高性价比混杂纤维工程水泥基复合材料的力学性能研究

硅酸盐通报 ›› 2023, Vol. 42 ›› Issue (11): 3816-3826.

所属专题：水泥混凝土

高性价比混杂纤维工程水泥基复合材料的力学性能研究

张品乐, 朱昊天, 胡静, 曾靖渊, 陶忠

昆明理工大学建筑工程学院,昆明 650500

收稿日期:2023-06-14 修订日期:2023-08-20 出版日期:2023-11-15 发布日期:2023-11-22
通信作者: 朱昊天,硕士研究生。E-mail:zhuhaotian0814@163.com
作者简介:张品乐(1975—),男,博士,教授。主要从事混杂纤维混凝土材料力学性能方面的研究。E-mail:zhangpinlezhang@163.com
基金资助:
国家自然科学基金(52168069,51568028)

Mechanical Properties of High Cost Performance Hybrid Fiber Engineered Cementitious Composites

ZHANG Pinle, ZHU Haotian, HU Jing, ZENG Jingyuan, TAO Zhong

Faculty of Civil Engineering and Mechanics, Kunming University of Science and Technology, Kunming 650500, China

Received:2023-06-14 Revised:2023-08-20 Online:2023-11-15 Published:2023-11-22

摘要/Abstract

摘要： 为提高工程水泥基复合材料(ECC)的经济适用性,并保证其较好的拉伸延性,研究了PVA-ECC的制备方法,配制出性价比较高的PVA-ECC,为实际工程提供更多的材料选择。首先基于ECC的微观力学模型和多尺度结构特征,确定ECC配合比的优化方向。然后通过设计12组不同配合比的ECC试件单轴压缩试验和单轴拉伸试验,研究硅灰、水泥/粉煤灰比、水胶比、PVA纤维种类和CaCO₃晶须对ECC力学性能的影响,确定了混杂纤维水泥基复合材料的较优配合比。最后通过价值工程法对比分析本文制备的混杂纤维水泥基复合材料的经济价值,并根据其成本和性能,提出了三种具有代表性的配合比:低成本、拉伸延展性相对较低、单掺国产PVA纤维的H12;中等成本、拉伸延展性相对较高、复掺两种PVA纤维的H11;高成本、高拉伸延展性、复掺日产PVA纤维和CaCO₃晶须的H8。本研究可为实现力学性能优化和经济性提高的双重目标提供数据参考。

关键词: 工程水泥基复合材料, PVA纤维, CaCO₃晶须, 力学性能, 经济价值

Abstract: In order to improve the economic applicability of engineered cementitious composites (ECC) and ensure its good tensile ductility, the preparation method of PVA-ECC was studied, and PVA-ECC with high cost performance was prepared to provide more material selection for practical engineering. Firstly, based on the micro-mechanical model and multi-scale structural characteristics of ECC, the optimization direction of ECC mix ratio was determined. Then, the uniaxial compression test and uniaxial tensile test were carried out by designing 12 groups of ECC specimens with different mix ratios. The effects of silica fume, cement -fly ash ratio, water-binder ratio, PVA fiber type and CaCO₃ whisker on the mechanical properties of ECC were studied, and the optimal mix ratio of hybrid fiber cement-based composites was determined. Finally, the economic value of the hybrid fiber engineered cementitious composites prepared in this paper was compared and analyzed by the value engineering method. According to its cost and performance, three representative mix ratios were proposed: H12 with low cost, relatively low tensile ductility and reinforced by domestic PVA fibers, H11 with moderate cost, relatively high tensile ductility and reinforced by hybrid PVA fibers and H8 with high cost, high tensile ductility and reinforced by Japanese PVA fibers and CaCO₃ whisker. This study can provide data reference for achieving the dual goals of mechanical performance optimization and economic improvement.

Key words: engineered cementitious composite, PVA fiber, CaCO₃whisker, mechanical property, economic value

中图分类号:

TU502⁺.6

张品乐, 朱昊天, 胡静, 曾靖渊, 陶忠. 高性价比混杂纤维工程水泥基复合材料的力学性能研究[J]. 硅酸盐通报, 2023, 42(11): 3816-3826.

ZHANG Pinle, ZHU Haotian, HU Jing, ZENG Jingyuan, TAO Zhong. Mechanical Properties of High Cost Performance Hybrid Fiber Engineered Cementitious Composites[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2023, 42(11): 3816-3826.

