冻融循环作用下盐浓度对温拌胶粉改性沥青混合料开裂特性影响

硅酸盐通报 ›› 2021, Vol. 40 ›› Issue (5): 1743-1750.

所属专题：道路材料

冻融循环作用下盐浓度对温拌胶粉改性沥青混合料开裂特性影响

冯蕾, 陈征, 王岚, 罗鑫

内蒙古工业大学土木工程学院,内蒙古自治区土木工程结构与力学重点实验室,呼和浩特 010051

收稿日期:2020-12-24 修回日期:2021-02-10 出版日期:2021-05-15 发布日期:2021-06-07
通讯作者: 王岚,博士,教授。E-mail:wanglan661018@163.com
作者简介:冯蕾(1975—),女,博士研究生,副教授。主要从事路面材料方面的研究。E-mail:1515601500@qq.com
基金资助:
国家自然科学基金(11762012);内蒙古自治区自然科学基金(2017MS(LH)0102)

Effect of Salt Concentration on CR-WMA Cracking Characteristics under Freeze-Thaw Cycles

FENG Lei, CHEN Zheng, WANG Lan, LUO Xin

Key Laboratory of Civil Engineering Structure and Mechanics of Inner Mongolia Autonomous Region, School of Civil Engineering, Inner Mongolia University of Technology, Hohhot 010051, China

Received:2020-12-24 Revised:2021-02-10 Online:2021-05-15 Published:2021-06-07

摘要/Abstract

摘要： 为科学分析冻融循环作用下除冰盐侵蚀对温拌胶粉改性沥青混合料(CR-WMA)和热拌胶粉改性沥青混合料(CR-HMA)路面开裂特性的影响,运用数字图像(DIC)技术对三点弯曲重复加载试验下两种半圆试件产生的水平应变进行分析,定量描述沥青混合料的损伤开裂特性。采用半圆弯拉试验(SCB)分析两种试件的蠕变应变能(DCSE),并与基于DIC技术下的损伤开裂指标进行相关性分析。试验结果表明:水平应变场中数值较大的点与试件损伤开裂的演化有密切关系;CR-WMA和CR-HMA的抗损伤开裂性能随着盐浓度的增加先降低后升高,且在盐浓度为8%时最差;无论是水冻还是盐冻条件下,CR-WMA的损伤累积密度D_E值和D_CSE值较CR-HMA高,说明CR-WMA抗开裂性能及抗盐侵蚀能力均优于CR-HMA;发现D_E和D_CSE具有较好的相关性,验证了DIC技术评价沥青混合料损伤开裂特性的合理性。

关键词: 冻融循环, 盐侵蚀, 数字图像技术, 温拌胶粉改性沥青混合料, 损伤开裂

Abstract: In order to scientifically analyze the effect of deicing salt erosion on the cracking characteristics of warm rubber powder modified asphalt mixture (CR-WMA) and hot rubber powder modified asphalt mixture (CR-HMA) under the action of freeze-thaw cycles, application of digital image (DIC) technique for three-point bending test repeated loading levels of the two semi-circular pieces under the test strain generated analysis were used for quantitative description damage cracking of asphalt mixture. The semicircular bending tensile test (SCB) was used to analyze the creep strain energy (DCSE) of the two specimens, and the correlation analysis with the damage and cracking index based on DIC technology was carried out. The test results show that the point with a larger value in the horizontal strain field is closely related to the evolution of damage and cracking of the specimen. The damage and cracking resistance of CR-WMA and CR-HMA first decreases and then increases with the increase of salt concentration at worst concentration of 8%. Whether it is frozen or salt water freezing conditions, D_E value and the value CR-WMA D_CSE relatively high CR-HMA, described CR-WMA cracking resistance and were superior erosion salt CR-HMA: it is found that D_E and D_CSE have a good correlation, which verifies the rationality of the DIC technology to evaluate the cracking characteristics of asphalt mixtures.

Key words: freeze-thaw cycle, salt erosion, digital image technology, warm rubber powder modified asphalt mixture, damage cracking

中图分类号:

U414

冯蕾, 陈征, 王岚, 罗鑫. 冻融循环作用下盐浓度对温拌胶粉改性沥青混合料开裂特性影响[J]. 硅酸盐通报, 2021, 40(5): 1743-1750.

FENG Lei, CHEN Zheng, WANG Lan, LUO Xin. Effect of Salt Concentration on CR-WMA Cracking Characteristics under Freeze-Thaw Cycles[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(5): 1743-1750.

