China Civil Engineering Journal, 2020, 53(12): 86-97 (in Chinese).
[5] LI P P, YU Q L, BROUWERS H J H. Effect of coarse basalt aggregates on the properties of ultra-high performance concrete (UHPC)[J]. Construction and Building Materials, 2018, 170: 649-659.
[6] AMIN M, TAYEH B A, AGWA I S. Effect of using mineral admixtures and ceramic wastes as coarse aggregates on properties of ultrahigh-performance concrete[J]. Journal of Cleaner Production, 2020, 273: 123073.
[7] 李文旭, 马昆林, 龙广成, 等. 自密实混凝土拌合物稳定性动态监测及数值模拟研究进展[J]. 材料导报, 2019, 33(13): 2206-2213.
LI W X, MA K L, LONG G C, et al. Stability dynamic monitoring and simulation of self-compacting concrete: a review[J]. Materials Reports, 2019, 33(13): 2206-2213 (in Chinese).
[8] ESMAEILKHANIAN B, DIEDERICH P, KHAYAT K H, et al. Influence of particle lattice effect on stability of suspensions: application to self-consolidating concrete[J]. Materials and Structures, 2016, 50(1): 39.
[9] 王振, 李化建, 易忠来, 等. 自密实混凝土稳定性机理及其影响因素研究新进展[J]. 材料导报, 2017, 31(增刊1): 379-383.
WANG Z, LI H J, YI Z L, et al. Research progress on stability mechanism and influencing factors of self-compacting concrete[J]. Materials Reports, 2017, 31(supplement 1): 379-383 (in Chinese).
[10] 张丽辉, 刘加平, 周华新, 等. 粗骨料与钢纤维对超高性能混凝土单轴拉伸性能的影响[J]. 材料导报, 2017, 31(23): 109-114.
ZHANG L H, LIU J P, ZHOU H X, et al. Effects of coarse aggregate and steel fiber on uniaxial tensile property of ultra-high performance concrete[J]. Materials Review, 2017, 31(23): 109-114 (in Chinese).
[11] KANG S T, KIM J K. Investigation on the flexural behavior of UHPCC considering the effect of fiber orientation distribution[J]. Construction and Building Materials, 2012, 28(1): 57-65.
[12] 张倩倩, 刘建忠, 周华新, 等. 超高性能混凝土流变特性及其对纤维分散性的影响[J]. 材料导报, 2017, 31(23): 73-77.
ZHANG Q Q, LIU J Z, ZHOU H X, et al. Rheological properties of ultra-high performance concrete and its effect on the fiber dispersion within the material[J]. Materials Review, 2017, 31(23): 73-77 (in Chinese).
[13] 程俊, 刘加平, 张丽辉. 含粗骨料超高性能混凝土单轴拉伸性能及机理分析[J]. 混凝土与水泥制品, 2015(12): 1-5.
CHENG J, LIU J P, ZHANG L H. Properties of uniaxial tensile of ultra-high performance concrete containing coarse aggregate and mechanical analysis[J]. China Concrete and Cement Products, 2015(12): 1-5 (in Chinese).
[14] 黄维蓉, 杨玉柱, 刘延杰, 等. 含粗骨料超高性能混凝土的力学性能[J]. 硅酸盐学报, 2020, 48(11): 1747-1755.
HUANG W R, YANG Y Z, LIU Y J, et al. Mechanical properties of ultra-high performance concrete containing coarse aggregate[J]. Journal of the Chinese Ceramic Society, 2020, 48(11): 1747-1755 (in Chinese).
[15] 郑晓博, 韩方玉, 刘建忠, 等. 粗骨料超高性能混凝土流变与稳定性[J]. 硅酸盐学报, 2022, 50(11): 2844-2854.
ZHENG X B, HAN F Y, LIU J Z, et al. Rheological properties and stability of ultra-high performance concrete containing coarse aggregate[J]. Journal of the Chinese Ceramic Society, 2022, 50(11): 2844-2854 (in Chinese).
