活性掺合料对混凝土抗碳化性能影响的研究

硅酸盐通报 ›› 2021, Vol. 40 ›› Issue (2): 439-446.

所属专题：水泥混凝土

活性掺合料对混凝土抗碳化性能影响的研究

王艺霖, 王顺尧, 刘巧玲

山东建筑大学土木工程学院,建筑结构加固改造与地下空间工程教育部重点实验室,济南 250101

收稿日期:2020-08-05 修回日期:2020-11-08 出版日期:2021-02-15 发布日期:2021-03-10
作者简介:王艺霖(1981—),男,博士,副教授。主要从事混凝土结构耐久性方面的研究。E-mail:xgwang_wang@163.com
基金资助:
教育部“长江学者和创新团队发展计划”(IRT13075)

Influences of Active Admixtures on Anti-Carbonization Performance of Concrete

WANG Yilin, WANG Shunyao, LIU Qiaoling

Key Laboratory of Building structural Retrofitting and Underground Space Engineering of Ministry of Education, School of Civil Engineering, Shandong Jianzhu University, Jinan 250101, China

Received:2020-08-05 Revised:2020-11-08 Online:2021-02-15 Published:2021-03-10

摘要/Abstract

摘要： 研究了强度等级(C30和C45)、龄期(28 d和120 d)、矿物掺和料(矿粉和粉煤灰)质量掺量对掺有脂肪族高效减水剂(SAF)的混凝土抗碳化性能的影响,并建立了C30/C45混凝土在28 d/120 d龄期的碳化深度与矿粉/粉煤灰掺量比例之间的回归模型。结果表明:水胶比的降低、养护龄期的延长都能提高水泥石的密实度,从而提高抗压强度和抗碳化性能;混凝土抗碳化性能随矿粉掺量的上升、粉煤灰掺量的下降而提高;当矿粉掺量占胶凝材料质量的37.5%时,C30混凝土的抗碳化性能最佳;当矿粉掺量占胶凝材料质量的31.9%时,C45混凝土的抗碳化性能最佳;当龄期增加时,粉煤灰掺量比例越大则碳化深度的下降幅度越大;矿粉和粉煤灰掺量的相对比例变化时,对低强度混凝土的影响程度要大于高强度混凝土。

关键词: 混凝土, 粉煤灰, 矿粉, 碳化, 龄期

Abstract: The influence of strength grade (C30 and C45), age (28 d and 120 d) and mineral admixture (mineral powder and fly ash) mass content on the anti-carbonization performance of concrete mixed with high efficiency aliphatic superplasticizer(SAF) was studied. A regression model between the carbonization depth of C30/C45 concrete at 28 d/120 d age and the proportion of mineral powder/fly ash was established. The results show that the reduction of water-binder ratio and the extension of curing age improve the compactness of cement stone, which improve the compressive strength and carbonization resistance. The anti-carbonization performance of concrete increases with the increase in the amount of mineral powder and the decrease in the amount of fly ash. When the mass fraction of mineral powder in the cementing material is 37.5%, the carbonization resistance of C30 concrete is the best. When the mass fraction of mineral powder in the cementing material is 31.9%, the carbonization resistance of C45 concrete is the best. When the age increases, the greater the proportion of fly ash, the greater the decrease in carbonization depth. When the relative proportion of mineral powder and fly ash content changes, the degree of influence on low-strength concrete is greater than that of high-strength concrete.

Key words: concrete, fly ash, mineral powder, carbonization, age

中图分类号:

TU528

王艺霖, 王顺尧, 刘巧玲. 活性掺合料对混凝土抗碳化性能影响的研究[J]. 硅酸盐通报, 2021, 40(2): 439-446.

WANG Yilin, WANG Shunyao, LIU Qiaoling. Influences of Active Admixtures on Anti-Carbonization Performance of Concrete[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2021, 40(2): 439-446.

