不同pH值碱性电解水对砂浆工作性能和强度的影响

硅酸盐通报 ›› 2021, Vol. 40 ›› Issue (11): 3702-3711.

不同pH值碱性电解水对砂浆工作性能和强度的影响

谢子茜¹, 刘桂宾², 张天宇³, 李秋义¹, 王亮¹

1.青岛农业大学建筑工程学院,青岛 266109;
2.青岛青建新型材料集团有限公司,青岛 266108;
3.青岛理工大学土木工程学院,青岛 266103

收稿日期:2021-06-23 修回日期:2021-08-21 出版日期:2021-11-15 发布日期:2021-12-08
通讯作者: 王亮,博士,副教授。E-mail:Liangwang2019@qau.edu.cn
作者简介:谢子茜(1998—),女,硕士研究生。主要从事混凝土耐久性方面的研究。E-mail:1143017150@qq.com
基金资助:
国家自然科学基金(51808310,52078261,51878366);山东省自然科学基金(ZR2019PEE007,ZR2020ME036)

Influence of Alkaline Electrolyzed Water with Different pH Values on Workability and Strength of Mortar

XIE Zixi¹, LIU Guibin², ZHANG Tianyu³, LI Qiuyi¹, WANG Liang¹

1. School of Civil Engineering, Qingdao Agricultural University, Qingdao 266109, China;
2. Qingdao Qingjian New Material Group Co., Ltd., Qingdao 266108, China;
3. School of Civil Engineering, Qingdao Technological University, Qingdao 266103, China

Received:2021-06-23 Revised:2021-08-21 Online:2021-11-15 Published:2021-12-08

摘要/Abstract

摘要： 碱性电解水具有强碱性、高活性、离子性和吸附性等优点,本文利用不同pH值(9.5、10.5、11.5)的碱性电解水制备粉煤灰砂浆,并在粉煤灰取代率为0%、15%及30%(质量分数)的条件下,系统研究了不同pH值碱性电解水对粉煤灰砂浆的工作性能、力学性能以及Ca(OH)₂等水泥水化产物含量的影响规律,并利用XRD、SEM等微观试验对比分析了不同pH值的粉煤灰净浆的结构组成和微观形貌特征。试验结果表明:随着pH值的提高,相较于普通自来水粉煤灰砂浆,碱性电解水粉煤灰砂浆的流动度、抗压强度和抗折强度逐渐提高,水化产物Ca(OH)₂含量逐渐降低。当碱性电解水pH值为10.5,粉煤灰取代率为15%时,碱性电解水粉煤灰砂浆的早期强度和流动度的改善效果达到最佳,28 d的抗压强度和抗折强度较普通水砂浆分别提高了8.4%和12.5%。同时,相较于普通自来水净浆,不同pH值的碱性电解水净浆的团簇化和颗粒化均表现得更加明显,这对于促进水泥水化进程,提高砂浆流动性,激发粉煤灰早期活性起到了积极作用,除了生成更多的C-S-H凝胶体和Ca(OH)₂等水化产物以外,还生成了钾长石等其他水化产物。