[16] LI L J, XU L H, HUANG L, et al. Compressive fatigue behaviors of ultra-high performance concrete containing coarse aggregate[J]. Cement and Concrete Composites, 2022, 128: 104425.
[17] LIU J Z, HAN F Y, CUI G, et al. Combined effect of coarse aggregate and fiber on tensile behavior of ultra-high performance concrete[J]. Construction and Building Materials, 2016, 121: 310-318.
[18] KOURA B I O, HOSSEINPOOR M, YAHIA A. Coupled effect of fine mortar and granular skeleton characteristics on dynamic stability of self-consolidating concrete as a diphasic material[J]. Construction and Building Materials, 2020, 263: 120131.
[19] 国家质量监督检验检疫总局, 中国国家标准化管理委员会. 活性粉末混凝土: GB/T 31387—2015[S]. 北京: 中国标准出版社, 2015.
General Administration of Quality Supervision, Inspection and Quarantine, Standardization Administration, the People’s Republic of China. Reactive powder concrete: GB/T 31387—2015[S]. Beijing: Standard Press of China, 2015 (in Chinese).
[20] 武斌, 安晓鹏, 史才军, 等. 混凝土流变特性对其稳定性及浇筑后外观质量的影响[J]. 材料导报, 2020, 34(4): 4043-4048.
WU B, AN X P, SHI C J, et al. Effect of rheological properties on stability and appearance of cast concrete[J]. Materials Reports, 2020, 34(4): 4043-4048 (in Chinese).
[21] WANG R, GAO X J, HUANG H H, et al. Influence of rheological properties of cement mortar on steel fiber distribution in UHPC[J]. Construction and Building Materials, 2017, 144: 65-73.
[22] LI K K, LENG Y, XU L L, et al. Rheological characteristics of ultra-high performance concrete (UHPC) incorporating bentonite[J]. Construction and Building Materials, 2022, 349: 128793.
[23] 王圣杰, 李兵, 李传习, 等. 超高性能混凝土流动性与流变性关系[J]. 硅酸盐学报, 2023, 51(8): 1962-1970.
WANG S J, LI B, LI C X, et al. Flowability and rheological properties of ultra-high performance concrete[J]. Journal of the Chinese Ceramic Society, 2023, 51(8): 1962-1970 (in Chinese).
[24] YU R, XU L L, LI K K, et al. Dynamic behaviors assessment of steel fibres in fresh ultra-high performance concrete (UHPC): experiments and numerical simulations[J]. Journal of Building Engineering, 2022, 59: 105084.
[25] 张秀芝, 毕梦迪, 刘同军, 等. 钢纤维混凝土中纤维分布特性影响因素研究进展[J]. 硅酸盐学报, 2021, 49(8): 1732-1742.
ZHANG X Z, BI M D, LIU T J, et al. Research progress in factors affecting fiber distribution in steel fiber concrete[J]. Journal of the Chinese Ceramic Society, 2021, 49(8): 1732-1742 (in Chinese).
[26] 高珍, 曾力, 刘军鹏. 骨料粒径对自密实混凝土离析的影响研究[J]. 西北水电, 2014(6): 50-53.
GAO Z, ZENG L, LIU J P. Study of impacts by aggregate size on segregation of self-compaction concrete[J]. Northwest Hydropower, 2014(6): 50-53 (in Chinese).
[27] ROUSSEL N. A theoretical frame to study stability of fresh concrete[J]. Materials and Structures, 2006, 39(1): 81-91.
[28] 汪玺玥. 超高性能水泥基材料流变行为及机理研究[D]. 南京: 东南大学, 2020: 63-69.
WANG X Y. Study on rheological behavior and mechanism of ultra-high performance cement-based materials[D]. Nanjing: Southeast University, 2020: 63-69 (in Chinese).
[29] GOLTERMANN P, JOHANSEN V, PALBØL L. Packing of aggregates: an alternative tool to determine the optimal aggregate mix[J]. ACI Materials Journal, 1997, 94(5): 435-443.