参考文献

[1] 刘海峰,马荷姣,刘宁,等.粉煤灰及沙漠砂对混凝土抗碳化性能的影响[J].硅酸盐通报,2017,36(11):3823-3828+3847.
LIU H F, MA H J, LIU N, et al. Influence of fly ash and desert sand on the carbonation resistance property of concrete[J]. Bulletin of the Chinese Ceramic Society, 2017, 36(11): 3823-3828+3847 (in Chinese).
[2] SAMIMI K, KAMALI-BERNARD S, MAGHSOUDI A A. Durability of self-compacting concrete containing pumice and zeolite against acid attack, carbonation and marine environment[J]. Construction and Building Materials, 2018, 165: 247-263.
[3] LU C F, WANG W, LI Q T, et al. Effects of micro-environmental climate on the carbonation depth and the pH value in fly ash concrete[J]. Journal of Cleaner Production, 2018, 181: 309-317.
[4] 容志刚,黄萍萍,陈磊.矿粉和粉煤灰对混凝土抗碳化性能影响的研究[J].商品混凝土,2015(4):34-36.
RONG Z G, HUANG P P, CHEN L. Effect of mineral admixtures on the concrete carbonation resistance[J]. Ready-Mixed Concrete, 2015(4): 34-36 (in Chinese).
[5] 徐飞.混凝土抗碳化性能的定量设计及其服役寿命研究[D].南宁:广西大学,2014.
XU F. Research on quantitaive design of carbonation resistance of concrete and its service life[D]. Nanning: Guangxi University, 2014 (in Chinese).
[6] 伏程红,倪文,张旭芳,等.矿渣—粉煤灰基高性能混凝土专用胶凝材料[J].北京科技大学学报,2011,33(5):606-613.
FU C H, NI W, ZHANG X F, et al. Slag-fly ash based cementitious materials special for high performance concrete[J]. Journal of University of Science and Technology Beijing, 2011, 33(5): 606-613 (in Chinese).
[7] 杨益,宁翠萍.活性掺合料再生混凝土碳化性能试验研究和理论分析[J].混凝土,2017(5):94-98+102.
YANG Y, NING C P. Experimental study and theoretical analysis on carbonation performance of recycled concrete with active admixture[J]. Concrete, 2017(5): 94-98+102 (in Chinese).
[8] 彭华娟,陈建国.双掺粉煤灰及聚羧酸减水剂再生混凝土性能试验研究[J].粉煤灰综合利用,2018,31(1):3-6.
PENG H J, CHEN J G. Study on the influence of double-doped fly ash and polycarboxylate superplasticizer on properties of recycled aggregate concrete[J]. Fly Ash Comprehensive Utilization, 2018, 31(1): 3-6 (in Chinese).
[9] 张恺,尹志刚,程国敏,等.聚羧酸减水剂及不同掺合料对混凝土耐久性的试验研究[J].硅酸盐通报,2018,37(9):2974-2978+2984.
ZHANG K, YIN Z G, CHENG G M, et al. Experimental study on the durability of concrete with polycarboxylate superplasticizer and different admixtures[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(9): 2974-2978+2984 (in Chinese).
[10] 赵晶,邱晨,徐天博.聚羧酸混凝土耐久性分析[J].大连交通大学学报,2012,33(2):53-56.
ZHAO J, QIU C, XU T B. Polycarboxylate concerete durability[J]. Journal of Dalian Jiaotong University, 2012, 33(2): 53-56 (in Chinese).
[11] 张燕梅.复合外加剂对混凝土碳化性能的影响[J].商品混凝土,2012(12):33-35.
ZHANG Y M. The influence of compound admixture on the carbonization performance of concrete[J]. Ready-Mixed Concrete, 2012(12): 33-35 (in Chinese).
[12] 中华人民共和国住房和城乡建设部.普通混凝土长期性能和耐久性能试验方法标准:GB/T 50082—2009[S].北京:中国建筑工业出版社,2009.
Ministry of Housing and Urban-Rural Development of the People's Republic of China. Standard for test methods of long-term performance and durability of ordinary concrete: GB/T 50082—2009[S]. Beijing: China Building Industry Press, 2009.
[13] 黄勇,王边.S95矿粉对混凝土性能的影响[J].粉煤灰,2016,28(6):27-28.
HUANG Y, WANG B. Effect of S95 slag powder on the performance of concrete retraction[J]. Coal Ash, 2016, 28(6): 27-28 (in Chinese).
[14] 周万良,方坤河,詹炳根.掺粉煤灰、矿粉混凝土抗碳化性能研究[J].混凝土与水泥制品,2012(12):14-19.
ZHOU W L, FANG K H, ZHAN B G. Properties research on anti-carbonation of cement concrete added with fly ash and slag powder[J]. China Concrete and Cement Products, 2012(12): 14-19 (in Chinese).
[15] 张雷.矿粉混凝土在工程实践中的研究[J].四川水泥,2018(10):266+260.
ZHANG L. Research on slag concrete in engineering practice[J]. Sichuan Cement, 2018(10): 266+260 (in Chinese).