参考文献

[1] LI V C, MISHRA D K, NAAMAN A E, et al. On the shear behavior of engineered cementitious composites[J]. Advanced Cement Based Materials, 1994, 1(3): 142-149.
[2] LI V C, LEUNG C K Y. Steady-state and multiple cracking of short random fiber composites[J]. Journal of Engineering Mechanics, 1992, 118(11): 2246-2264.
[3] LI V C. Engineered cementitious composites tailo-red composites through micromechanical modeling[J]. Canadian Society for Civil Engineering, 1998: 64-97.
[4] PAN Z F, WU C, LIU J Z, et al. Study on mechanical properties of cost-effective polyvinyl alcohol engineered cementitious composites (PVA-ECC)[J]. Construction and Building Materials, 2015, 78: 397-404.
[5] PEREIRA E B, FISCHER G, BARROS J A O. Direct assessment of tensile stress-crack opening behavior of strain hardening cementitious composites (SHCC)[J]. Cement and Concrete Research, 2012, 42(6): 834-846.
[6] 张聪, 曹明莉. 多尺度纤维增强水泥基复合材料力学性能试验[J]. 复合材料学报, 2014, 31(3): 661-668.
ZHANG C, CAO M L. Mechanical property test of a multi-scale fiber reinforced cementitious composites[J]. Acta Materiae Compositae Sinica, 2014, 31(3): 661-668 (in Chinese).
[7] LI V C. From micromechanics to structural engineering-the design of cementitious composites for civil engineering applications[J]. Structural Engineering/Earthquake Engineering, 1994, 10(2): 1-34.
[8] MARSHALL D B, COX B N. A J-integral method for calculating steady-state matrix cracking stresses in composites[J]. Mechanics of Materials, 1988, 7(2): 127-133.
[9] KANDA T, LI V C. Practical design criteria for saturated pseudo strain hardening behavior in ECC[J]. Journal of Advanced Concrete Technology, 2006, 4(1): 59-72.
[10] MA H, CAI J M, LIN Z, et al. CaCO₃ whisker modified engineered cementitious composite with local ingredients[J]. Construction and Building Materials, 2017, 151: 1-8.
[11] PICHLER C, LACKNER R, MANG H A. A multiscale micromechanics model for the autogenous-shrinkage deformation of early-age cement-based materials[J]. Engineering Fracture Mechanics, 2007, 74(1/2): 34-58.
[12] 王成启, 吴科如. 不同几何尺寸纤维混杂混凝土的混杂效应[J]. 建筑材料学报, 2005, 8(3): 250-255.
WANG C Q, WU K R. Research on the hybrid effect of different geometrical size hybrid fiber reinforced concrete[J]. Journal of Building Materials, 2005, 8(3): 250-255 (in Chinese).
[13] 工业和信息化部. 高延性纤维增强水泥基复合材料力学性能试验方法: JC/T 2461——2018[J]. 北京:建材工业出版社, 2018.
Ministry of Industry and Information Technology. Test method for mechanical properties of high ductility fiber reinforced cement-based Composites: JC/T 2461—2018[J]. Beijing: Building Materials Industry Press, 2018 (in Chinese).
[14] ZHOU J, QIAN S Z, YE G, et al. Improved fiber distribution and mechanical properties of engineered cementitious composites by adjusting the mixing sequence[J]. Cement and Concrete Composites, 2012, 34(3): 342-348.
[15] 张君, 居贤春, 郭自力. PVA纤维直径对水泥基复合材料抗拉性能的影响[J]. 建筑材料学报, 2009, 12(6): 706-710.
ZHANG J, JU X C, GUO Z L. Tensile properties of fiber reinforced cement composite with different PVA fibers[J]. Journal of Building Materials, 2009, 12(6): 706-710 (in Chinese).
[16] 庞超明, LEUNG C K Y, 孙伟. 高掺量粉煤灰高延性水泥基复合材料的制备和性能[J]. 硅酸盐学报, 2009, 37(12): 2071-2077.
PANG C M, LEUNG C K Y, SUN W. Preparation and properties of high ductility cementitious composites with high content of fly-ash[J]. Journal of the Chinese Ceramic Society, 2009, 37(12): 2071-2077 (in Chinese).
[17] 汪潇, 王宇斌, 杨留栓, 等. 高性能大掺量粉煤灰混凝土研究[J]. 硅酸盐通报, 2013, 32(3): 523-527+532.
WANG X, WANG Y B, YANG L S, et al. High-performance high-volume fly ash concrete[J]. Bulletin of the Chinese Ceramic Society, 2013, 32(3): 523-527+532 (in Chinese).
[18] 王洪, 陈伟天, 陈昌礼. 硅灰对高强混凝土强度影响的试验研究[J]. 混凝土, 2011(7): 74-76.
WANG H, CHEN W T, CHEN C L. Experimental research on the effect of silica fume to the strength of high-strength concrete[J]. Concrete, 2011(7): 74-76 (in Chinese).
[19] 何小芳, 卢军太, 李小楠, 等. 硅灰对混凝土性能影响的研究进展[J]. 硅酸盐通报, 2013, 32(3): 423-428.
HE X F, LU J T, LI X N, et al. Progress in research of effect of silica fume on the performance of cement concrete[J]. Bulletin of the Chinese Ceramic Society, 2013, 32(3): 423-428 (in Chinese).
[20] 刘光焰, 高鹏飞, 李德成, 等. 基于价值工程分析法的玻璃粉混凝土经济性分析[J]. 混凝土, 2020(6): 163-165+174.
LIU G Y, GAO P F, LI D C, et al. Economic analysis of glass powder concrete based on value engineering analysis[J]. Concrete, 2020(6): 163-165+174 (in Chinese).