参考文献

[1] 左锋,叶奋.国外温拌沥青混合料技术与性能评价[J].中外公路,2007,27(6):164-168.
ZUO F, YE F. Technology and performance evaluation of warm mix asphalt mixtures in foreign countries[J]. Journal of China and Foreign Highway, 2007, 27(6): 164-168 (in Chinese).
[2] 徐世法,颜彬,季节,等.高节能低排放型温拌沥青混合料的技术现状与应用前景[J].公路,2005,50(7):195-198.
XU S F, YAN B, JI J, et al. Technical status and application prospect of high energy saving and low emission warm mix asphalt mixture[J]. Highway, 2005, 50(7): 195-198 (in Chinese).
[3] 马浩.温拌胶粉改性沥青混合料性能与环保功效研究[D].西安:长安大学,2017.
MA H. Asphalt mixture performance and environmental effects of warm mix powder[D]. Xi’an: Chang’an University, 2017 (in Chinese).
[4] 崔亚楠,韩吉伟,冯蕾,等.盐冻循环条件下改性沥青微细观结构[J].吉林大学学报(工学版),2017,47(2):452-458.
CUI Y N, HAN J W, FENG L, et al. Microstructure of asphalt under salt freezing cycles[J]. Journal of Jilin University (Engineering and Technology Edition), 2017, 47(2): 452-458 (in Chinese).
[5] YI J Y, SHEN S H, MUHUNTHAN B, et al. Viscoelastic-plastic damage model for porous asphalt mixtures: application to uniaxial compression and freeze-thaw damage[J]. Mechanics of Materials, 2014, 70: 67-75.
[6] 罗蓉,柳子尧,黄婷婷,等.冻融循环对沥青混合料内水气扩散的影响[J].中国公路学报,2018,31(9):20-26+64.
LUO R, LIU Z Y, HUANG T T, et al. Effect of freezing-thawing cycles on water vapor diffusion in asphalt mixtures[J]. China Journal of Highway and Transport, 2018, 31(9): 20-26+64 (in Chinese).
[7] ZHANG M, QIAN Z D. Effects of freeze-thaw cycles on fracture behavior of epoxy asphalt concrete[J]. Journal of Southeast University (English Edition), 2017, 33(1): 96-100.
[8] FENG D C, YI J Y, WANG D S, et al. Impact of salt and freeze-thaw cycles on performance of asphalt mixtures in coastal frozen region of China[J]. Cold Regions Science and Technology, 2010, 62(1): 34-41.
[9] ZHANG J, CAI Y X, YE W J, et al. On the use of the digital image correlation method for heterogeneous deformation measurement of porous solids[J]. Optics and Lasers in Engineering, 2011, 49(2): 200-209.
[10] RAMOS E, GUTIERREZ A, TIRADO C, et al. Explaining overlay tester results with digital image correlation and finite element analysis[C]//International Conference on Transportation and Development 2016. USA: American Society of Civil Engineers, 2016: 884-894.
[11] JIANG J W, NI F J. Evaluation of fatigue property of asphalt mixtures based on digital image correlation method[J]. Journal of Southeast University (English Edition), 2017, 33(2): 216-223.
[12] SAFAVIZADEH S A, KIM Y R. DIC technique to investigate crack propagation in grid-reinforced asphalt specimens[J]. Journal of Materials in Civil Engineering, 2017, 29(6): 04017011.
[13] 易军艳,SHEN Shihui,MUHUNTHAN Balasingam,等.多孔沥青混合料粘弹塑性损伤模型[J].哈尔滨工业大学学报,2014,46(2):66-71.
YI J Y, SHEN S H, BALASINGAM M, et al. Viscoelastic-plastic damage model of porous asphalt mixtures[J]. Journal of Harbin Institute of Technology, 2014, 46(2): 66-71 (in Chinese).
[14] 王端宜,刘敬辉,刘宇.沥青混合料粘弹塑性断裂参数的研究[J].华南理工大学学报(自然科学版),2009,37(11):7-11+21.
WANG D Y, LIU J H, LIU Y. Investigation into viscoelastic-plastic fracture parameters of asphalt mixture[J]. Journal of South China University of Technology (Natural Science Edition), 2009, 37(11): 7-11+21 (in Chinese).
[15] 栾利强,田小革.沥青混合料疲劳损伤的非线性分析[J].建筑材料学报,2012,15(4):508-512.
LUAN L Q, TIAN X G. Non-linear analysis of fatigue damage of asphalt mixture[J]. Journal of Building Materials, 2012, 15(4): 508-512 (in Chinese).
[16] 刘宝奎.盐冻融作用下沥青混合料性能及破坏机理研究[D].西安:长安大学,2017.
LIU B K. Study on the properties of asphalt mixture and its failure mechanism under freeze-thaw cycles with deicers[D]. Xi’an: Chang’an University, 2017 (in Chinese).
[17] 王岚,王宇.盐冻破坏下沥青混合料的抗裂性能及影响因素[J].建筑材料学报,2016,19(4):773-778.
WANG L, WANG Y. Influence factors of crack resistance of asphalt mixture under the damage of deicing salt and freezing-thawing cycles[J]. Journal of Building Materials, 2016, 19(4): 773-778 (in Chinese).
[18] 冯娟.温拌沥青胶结料降粘机理研究[D].乌鲁木齐:新疆大学,2013.
FENG J. Study on the mechanism of warm mix asphalt binder viscosity reduction[D]. Urumqi: Xinjiang University, 2013 (in Chinese).
[19] 冉维廷.温拌沥青混合料沥青降粘机理研究[D].济南:山东建筑大学,2012.
RAN W T. Study on viscosity reduction mechanism of warm-mixed asphalt mixture[D]. Jinan: Shandong Jianzhu University, 2012 (in Chinese).
[20] ROQUE R, BIRGISSON B, SANGPETNGAM B, et al. Hot mix asphalt fracture mechanics: a fundamental crack growth law for asphalt mixtures[C]//Asphalt Paving Technology: Association of Asphalt Paving Technologists-Proceedings of the Technical Sessions. 2002, 71: 816-827.