[30] RODIN G J. Squeeze film between two spheres in a power-law fluid[J]. Journal of Non-Newtonian Fluid Mechanics, 1996, 63(2/3): 141-152.

含粗骨料超高性能混凝土静态稳定性研究

Static Stability of Ultra-High Performance Concrete Containing Coarse Aggregate

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王发静, 王新杰, 朱平华, 刘啸林. 粗骨料取代率对机制砂再生混凝土高温性能的影响[J]. 硅酸盐通报, 2024, 43(6): 2084-2092.
[2]	毛翔, 杨鼎宜, 曹忠露, 赵健, 陈龙祥, 王彤章. 基于图像法对自密实超高性能混凝土性能提升的研究[J]. 硅酸盐通报, 2024, 43(4): 1398-1409.
[3]	罗伊明, 张博, 刘彦钰, 吴守军, 付国. 混杂纤维增强超高性能混凝土的高温性能试验研究[J]. 硅酸盐通报, 2024, 43(3): 825-832.
[4]	成旭, 朱平华, 王新杰, 刘惠, 王华宇, 王月盈, 陈垂睿. 矿物掺合料对再生混凝土抗冻性与可再生性的影响[J]. 硅酸盐通报, 2024, 43(3): 956-964.
[5]	韦亚平, 李绍成, 王有志, 田长进. 多尺度MgO膨胀剂与SAP协同作用对UHPC力学及收缩性能的影响[J]. 硅酸盐通报, 2023, 42(9): 3154-3165.
[6]	高德军, 黄玉龙, 王青, 王旋. 杂散电流环境下UHPC劣化特征研究[J]. 硅酸盐通报, 2023, 42(6): 2007-2014.
[7]	李传习, 夏雨航, 王圣杰, 邓帅, 蒋健. 初凝超30min超早强UHPC制备及其机理[J]. 硅酸盐通报, 2023, 42(5): 1630-1639.
[8]	丁超, 贾子杰, 王振华, 丁玉贤. 基于生命周期评价的UHPC碳排放控制潜力评估[J]. 硅酸盐通报, 2023, 42(4): 1242-1251.
[9]	李相国, 张乘, 吕阳, 李树国, 田博, 张成龙, 柯凯. 陶瓷抛光废料制备UHPC的耐久性能试验研究[J]. 硅酸盐通报, 2023, 42(4): 1418-1427.
[10]	张占强, 陈平, 李顺凯, 明阳, 刘荣进, 李航, 赵欢. 氧化镁膨胀剂对UHPC浆体早期孔结构演变的影响[J]. 硅酸盐通报, 2023, 42(3): 871-877.
[11]	唐咸远, 马杰灵, 罗杰, 何滨冰, 陆澄剑. 钢渣微粉生态型超高性能混凝土力学性能影响因素分析[J]. 硅酸盐通报, 2023, 42(2): 607-617.
[12]	韦强, 高强, 卢福洲, 陈亮胜, 陈犇, 赵国欣, 李静, 陈正. 基于流变参数多样本统计的自密实混凝土稳定性及均匀性分析方法[J]. 硅酸盐通报, 2023, 42(12): 4298-4308.
[13]	路宇, 吴晨洁, 王德志, 赵晏. 复掺再生砂和超细粉煤灰对超高性能混凝土抗硫酸盐侵蚀性能的影响[J]. 硅酸盐通报, 2023, 42(10): 3671-3678.
[14]	陈鹏博, 李北星, 曾波. 再生粗骨料粒径对混凝土力学和耐久性能的影响[J]. 硅酸盐通报, 2023, 42(10): 3679-3687.
[15]	兰素恋, 田威, 张红日, 高晋峰, 韩祖丽, 李红明. 基于熵权法和灰色理论的钢渣粗骨料混凝土耐久性评估及寿命预测[J]. 硅酸盐通报, 2023, 42(10): 3710-3721.