关键词: 碱性电解水, 粉煤灰砂浆, 力学性能, pH值, 水化产物

Abstract: Alkaline electrolyzed water has the advantages of strong alkalinity, high activity, ionicity and adsorption. In this study, alkaline electrolyzed water with different pH values (9.5, 10.5, 11.5) was used to prepare fly ash mortar, under the conditions of 0%, 15% and 30% (mass fraction) replacement rate of fly ash, the influence of alkaline electrolyzed water with different pH values on the workability, mechanical properties and the Ca(OH)₂ content of cement hydration products of fly ash mortar was systematically studied. And the structure composition and micro morphology of fly ash paste with different pH values were compared and analyzed by XRD, SEM and other microscopic tests. The test results show that compared with fly ash mortar with ordinary tap water, with the increase of pH value, the fluidity, compressive strength and flexural strength of alkaline electrolyzed water fly ash mortar gradually increase, and the content of hydration product Ca(OH)₂ gradually reduces. When the pH value of alkaline electrolyzed water is 10.5 and the fly ash replacement rate is 15%, the improvement effects of the early strength and fluidity of alkaline electrolyzed water fly ash mortar reach the best, and compared with ordinary tap water mortar, the compressive strength and flexural strength at 28 d increase by 8.4% and 12.5%, respectively. At the same time, compared with ordinary tap water fly ash-cement paste, the clustering and granulation of alkaline electrolyzed water fly ash-cement paste with different pH values are more obvious, which can play a positive role to promote the cement hydration process, improve the fluidity of the mortar, and stimulate the early activity of fly ash. In addition to generating more hydration products such as C-S-H gel and Ca(OH)₂,other hydration products such as potassium feldspar are also generated.

Key words: alkaline electrolyzed water, fly ash mortar, mechanical property, pH value, hydration product

中图分类号:

TU525

谢子茜, 刘桂宾, 张天宇, 李秋义, 王亮. 不同pH值碱性电解水对砂浆工作性能和强度的影响[J]. 硅酸盐通报, 2021, 40(11): 3702-3711.

XIE Zixi, LIU Guibin, ZHANG Tianyu, LI Qiuyi, WANG Liang. Influence of Alkaline Electrolyzed Water with Different pH Values on Workability and Strength of Mortar[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(11): 3702-3711.