冻融循环作用下盐浓度对温拌胶粉改性沥青混合料开裂特性影响

Effect of Salt Concentration on CR-WMA Cracking Characteristics under Freeze-Thaw Cycles

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	高金瑞, 饶美娟, 张克昌, 邓青山. 铁相组分对铁相和高铁低钙水泥熟料水化性能及抗侵蚀性能影响[J]. 硅酸盐通报, 2021, 40(4): 1097-1102.
[2]	陈逸明, 林培桐, 李云龙, 刘锦红, 汪峻峰, 鲁刘磊. 高抗蚀胶凝材料的制备及其抗硫酸盐侵蚀性能研究[J]. 硅酸盐通报, 2021, 40(4): 1116-1127.
[3]	穆松, 郭政, 刘光严, 周莹, 谢德擎, 蔡景顺, 刘凯. 高浓度硫酸盐环境下桥梁桩基混凝土防腐技术[J]. 硅酸盐通报, 2021, 40(4): 1213-1219.
[4]	王岚, 郭志祥, 张宝鑫, 宋长振, 何立琦. 盐冻融循环下温/热拌胶粉改性沥青混合料高低温性能研究[J]. 硅酸盐通报, 2021, 40(4): 1395-1404.
[5]	薛文, 王腾, 程文杰, 沈鸿儒, 李乙, 陈江瑛, 朱瑶宏. 低温冻融循环对陶粒混凝土动态力学性能的影响[J]. 硅酸盐通报, 2021, 40(3): 821-828.
[6]	陶攀. 干湿-冻融循环下水泥固化淤泥土的力学性能与裂隙发育特征[J]. 硅酸盐通报, 2021, 40(1): 34-40.
[7]	刘潮;水中和;高旭;马赛. 碱激发煤矸石-高炉矿渣复合材料性能评价[J]. 硅酸盐通报, 2020, 39(9): 2877-2884.
[8]	王丽英;骆文进;王红梅;李鑫鑫. 盐-冻耦合作用下水泥基风积沙改性土基坑填料的性能研究[J]. 硅酸盐通报, 2020, 39(9): 2912-2918.
[9]	杨文武;杜蓬娟;范伟;李想. 海工磨细矿渣混凝土的冻渗性与孔结构研究[J]. 硅酸盐通报, 2020, 39(7): 2134-2138.
[10]	赵旭东;刘开志;陈杰;覃宇坤;陈祎明;赵宇航;肖勋光;水中和. 活化煤矸石生态型混凝土长期性能及水化特性的研究[J]. 硅酸盐通报, 2020, 39(6): 1757-1764.
[11]	樊晋源;姜屹;王利民;丁风宇;郭亮;段平. 剑麻-PVA混杂纤维增强地聚物抗硫酸盐侵蚀性能研究[J]. 硅酸盐通报, 2020, 39(5): 1430-1437.
[12]	张灵灵;陆春华;徐可;宣广宇;倪铭志. 荷载裂缝和养护龄期对混凝土内氯离子传输影响研究[J]. 硅酸盐通报, 2020, 39(4): 1100-1106.
[13]	张萌. 硫酸盐腐蚀对混凝土微观结构特征的影响研究[J]. 硅酸盐通报, 2020, 39(4): 1160-1165.
[14]	郭乐乐;靳文强;张家玮;王琦;赵建昌. 冻融环境下CFRP-粘土砖抗剪性能试验研究[J]. 硅酸盐通报, 2020, 39(3): 798-803.
[15]	黄道军;李东华;张镇山;王景辉;黄克峰;李永靖;张淑坤. 冻融循环影响下水泥、煤矸石改良粉土的力学特性研究[J]. 硅酸盐通报, 2020, 39(2): 416-421.