活性掺合料对混凝土抗碳化性能影响的研究

Influences of Active Admixtures on Anti-Carbonization Performance of Concrete

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘恩铭, 林明强, 谢群. 再生粗骨料混凝土抗冻性能研究进展[J]. 硅酸盐通报, 2022, 41(9): 2963-2978.
[2]	韩强强, 路伟, 姜鲁, 王亚妹. 微生物菌落体系对混凝土裂缝自修复效果的影响综述[J]. 硅酸盐通报, 2022, 41(9): 2993-3007.
[3]	佘亮, 傅平丰, 邓威, 陈雨齐, 王显聪. 联合活化多元辅助胶凝材料对蒸养混凝土性能的影响[J]. 硅酸盐通报, 2022, 41(9): 3059-3067.
[4]	肖世玉, 彭丙杰, 吴涛, 罗小东, 陶俊. 砂率及机制砂特性对混凝土流动性与颗粒膜层厚度的影响[J]. 硅酸盐通报, 2022, 41(9): 3068-3076.
[5]	单继雄, 李军, 侯永生, 胡艳民, 刘畅. 钙铝类水滑石对混凝土抗盐冻性能的影响[J]. 硅酸盐通报, 2022, 41(9): 3084-3090.
[6]	余波, 黄俊辉, 汪加梁, 秦荷成. 考虑材料参数和应力水平的氯离子扩散系数多因素预测模型[J]. 硅酸盐通报, 2022, 41(9): 3091-3099.
[7]	王萧萧, 冯蓉蓉, 荆磊, 刘曙光, 闫长旺, 姜琳. 冰凌作用下天然浮石混凝土磨损规律研究[J]. 硅酸盐通报, 2022, 41(9): 3100-3106.
[8]	楼建敏, 张国辉, 杨振东, 孙俊崇, 李虎. 基于楔入劈拉法的湿态混凝土双K断裂特性试验研究[J]. 硅酸盐通报, 2022, 41(9): 3107-3114.
[9]	周兰兰, 梅军鹏, 李海南, 牛寅龙, 李雨浓, 徐智东, 王智鑫, 何香香. 蒸汽养护条件下甲酸钙/纳米C-S-H复合对粉煤灰-水泥体系早期水化的影响[J]. 硅酸盐通报, 2022, 41(9): 3154-3161.
[10]	赵雅明, 张振, 王畔, 张明飞. 矿物掺合料对UHPC性能的影响[J]. 硅酸盐通报, 2022, 41(9): 3170-3175.
[11]	王晨晨, 王学志, 陈东林, 贺晶晶. 基于正交试验的粉煤灰-硅锰渣再生混凝土力学性能研究[J]. 硅酸盐通报, 2022, 41(9): 3190-3201.
[12]	向宇, 余金山, 王洪磊, 周新贵. 碳化硅纤维高温抗氧化性研究进展[J]. 硅酸盐通报, 2022, 41(9): 3234-3242.
[13]	董博, 闵昌胜, 陈博, 邓承继, 谢哲, 杨千秋, 丁军, 祝洪喜, 杨昕雨, 余超. 陶瓷相结合粉煤灰漂珠轻质隔热材料的制备及性能研究[J]. 硅酸盐通报, 2022, 41(9): 3315-3323.
[14]	韦建刚, 陈荣, 黄伟, 陈镇东, 陈宝春, 陈培标, 朱卫东. 静水压力下超高性能混凝土的抗氯离子渗透性能[J]. 硅酸盐通报, 2022, 41(8): 2706-2715.
[15]	张庆章, 方燕, 宋力, 徐宁, 康子寒. 混凝土孔结构及其分形维数与氯离子扩散性能的关系[J]. 硅酸盐通报, 2022, 41(8): 2716-2727.