参考文献

[1] 何鼎辉,李闯民.矿物掺合料对水泥砂浆性能影响试验研究[J].公路,2021,66(4):285-290.
HE D H, LI C M. Experimental study on the influence of mineral admixtures on the performance of cement mortar[J]. Highway, 2021, 66(4): 285-290 (in Chinese).
[2] 李孝雄,胡明华,袁枫斌.复掺粉煤灰与纳米SiO₂对混凝土性能的影响[J].湖南城市学院学报(自然科学版),2021,30(3):34-38.
LI X X, HU M H, YUAN F B. Effect of mixed fly ash and nano-SiO₂ on concrete performance[J]. Journal of Hunan City University (Natural Science), 2021, 30(3): 34-38 (in Chinese).
[3] 段承刚,孙永涛.复掺高性能矿物掺合料对高强机制砂混凝土性能的影响[J].硅酸盐通报,2021,40(7):2296-2305.
DUAN C G, SUN Y T. Effects of high performance mineral admixtures on performance of high strength manufactured-sand concrete[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(7): 2296-2305 (in Chinese).
[4] 王建新,李晶,赵仕宝,等.中国粉煤灰的资源化利用研究进展与前景[J].硅酸盐通报,2018,37(12):3833-3841.
WANG J X, LI J, ZHAO S B, et al. Research progress and prospect of resource utilization of fly ash in China[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(12): 3833-3841 (in Chinese).
[5] ZHANG J, SHI C J, ZHANG Z H. Chloride binding of alkali-activated slag/fly ash cements[J]. Construction and Building Materials, 2019, 226: 21-31.
[6] 马鹏传,李兴,温振宇,等.粉煤灰的活性激发与机理研究进展[J].无机盐工业,2021,53(10):1-8.
MA P C, LI X, WEN Z Y, et al. Research progress on the activation and mechanism of fly ash[J]. Inorganic Salt Industry, 2021, 53(10): 1-8 (in Chinese).
[7] 王琴,白国强,刘洋,等.不同化学激发剂对矿粉活性的影响研究[J].四川建筑科学研究,2019,45(4):97-101.
WANG Q, BAI G Q, LIU Y, et al. Effect of different chemical activators on mineral powder activity[J]. Sichuan Building Science, 2019, 45(4): 97-101 (in Chinese).
[8] 高嵩,李秋义,吴本清,等.超细矿渣粉水化反应特征及活性评价[J].混凝土,2016(1):96-98+102.
GAO S, LI Q Y, WU B Q, et al. Hydration characteristics and activity evaluation of super fine ground granulated blast furnace slag[J]. Concrete, 2016(1): 96-98+102 (in Chinese).
[9] PRASANPHAN S, WANNAGON A, KOBAYASHI T, et al. Reaction mechanisms of calcined kaolin processing waste-based geopolymers in the presence of low alkali activator solution[J]. Construction and Building Materials, 2019, 221: 409-420.
[10] 贾阳,武晓琼.碱性电解水的工艺设计、功效及发展前景[J].中国医药导刊,2009,11(10):1810-1811.
JIA Y, WU X Q. The process design, efficacy and development prospects of alkaline electrolyzed water[J]. Chinese Journal of Medicinal Guide, 2009, 11(10): 1810-1811 (in Chinese).
[11] 孙炳全.碱性活化水混凝土工艺及性能研究[D].大连:大连理工大学,2011.
SUN B Q. Research on the production process and durability of concrete mixed with alkaline-activated water[D]. Dalian: Dalian University of Technology, 2011 (in Chinese).
[12] 孙炳全,王立久.碱性氧化还原电位水拌和混凝土性能初探[J].建筑材料学报,2009,12(1):112-115+126.
SUN B Q, WANG L J. Study on the properties of concrete mixed with alkaline redox potential water[J]. Journal of Building Materials, 2009, 12(1): 112-115+126 (in Chinese).
[13] 孙炳全,俸永格,林尤全,等.碱性氧化还原电位水理化性能及其应用[J].实验室研究与探索,2009,28(6):30-33.
SUN B Q, FENG Y G, LIN Y Q, et al. Physicochemical properties and applications of alkaline redox potential water[J]. Research and Exploration in Laboratory, 2009, 28(6): 30-33 (in Chinese).
[14] 谢子茜,刘桂宾,张天宇,等.钾基碱性电解水对粉煤灰混凝土性能的影响[J].硅酸盐通报,2021,40(3):943-950+969.
XIE Z X, LIU G B, ZHANG T Y, et al. Influence of potassium-based alkaline electrolyzed water on performance of fly ash concrete[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(3): 943-950+969 (in Chinese).
[15] 李长江,刘桂宾,于琦,等.利用碱性电解水激发砂浆中矿粉活性的研究[J].混凝土与水泥制品,2021(1):30-33+47.
LI C J, LIU G B, YU Q, et al. Effect of alkaline electrolyzed water on activating activity of slag in mortar[J]. China Concrete and Cement Products, 2021(1): 30-33+47 (in Chinese).
[16] CHAKRABORTY S, MANDAL R, CHATTOPADHYAY S, et al. Investigation on the effectiveness of electrolyzed water in controlling the early age properties of cement mortar[J]. Construction and Building Materials, 2019, 211: 1-11.
[17] WANG L, QUAN H Z. Effects of single and compound electrolyte electrolyzed cathode waters on mechanical property and hydration reaction of concrete[J]. Science of Advanced Materials, 2020, 12(3): 366-375.
[18] 张天宇,王亮,李秋义.低碱性电解水对粉煤灰砂浆性能的影响[J].混凝土与水泥制品,2021(5):11-15.
ZHANG T Y, WANG L, LI Q Y. Effect of low-alkaline electrolyzed water on the performance of fly ash mortar[J]. China Concrete and Cement Products, 2021(5): 11-15 (in Chinese).
[19] CHAKRABORTY S, JO B W, SIKANDAR M A. Hydration mechanism of the hydrogen-rich water based cement paste[J]. The Journal of Physical Chemistry C, 2016, 120(15): 8198-8209.
[20] LIU G B, WANG M N, YU Q, et al. Effect of alkaline electrolyzed water on performance improvement of green concrete with high volume of mineral admixtures[J]. Journal of Renewable Materials, 2021, 9(11): 2051-2065.