高性价比混杂纤维工程水泥基复合材料的力学性能研究

Mechanical Properties of High Cost Performance Hybrid Fiber Engineered Cementitious Composites

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	郭政, 穆松, 庄智杰, 张浩, 张蕾. 中/高度真空环境下水泥基材料性能的研究进展[J]. 硅酸盐通报, 2023, 42(9): 3075-3082.
[2]	邓永刚, 代婷婷, 孙晨, 杨元全. 沸石微粉对磷酸钾镁水泥水化性能的影响[J]. 硅酸盐通报, 2023, 42(9): 3083-3088.
[3]	陈友治, 吴修齐, 殷伟淞, 李万民, 汤世昌. 电石渣对复合胶凝材料力学性能和微观结构的影响[J]. 硅酸盐通报, 2023, 42(9): 3196-3203.
[4]	李学亮, 赵庆朝, 李伟光, 李勇, 朱阳戈, 宋厚彬, 杨浩, 张艳平. 煤系偏高岭土对混凝土力学性能及微观结构的影响机理[J]. 硅酸盐通报, 2023, 42(9): 3221-3230.
[5]	郭志翔, 王琴, 张秋臣, 郑海宇, 刘克俊. 氟化物对石膏基胶凝材料结构和性能的影响[J]. 硅酸盐通报, 2023, 42(9): 3248-3257.
[6]	杨医博, 梁宋梭, 刘福财, 谢锐, 欧锦盛, 郭文瑛, 王恒昌. 低吸水率陶瓷再生砂对砂浆力学和干燥收缩性能的影响及机理研究[J]. 硅酸盐通报, 2023, 42(9): 3277-3285.
[7]	彭蔓, 高涌涛, 韩杨, 陈秀丽, 寇雄俊. 废旧钢纤维增强橡胶混凝土力学性能试验研究[J]. 硅酸盐通报, 2023, 42(9): 3286-3294.
[8]	袁志勇, 张学日, 李凯, 许承铭, 吴佳莉, 廖仓冬, 郑猛, 吴英豪, 阎法强. 高铝瓷组成、结构与力学性能随烧成温度的演变[J]. 硅酸盐通报, 2023, 42(9): 3315-3323.
[9]	宋子贤, 温建华. 3M^TM实心陶瓷微球在瓷器补配中的性能研究[J]. 硅酸盐通报, 2023, 42(9): 3342-3349.
[10]	李晓东, 滕逸伟, 赵建宁, 闫升, 杨建荣, 贾小龙. 大掺量煤气化炉渣稳定基层混合料的制备及路用性能研究[J]. 硅酸盐通报, 2023, 42(9): 3412-3420.
[11]	褚洪岩, 安圆圆, 秦健健, 蒋金洋. 轻质高性能混凝土力学性能及微观结构研究[J]. 硅酸盐通报, 2023, 42(8): 2722-2732.
[12]	周丽波, 陈平, 胡成, 荣北国, 张健, 梁翔, 夏海洋, 梁志锋. 钢渣-赤泥-水泥基复合砂浆的水化硬化特性[J]. 硅酸盐通报, 2023, 42(8): 2837-2845.
[13]	王成刚, 刘耀伟, 王帅, 马兵辉, 毕功华. 钢渣双掺混凝土力学与耐久性能试验研究[J]. 硅酸盐通报, 2023, 42(8): 2846-2855.
[14]	李海礁, 王加军, 韩希平, 陶琦, 张仕龙. 大掺量矿物掺合料纤维增强轻骨料混凝土的抗疲劳性能[J]. 硅酸盐通报, 2023, 42(8): 2856-2864.
[15]	王嘉毅, 汪涛, 聂云鹏, 王琪. IP6-HA改性磷酸镁基复合骨水泥的制备与性能研究[J]. 硅酸盐通报, 2023, 42(8): 2888-2894.